水星 Mercury 225X EFI PROMAX 0T430254 THRU 0T819605 - 爆炸图零件明细

两冲程电喷 EFI · Cat.# 90-80393402 · 共 37 个部位 · 1556 条零件

1空气处理器 2下罩 3线圈板总成 4曲轴活塞与连杆 5气缸体与端盖 6气缸盖 7驱动轴壳与排气管 8电气板总成 9排气分隔板和排气板 10飞轮/交流发电机 11燃油系统 12衬垫组件全套动力头和下部单元 13齿轮箱驱动轴-标准/反向-运动大师 14齿轮箱驱动轴-TorqueMaster 15齿轮箱螺旋桨轴-反向旋转-运动大师 16齿轮箱螺旋桨轴-标准旋转-运动大师 17齿轮箱螺旋桨轴-Torque Master 18液压泵及安装支架 19液压泵总成 20仪表/附件 21钥匙开关总成 22润滑油系统 23动力升降组件 8M0231193 24动力升降组件金属马达壳 25动力升降组件（塑料马达壳体）26维修/支撑材料 27启动电机 28转向连接套件 29旋转支架和转向臂(长型)30旋转支架和转向臂(短型)31油门杆和换挡轴(序列号0T818234及以下)32油门杆和换挡轴(序列号0T818235及以上)33顶罩 34艉板支架(长型)35艉板支架(短型)36油气分离器组件 37水管

图 1空气处理器 Air Handler

REF	零件编号	中文名称	英文名称	数量
-	841085T05	空气处理器总成	AIR HANDLER ASSEMBLY	1
1	858708T1	空气集气室套件	PLENUM KIT Air	1
2	840485	衬垫	GASKET	1
3	840396T1	适配板	ADAPTER PLATE	1
4	840484	衬垫	GASKET	1
5	840805T1	簧片阀总成	REED BLOCK ASSEMBLY	6
6	55715	螺钉(.250-20×0.880)	SCREW (.250-20 x .880)	12
7	840892	燃油接头	FITTING Fuel	1
8	862053	O型圈	O-RING	2
9	840482A2	线束总成	HARNESS ASSEMBLY	1
10	840889T	燃油导轨	FUEL RAIL	1
11	840422A1	板组件套件	PLATE KIT	2
12	627021	O型圈(.301 x .070)	O-RING (.301 x .070)	2
13	188642	螺钉(#8-32 x .500)	SCREW (#8-32 x .500)	4
14	840893	护孔环	GROMMET	6
15	840891	隔套	SPACER	12
16	812987	螺钉 (#10-24 x 1.250)	SCREW (#10-24 x 1.250)	6
17	63153	J型卡扣	J CLIP	2
18	840481001	喷油器总成	INJECTOR ASSEMBLY	6
18	840481T01	喷油器总成	INJECTOR ASSEMBLY	6
19	889575	传感器总成	SENSOR ASSEMBLY	1
19	8M0214984	温度传感器	SENSOR Temperature	1
19	885342001	传感器总成	SENSOR ASSEMBLY	1
19	8M0148668	传感器总成	SENSOR ASSEMBLY	1
20	627021	O型圈(.301 x .070)	O-RING (.301 x .070)	1
20	888814	O型圈(0.351 x 0.072)	O-RING (.351 x .072)	1
20	896699	O型圈（1.78毫米 x 0.08毫米）	O-RING (1.78 mm x .08 mm)	1
21	854445	MAP传感器	SENSOR MAP	1
21	8M0237529	MAP传感器	SENSOR MAP	1
22	884522	MAP传感器支架	BRACKET MAP Sensor	1
23	1993716	螺钉(M6 x 16)	SCREW (M6 x 16)	1
24	883957T1	节气门体套件	THROTTLE BODY KIT	1
25	855423	O型圈	O-RING	1
26	82130040	螺钉(M6 x 40)	SCREW (M6 x 40)	4
27	55098	J型卡扣	J CLIP	2
27	8M0024808	J型夹	J-CLIP	2
28	4001987	螺钉(M4×16)	SCREW (M4 x 16)	2
29	879892T04	泵总成	PUMP ASSEMBLY	1
29	8M0185615	EFI机油泵	OIL PUMP EFI	1
30	855364	衬套	BUSHING	3
31	855362	护孔环	GROMMET	3
31	855362001	护孔环	GROMMET	3
32	817274	垫圈(0.344×1.00×0.063)不锈钢	WASHER (.344 x 1.00 x .063) Stainless Steel	3
33	81893430	螺钉 (M8 x 30)	SCREW (M8 x 30)	3
33	81893435	螺钉(M8×35)	SCREW (M8 x 35)	3
34	841014A1	接头总成	FITTING ASSEMBLY	1
35	20385	O型圈(.239 x .070)	O-RING (.239 x .070)	2
36	841022	卡箍	CLAMP	1
37	883376	螺钉(#10-24 x .375)	SCREW (#10-24 x .375)	1
38	856880	软管卡箍（15.3）	CLAMP Hose (15.3)	3
38	8M0214964	卡箍	CLAMP	3
39	774572	软管(48.00英寸散装)(裁切至3.00英寸)	HOSE (48.00 Inches Bulk) (Cut to 3.00 Inch Length)	1
40	774572	软管(48.00英寸散装)(裁切至11.50英寸)	HOSE (48.00 Inches Bulk) (Cut to 11.50 Inch Length)	1
41	816296K2	燃油滤清器	FILTER Fuel	1
42	880194T05	盖总成	COVER ASSEMBLY	1
43	840525	护孔环	GROMMET	2
44	20116	护孔环	GROMMET	1
45	8261151	连接器卡箍	CLAMP Connector	1
46	97224	J型卡扣	J CLIP	2
47	817504	螺钉（0.250-20 x 1.500）不锈钢	SCREW (.250-20 x 1.500) Stainless Steel	12
48	55715	螺钉(.250-20×0.880)	SCREW (.250-20 x .880)	4
49	55098	J型卡扣	J CLIP	1
49	8M0024808	J型夹	J-CLIP	1
50	855613	护孔环	GROMMET	1
-	813859A02	衬垫套件	GASKET SET	1

图 2下罩 Bottom Cowl

REF	零件编号	中文名称	英文名称	数量
1	849479A8	底壳	BOTTOM PAN	1
1	849479T5	底壳	BOTTOM PAN	1
2	848810	锁扣支架	BRACKET Latch	1
3	28782	螺钉(.312-18 x .880)不锈钢	SCREW (.312-18 x .880) Stainless Steel	2
4	814806	垫圈 (.344 x .688 x .065) 不锈钢	WASHER (.344 x .688 x .065) Stainless Steel	2
4	8M0204690	垫圈 (.344 x .688 x .065) 不锈钢	WASHER (.344 x .688 x .065) Stainless Steel	2
5	812707	衬套	BUSHING	2
6	848985	密封件	SEAL	1
7	848815T1	手柄	HANDLE	1
8	F2047	波形垫圈	WASHER Wave	1
9	889566	凸轮	CAM	1
9	8M0001081	凸轮	CAM	1
10	4002316	垫圈(6.60 X 17.0 X 1.5不锈钢)	WASHER (6.60 X 17.0 X 1.5SS)	1
10	8M0214930	垫圈6.60 x 17.0 x 1.5	WASHER 6.60 x 17.0 x 1.5	1
11	28635	不锈钢螺丝(.250-20 x .620)	SCREW (.250-20 x .620) Stainless Steel	1
12	849830T1	闩锁	LATCH	1
13	849011	螺钉(.250-20 x .750)	SCREW (.250-20 x .750)	2
14	849480T2	安装板	PLATE	1
14	849480T	安装板	PLATE	1
15	38601	螺丝(.250-28 x 1.250)	SCREW (.250-28 x 1.250)	14
16	826709109	不锈钢螺母(.250-28)	NUT (.250-28) Stainless Steel	14
17	29245	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	14
17	8M0204649	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	14
18	849750	护孔环	GROMMET	1
19	8177133	护孔环	GROMMET	2
20	690201	螺钉(#10-32 x .875)	SCREW (#10-32 x .875)	2
21	826709106	螺母 (#10-32) 不锈钢	NUT (#10-32) Stainless Steel	2
21	8M0204718	螺母	NUT	2
22	849767	密封件	SEAL	2
22	8M0043399	密封件	SEAL	2
23	849766	密封件	SEAL	1
23	8M0043398	密封件	SEAL	1
24	849765	密封件	SEAL	1
24	8M0043397	罩盖密封条	SEAL-COWL	1
25	8496191	支撑架	BRACE	2
26	849011	螺钉(.250-20 x .750)	SCREW (.250-20 x .750)	4
27	8267098	螺母 (.250-20) 不锈钢	NUT (.250-20) Stainless Steel	4
28	88621	固定座	RETAINER	1
29	849831A1	锁手柄总成	LATCH HANDLE ASSEMBLY	1
29	8M0192237	闩锁手柄	LATCH HANDLE	1
30	849833	双头螺柱(.250-20 x 3.310)	STUD (.250-20 x 3.310)	2
30	843118	双头螺柱（0.250-20×3.45）	STUD (.250-20 x 3.45)	2
30	843118	双头螺柱（0.250-20×3.45）	STUD (.250-20 x 3.45)	2
31	849832	销	PIN	1
32	NSS	标贴(不单独销售)	NOT SOLD SEPARATE Decal	1
33	849837	弹簧(.360外径)	SPRING (.360 Outside Diameter)	2
33	842776	弹簧（外径0.420英寸）	SPRING (.420 Outside Diameter)	2
34	846673	不锈钢垫圈(.265 x .500 x .060)	WASHER (.265 x .500 x .060) Stainless Steel	2
35	8267098	螺母 (.250-20) 不锈钢	NUT (.250-20) Stainless Steel	2
36	8569901	升降倾斜开关	SWITCH Trim	1
36	8M0235191	升降倾斜开关	SWITCH Trim	1
37	849534A1	围板	SKIRT	1
38	849000	螺母	NUT	6
39	F2030	螺钉 (.250-20 x 1.250) 不锈钢	SCREW (.250-20 x 1.250) Stainless Steel	6
40	94848	接头	FITTING	1 or 2
41	32298	堵头	PLUG	2
42	817362	盖帽	CAP	1
43	89774	堵头	PLUG	1
44	126021	护孔环	GROMMET	1
44	12602002	护孔环	GROMMET	1
45	57009	护孔环	GROMMET	1
45	57009001	护孔环	GROMMET	1
46	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	AR
47	849751	堵头	PLUG	2

图 3线圈板总成 Coil Plate Assembly

REF	零件编号	中文名称	英文名称	数量
1	880188F1	线圈板	PLATE Coil	1
2	8502341	衬套	BUSHING	4
3	833155	护孔环	GROMMET	4
4	49436	垫圈	WASHER	4
5	858414A1	编织电缆总成	CABLE ASSEMBLY Braided	2
6	70132	垫圈(0.323×0.563×0.063)不锈钢	WASHER (.323 x .563 x .063) Stainless Steel	2
6	8M0042642	垫圈(.323 x .562 x .063)	WASHER (.323 x .562 x .063)	2
7	60411	螺钉(.312-18 x 1.250)	SCREW (.312-18 x 1.250)	4
8	29245	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	3
8	8M0204649	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	3
9	82129110	螺丝 (M6 x 10)	SCREW (M6 x 10)	3
10	879984A1	线圈套件	COIL KIT	6
10	8M0077471	点火线圈	IGNITION COIL	6
11	82129130	螺钉 (M6 x 30)	SCREW (M6 x 30)	12
12	859747	联轴器	COUPLER	1
12	8M0214971	耦合接头 (4 MM)	COUPLER Fitting (4 MM)	1
13	882757T1	线圈线束总成	HARNESS ASSEMBLY Coil	1
14	885185	火花塞	SPARK PLUG	6
14	8M0046265	火花塞@4	SPARK PLUG @4	6
15	881908T	电缆组	CABLE SET	1
16	883066	夹子 (.865)	CLIP (.865)	2
17	881879A7	传感器套件 (0-50 PSI)	SENSOR KIT (0-50 PSI)	1
17	8M0157742	水压传感器	SENSOR Water Pressure	1
18	881879A6	传感器(0-100 PSI)	SENSOR (0 - 100 PSI)	1
18	881879T11	压力传感器 (0 - 100 PSI)	SENSOR Pressure (0 - 100 PSI)	1
18	881879A5	速度计传感器(0-200PSI)	SENSOR Speedometer (0-200 PSI)	1
19	859431	接头	FITTING	1
19	8M0207782	直通接头	FITTING Straight	1
20	85944975	管材(72.00英寸散装)(裁切至14.50英寸)	TUBING (72.00 Inches Bulk) (Cut To 14.50 Inch Length)	1
21	828991	卡扣	CLIP	1
21	828991T	卡扣	CLIP	1

图 4曲轴活塞与连杆 Crankshaft Pistons And Connecting Rods

REF	零件编号	中文名称	英文名称	数量
1	850690T7	曲轴总成	CRANKSHAFT ASSEMBLY	1
2	78662	耐磨套	WEAR SLEEVE	1
3	67923T	下滚珠轴承	BEARING Ball Lower	1
4	67446	环	RING	1
5	54196A6	托架总成	CARRIER ASSEMBLY	1
6	65800	填料	PACKING	1
7	67377	密封环	RING Sealing	9
7	67377T	密封环	RING Sealing	9
8	16756A6	轴承套件	BEARING KIT	2
9	NSS	不单独销售轴承座圈	NOT SOLD SEPARATE Race	2
10	840993T1	活塞	PISTON	3
10	841123T1	活塞	PISTON	AR
10	840992T1	活塞	PISTON	3
10	841124T1	活塞	PISTON	AR
11	840684A12	活塞环组	RING SET Piston	1
11	841139A12	活塞环组	RING SET Piston	AR
12	857196	锁紧环	LOCK RING	12
13	8M0081411	连杆总成	CONNECTING ROD ASSEMBLY	6
14	763491	螺钉(.312-24 x .875)	SCREW (.312-24 x .875)	12
15	812876	垫圈	WASHER	12
15	8M0012298	止推垫片	THRUST WASHER	12
16	8M0082405	轴承套件	BEARING KIT	6
17	822553	滚针轴承	BEARING Needle	174
17	8M0204691	滚针轴承@200	BRG-NEEDLE @200	174
-	813859A02	衬垫套件	GASKET SET	1
-	809430T02	动力头总成	POWERHEAD ASSEMBLY	1

图 5气缸体与端盖 Cylinder Block And End Caps

REF	零件编号	中文名称	英文名称	数量
1	858961T02	气缸体	CYLINDER BLOCK	1
2	847530	双头螺柱(.375-16/.375-24 x 2.040)	STUD (.375-16/.375-24 x 2.040)	2
2	8M0034443	螺柱	STUD	2
2	847530	双头螺柱(.375-16/.375-24 x 2.040)	STUD (.375-16/.375-24 x 2.040)	6
2	8M0034443	螺柱	STUD	6
3	847529	双头螺柱 (.375-16/.375-24 x 2.490)	STUD (.375-16/.375-24 x 2.490)	4
3	8M0034430	螺柱	STUD	4
3	670653	螺柱（.375 x 5.620）	STUD (.375 x 5.620)	2
3	670654	螺柱(.375-16/.375-24 x 5.620)	STUD (.375-16/.375-24 x 5.620)	2
3	847532	双头螺柱 (.375-16/.375-24 x 5.750)	STUD (.375-16/.375-24 x 5.750)	4
3	8M0034437	螺柱	STUD	4
3	784385	螺柱 (.375-16/.375-24 x 6.870)	STUD (.375-16/.375-24 x 6.870)	2
3	8M0034454	螺柱(.375-16/.375-24 x 6.87)	STUD (.375-16/.375-24 x 6.87)	2
4	43044	定位销-无孔(.375 x .625)	PIN Dowel - Without Hole (.375 x .625)	2
5	67296	轴承座销	PIN Bearing Race	2
5	8M0036405	销	PIN	2
6	8569662	支架	BRACKET	1
6	8M0111325	盖板	COVER	1
7	828213	螺钉(.312-18 x 1.500)六角法兰	SCREW (.312-18 x 1.500) Hex Flange	2
8	76867	下盖	COVER Bottom	1
9	828214	螺钉(.312-18 x 2.00)六角法兰	SCREW (.312-18 x 2.00) Hex Flange	2
10	66717	螺钉(.375-16 x 3.250)	SCREW (.375-16 x 3.250)	8
11	74824	螺钉(.312-18 x 1.250)	SCREW (.312-18 x 1.250)	6
12	26852	尼龙帽	CAP Nylon	1
13	856832	螺丝 (.250-20 x 1.750)	SCREW (.250-20 x 1.750)	1
14	64015	螺母 (.250-20)	NUT (.250-20)	1
15	883048	堵头(.500-14)	PLUG (.500-14)	1
16	8283582	传感器	SENSOR	1
16	8M0082988	曲轴位置传感器	SENSOR Crankshaft Position	1
17	40011107	不锈钢螺钉(M5x16)	SCREW (M5 x 16) Stainless Steel	2
18	8215832	特殊销（1.5英寸）	PIN Special (1.5 Inches)	1
19	832760T1	端盖总成	END CAP ASSEMBLY	1
20	54029	O型圈(2.800 x .103)	O-RING (2.800 x .103)	1
21	16756A4	轴承套件	BEARING KIT	1
22	NSS	不单独销售轴承座圈	NOT SOLD SEPARATE Bearing Race	1
23	41953	密封件	SEAL	1
24	881190	螺丝(.312-18 x 1.00)	SCREW (.312-18 x 1.00)	4
25	7809T1	端盖总成	END CAP ASSEMBLY	1
26	62700	O型圈(3.237 x .103)	O-RING (3.237 x .103)	1
27	41953	密封件	SEAL	2
28	28636	螺钉(.250-20 x .750)	SCREW (.250-20 x .750)	4
29	26992	锁紧垫圈(.250)不锈钢	LOCKWASHER (.250) Stainless Steel	4
30	81893414	螺钉（M8 x 14）	SCREW (M8 x 14)	1
31	88439A26	蓄电池负极电缆总成	CABLE ASSEMBLY Battery - Negative	1
32	426982	止回阀	CHECK VALVE	1
33	99130122	管材(20.00英尺散装)(裁切至19.00英寸长度)	TUBING (20.00 Feet Bulk) (Cut to 19.00 Inch Length)	1
33	892024122	管(240.00英寸散装)	TUBING (240.00 Inches Bulk)	1
34	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	2
35	8538821	节气门位置指示器安装支架	BRACKET Throttle Position Indicator Mount	1
36	8519371	节气门位置指示器杠杆	LEVER Throttle Position Indicator	1
37	82130025	螺钉(M6x25)	SCREW (M6 x 25)	3
38	856954	衬套	BUSHING	3
39	65567	不锈钢垫圈(0.265x0.750x0.048)	WASHER (.265 x .750 x .048) Stainless Steel	3
40	834985	护孔环	GROMMET	3
40	8M0190980	护孔环	GROMMET	3
41	83295211	油门位置指示器	INDICATOR Throttle Position	1
41	8M6005165	TPI	TPI	1
42	8508281	螺钉（#10-32 x 2.00）	SCREW (#10-32 x 2.00)	3
43	878175	连杆总成	LINK ASSEMBLY	1
43	8M0084738	连杆总成	LINK ASSY	1
44	426233	止回阀	CHECK VALVE	1
45	28700	卡箍	CLAMP	1
46	8248324	螺钉(M6 x 16)	SCREW (M6 x 16)	1
47	859172	卡箍	CLAMP	1
48	8582261	盖板	COVER	1
-	813859A02	衬垫套件	GASKET SET	1
-	809430T02	动力头总成	POWERHEAD ASSEMBLY	1

图 6气缸盖 Cylinder Head

REF	零件编号	中文名称	英文名称	数量
1	849496T12	气缸盖	CYLINDER HEAD	2
2	8584521	密封件	SEAL	2
2	8M0149612	气缸盖密封	SEAL CYLINDER HEA	2
3	8597721	密封件	SEAL	6
4	878217	螺丝 (.375-16 x 2.750)	SCREW (.375-16 x 2.750)	24
4	8M0125882	螺钉	SCREW	24
5	63779	定位销 (.250 x .625)	PIN Dowel (.250 x .625)	4
6	62386	衬垫	GASKET	2
6	8M0204714	衬垫@4	GASKET @4	2
7	90390A1	盖板套件	COVER KIT	2
8	14586	节温器	THERMOSTAT	2
9	40011149	螺钉 (M8 x 25) 不锈钢	SCREW (M8 x 25) Stainless Steel	4
10	687271	90度弯头 (.250-18) - 黄铜	FITTING (.250-18) 90 Degree - Brass	2
11	815504104	蜗杆卡箍	CLAMP Worm Gear	4
12	774572	软管 (48.00英寸整卷)(截取2.00英寸)(用于排水指示管)	HOSE (48.00 Inches Bulk) (Cut to 2.00 Inch Length)(To Telltail)	1
12	774572	软管 (48.00英寸整卷)(截取2.00英寸)(用于排气板)	HOSE (48.00 Inches Bulk) (Cut to 2.00 Inch Length)(To Exhaust Plate)	1
13	885342001	传感器总成	SENSOR ASSEMBLY	2
13	8M0148668	传感器总成	SENSOR ASSEMBLY	2
14	627021	O型圈(.301 x .070)	O-RING (.301 x .070)	2
14	888814	O型圈(0.351 x 0.072)	O-RING (.351 x .072)	2
14	896699	O型圈（1.78毫米 x 0.08毫米）	O-RING (1.78 mm x .08 mm)	2
15	822838	垫圈 (.401 x .745 x .097)	WASHER (.401 x .745 x .097)	24
-	813859A02	衬垫套件	GASKET SET	1
-	809430T02	动力头总成	POWERHEAD ASSEMBLY	1

图 7驱动轴壳与排气管 Drive Shaft Housing And Exhaust Tube

REF	零件编号	中文名称	英文名称	数量
1	8343T19	驱动轴壳体总成	HOUSING ASSEMBLY Driveshaft	1
2	59579	双头螺柱(.437-14/.437-20 x 2.812)	STUD (.437-14/.437-20 x 2.812)	2
3	849330	怠速排气套	BOOT Idle Exhaust	1
4	63474	螺钉(.500-20 x 6.00)	SCREW (.500-20 x 6.00)	2
4	898831	螺钉(.500-20 x 6.220)	SCREW (.500-20 x 6.220)	2
5	816054T1	下支架	MOUNT Lower	2
6	816056	垫圈	WASHER	4
7	82670817	螺母(.500-20)	NUT (.500-20)	2
7	898832	螺母(.500-20)	NUT (.500-20)	2
8	88238A10	接地线总成	CABLE ASSEMBLY Ground	1
9	67076	卡箍	CLAMP	2
9	8M0036782	卡箍	CLAMP	2
10	66727	螺钉(.312-18 x 1.250)	SCREW (.312-18 x 1.250)	4
11	67077T	黑色盖	COVER Black	2
11	8M4500752	盖板	COVER	2
12	88417	螺钉(#12-24×0.620)	SCREW (#12-24 x .620)	4
13	35521	螺母	NUT	4
14	88238A10	接地线总成	CABLE ASSEMBLY Ground	1
15	41508	螺钉(0.250-20×0.500)不锈钢	SCREW (.250-20 x .500) Stainless Steel	1
16	822838	垫圈 (.401 x .745 x .097)	WASHER (.401 x .745 x .097)	10
17	46335	螺母 (.375-24)	NUT (.375-24)	10
18	64649	堵头	PLUG	1
19	18276	排气管	TUBE Exhaust	1
19	18276T	排气管	EXHAUST TUBE	1
20	66350	下部密封件	SEAL Lower	1
20	66350001	密封件	SEAL	1
21	177261	上密封件	SEAL Upper	1
21	8M0039076	密封件	SEAL	1
22	818900T8	驱动轴壳体	HOUSING Driveshaft	1
22	818900T24	驱动轴壳体	HOUSING Driveshaft	1
22	818900T24	驱动轴壳体	HOUSING Driveshaft	1
23	59579	双头螺柱(.437-14/.437-20 x 2.812)	STUD (.437-14/.437-20 x 2.812)	2
24	818908	双头螺柱 (.500-13/.500-20 x 4.120)	STUD (.500-13/.500-20 x 4.120)	2
25	816056	垫圈	WASHER	2
26	82670817	螺母(.500-20)	NUT (.500-20)	2
26	898832	螺母(.500-20)	NUT (.500-20)	2
27	818909	排气挡板	PLATE Exhaust Blockoff	1
27	8189091	排气挡板	PLATE Exhaust Blockoff	1
28	39349	螺钉(.312-18×0.75)不锈钢	SCREW (.312-18 x .750) Stainless Steel	1
29	847539	垫圈	WASHER	1
30	822838	垫圈 (.401 x .745 x .097)	WASHER (.401 x .745 x .097)	10
31	826709113	不锈钢螺母 (.375-24)	NUT (.375-24) Stainless Steel	2
31	8M0204726	黄铜螺母 (.375-24)	NUT (.375-24) Brass	2
31	82671013	不锈钢螺母 (.375-24)	NUT (.375-24) Stainless Steel	8
32	817717T8	排气延长板总成	PLATE ASSEMBLY Exhaust Extension	1
33	44260	固定座	RETAINER	1
34	28635	不锈钢螺丝(.250-20 x .620)	SCREW (.250-20 x .620) Stainless Steel	1
35	26992	锁紧垫圈(.250)不锈钢	LOCKWASHER (.250) Stainless Steel	1
36	91903	螺钉(.437-14 x 1.750)	SCREW (.437-14 x 1.750)	3
37	822836	垫圈(.445 x .805 x .108)	WASHER (.445 x .805 x .108)	3
38	822836	垫圈(.445 x .805 x .108)	WASHER (.445 x .805 x .108)	3
39	859116	螺母(.437-20)	NUT (.437-20)	3
40	672951	水管	TUBE Water	1
40	8590971	水管	TUBE Water	1
40	8M0042788	长型水管	TUBE-WATER-LONG	1
41	991734	衬垫	GASKET	1
42	18233T18	隔板总成	PLATE ASSEMBLY	1
43	90192	螺钉(.250-20 x .750)不锈钢	SCREW (.250-20 x .750) Stainless Steel	6
44	20533	垫圈	WASHER	6
45	43044	定位销-无孔 (.375 x .625)(驱动轴壳体连接板)	PIN Dowel - Without Hole (.375 x .625) Plate to Drive Shaft Housing	2
45	823106	定位销 (0.875) 板至动力头	PIN Dowel (.875) Plate to Powerhead	2
45	8M0043826	定位销	PIN Dowel	2
46	38970	密封件	SEAL	1
47	183074	衬垫	GASKET	1
48	419424	排气管延长段	EXTENSION Exhaust	1
48	879288T71	排气管延长段	EXTENSION Exhaust	1
49	782461	衬垫	GASKET	1
50	58893	双头螺柱 (0.250-28x1.310)	STUD (.250-28 x 1.310)	6
50	8M0030694	螺钉(0.25-20×1.00)	SCREW (0.25-20 x 1.00)	6
51	30506	螺母(.250-28)	NUT (.250-28)	6
-	813859A02	衬垫套件	GASKET SET	1

图 8电气板总成 Electrical Plate Assembly

REF	零件编号	中文名称	英文名称	数量
1	833137F1	安装板	PLATE	1
2	82129110	螺丝 (M6 x 10)	SCREW (M6 x 10)	3
3	858755	卡箍(1.00)	CLIP (1.00)	1
4	882751A1	继电器总成	RELAY ASSEMBLY	3
4	8M0207773	调整继电器总成	RELAY ASSEMBLY Trim	3
5	NSS	不单独销售贴纸-配平继电器	NOT SOLD SEPARATE Decal - Trim Relay	3
6	828102	支架	BRACKET	3
6	8M0207771	安装支架	BRACKET Mounting	3
7	818968	衬套	BUSHING	3
7	8M0214955	衬套	BUSHING	3
8	818967	护孔环	GROMMET	3
8	8M0207785	护孔环	GROMMET	3
9	82129125	螺丝(M6 x 25毫米)	SCREW (M6 x 25 mm)	4
10	91912	衬套	BUSHING	1
11	819514T16	升降线束总成	HARNESS ASSEMBLY Trim	1
12	859244T2	线束总成	HARNESS ASSEMBLY	1
12	859244A2	Smartcraft线束总成	HARNESS ASSEMBLY Smartcraft	1
13	88807A16	电缆总成 (4.00英寸) 黑色	CABLE ASSEMBLY (4.00 Inches) Black Black	1
14	882830A1	拉线总成	CABLE ASSEMBLY	1
15	8500671	红色绝缘护套	BOOT Insulator - Red	1
16	817109A2	电磁阀总成(#10-32/.3125-18端子)	SOLENOID ASSEMBLY (#10-32 / .3125-18 Terminals)	1
17	822179	护孔环	GROMMET	2
18	818968	衬套	BUSHING	2
18	8M0214955	衬套	BUSHING	2
19	813938	盖形螺母(#10-32)	CAP NUT (#10-32)	1
20	45076	黄铜螺母(#10-32)	NUT (#10-32) Brass	2
21	53166	锁紧垫圈 (.312)	LOCKWASHER (.312)	2
22	68292	螺母(.312-18)	NUT (.312-18)	2
22	8M0204668	螺母(.312-18)	NUT (.312-18)	2
23	29245	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	1
23	8M0204649	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	1
24	82129135	螺钉(M6x35)	SCREW (M6 x 35)	1
25	880186T1	发动机线束总成	HARNESS ASSEMBLY Engine Wiring	1
25	880186T3	发动机线束总成	HARNESS ASSEMBLY Engine Wiring	1
26	858754	保险丝盖	COVER Fuse	1
27	828991	卡扣	CLIP	2
27	828991T	卡扣	CLIP	2
28	858780A2	喷油器线束总成	HARNESS ASSEMBLY Fuel Injector	1
28	879346A50	线束维修套件	HARNESS REPAIR KIT	1
29	878073A2	节气门位置传感器线束总成	HARNESS ASSEMBLY TPS	1
29	879346A41	线束维修套件	HARNESS REPAIR KIT	1
30	83296920	迷你保险丝-黄色-20安	FUSE Mini - Yellow - 20 Ampere	4
30	832969T20	迷你保险丝-黄色-20安	FUSE Mini - Yellow - 20 Ampere	4
30	8329695	迷你保险丝-棕色-5安培	FUSE Mini - Tan - 5 Ampere	1
30	832969T05	迷你保险丝-棕色-5安培	FUSE Mini - Tan - 5 Ampere	1
30	83296915	迷你保险丝-蓝色-15安培	FUSE Mini - Blue - 15 Ampere	1
30	832969T15	迷你保险丝-蓝色-15安培	FUSE Mini - Blue - 15 Ampere	1
31	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	AR
32	82130012	螺钉（M6 x 12）	SCREW (M6 x 12)	3
33	85961010	发动机控制模块ECM	ECM Engine Control Module	1
33	885557T19	PCM控制模块	PCM	1
33	8596109S	发动机控制模块ECM	ECM Engine Control Module	1
33	885557T19	PCM控制模块	PCM	1
33	88555719S	推进控制模块PCM	PCM Propulsion Control Module	1
33	885557T19	PCM控制模块	PCM	1
34	82130025	螺钉(M6x25)	SCREW (M6 x 25)	3
35	856954	衬套	BUSHING	3
36	834985	护孔环	GROMMET	3
36	8M0190980	护孔环	GROMMET	3
37	65567	不锈钢垫圈(0.265x0.750x0.048)	WASHER (.265 x .750 x .048) Stainless Steel	3
38	858953	支架	BRACKET	2
39	82129114	螺钉 (M6 x 14)	SCREW (M6 x 14)	2
40	832948A1	2针公头连接器总成	CONNECTOR ASSEMBLY 2 POS Male	1
41	878231A6	保险丝线束总成-100安培	HARNESS ASSEMBLY Fuse - 100 Ampere	1

图 9排气分隔板和排气板 Exhaust Divider And Exhaust Plate

REF	零件编号	中文名称	英文名称	数量
1	840760T	排气隔板	PLATE Exhaust Divider	1
2	8475251	衬垫	GASKET	1
2	847525004	衬垫	GASKET	1
3	814754	密封件(12.50英寸)	SEAL (12.50 Inches)	1
4	8263561	螺钉带垫圈(.312-18 x 1.500)	SCREW AND WASHER (.312-18 x 1.500)	18
4	881190	螺丝(.312-18 x 1.00)	SCREW (.312-18 x 1.00)	2
5	814634	卡箍	CLAMP	2
6	8231931	适配器	ADAPTER	1
7	687271	90度弯头 (.250-18) - 黄铜	FITTING (.250-18) 90 Degree - Brass	2
8	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	2
9	77653101	软管 (48.00英寸整卷)(截取9.75英寸)	HOSE (48.00 Inches Bulk) (Cut to 9.75 Inch Length)	1
10	687291	盖板	COVER	1
10	8M0039767	盖板	COVER	1
11	74824	螺钉(.312-18 x 1.250)	SCREW (.312-18 x 1.250)	4
12	69570	螺钉(#10-16 x .750)	SCREW (#10-16 x .750)	1
13	76451	垫圈	WASHER	1
14	144791	隔膜	DIAPHRAGM	1
15	16496	导水板	DEFLECTOR Water	1
16	16497A1	安装板	PLATE	1
17	78690	衬垫	GASKET	2
17	78690002	衬垫	GASKET	2
18	64878	弹簧(黑色)	SPRING (Black)	1
19	85303	垫圈	WASHER	1
20	14480	提动阀	POPPET	1
21	64872	护孔环	GROMMET	1
22	65848	托架	CARRIER	1
23	8231422	衬垫	GASKET	2
24	18260T5	排气板总成	PLATE ASSEMBLY Exhaust	1
25	823106	定位销 (.875)	PIN Dowel (.875)	2
25	8M0043826	定位销	PIN Dowel	2
26	14867		ELBOW 45 Degree (45 Degrees)	1
27	29085	45度弯管接头	FITTING Elbow (45 Degree)	1
27	8M0123050	45度弯管接头	FITTING Elbow (45 Degree)	1
28	66727	螺钉(.312-18 x 1.250)	SCREW (.312-18 x 1.250)	1
29	68783	螺钉(.312-18×2.50)	SCREW (.312-18 x 2.50)	1
30	66725	螺钉(.375-16×3.50)	SCREW (.375-16 x 3.50)	3
30	898833	螺钉(.375-16 x 3.500)	SCREW (.375-16 x 3.500)	3
31	27132	衬套	BUSHING	1
-	813859A02	衬垫套件	GASKET SET	1
-	809430T02	动力头总成	POWERHEAD ASSEMBLY	1

图 10飞轮/交流发电机 Flywheel/Alternator

REF	零件编号	中文名称	英文名称	数量
1	881248T	交流发电机	ALTERNATOR	1
1	8M0064021	交流发电机	ALTERNATOR	1
2	40108100	螺钉(M10×100)六角法兰-不锈钢	SCREW (M10 x 100) Hex Flange - Stainless Steel	1
2	8M0012503	螺钉(M10×1.5)	SCREW (M10 x 1.5)	1
3	40108120	螺钉(M10×120)六角法兰-不锈钢	SCREW (M10 x 120) Hex Flange - Stainless Steel	1
4	29395	垫圈(0.390×1.00×0.06)	WASHER (.390 x 1.00 x .06)	3
4	8M0042641	垫圈(0.390×1.00×0.06)	WASHER (.390 x 1.00 x .06)	3
5	856975	支架	MOUNT	3
6	858391T	支架	BRACKET	1
6	858391T01	支架	BRACKET	1
7	845998	垫圈(0.406×1.250×0.089)	WASHER (.406 x 1.250 x .089)	3
8	858393T	支架	BRACKET	1
8	858393T01	支架	BRACKET	1
9	826292	螺母(M10)黄铜/镀镍	NUT (M10) Brass/Nickel Plated	2
10	82446155	螺钉(M10×55)	SCREW (M10 x 55)	1
11	856583T2	拉线总成	CABLE ASSEMBLY	1
12	8215832	特殊销（1.5英寸）	PIN Special (1.5 Inches)	1
13	857142T	支架	BRACKET	1
14	812618	不锈钢螺钉(.312-18 x 1.00)带尼龙垫	SCREW (.312-18 x 1.00) Stainless Steel With Nylon Patch	3
15	840994	弹簧	SPRING	1
16	856815T2	张紧臂总成	ARM TENSIONER ASSEMBLY	1
17	856900	螺柱(M10×85)	STUD (M10 x 85)	1
17	8M0034457	螺柱(M10×85)	STUD (M10 x 85)	1
18	826292	螺母(M10)黄铜/镀镍	NUT (M10) Brass/Nickel Plated	1
19	8568941	衬套	BUSHING	1
20	4002320	垫圈	WASHER	2
21	883471T	滑轮	PULLEY	1
22	4010835	螺钉(M10×35)六角法兰-不锈钢	SCREW (M10 x 35) Hex Flange - Stainless Steel	1
23	828507Q10	皮带	BELT	1
24	859734T1	飞轮	FLYWHEEL	1
25	52901	螺母(0.625-18)	NUT (.625-18)	1
26	68229	垫圈(.641 x 1.250 x .190)	WASHER (.641 x 1.250 x .190)	1
26	33001	垫圈	WASHER	1
27	401386	螺母(M6)不锈钢	NUT (M6) Stainless Steel	1
28	4002319	垫圈	WASHER	1
-	809430T02	动力头总成	POWERHEAD ASSEMBLY	1

图 11燃油系统 Fuel System

REF	零件编号	中文名称	英文名称	数量
-	14360T75	燃油泵总成	PUMP ASSEMBLY Fuel	1
1	NSS	不单独销售燃油泵体	NOT SOLD SEPARATE Fuel Pump Body	1
2	857005A1	膜片组件	DIAPHRAGM KIT	1
3	NSS	止回阀(不单独销售)	NOT SOLD SEPARATE Check Valve	2
4	NSS	固定座(不单独销售)	NOT SOLD SEPARATE Retainer	2
5	NSS	弹簧(不单独销售)	NOT SOLD SEPARATE Spring	1
6	NSS	盖帽(不单独销售)	NOT SOLD SEPARATE Cap	1
7	NSS	弹簧(不单独销售)	NOT SOLD SEPARATE Spring	1
8	NSS	盖帽(不单独销售)	NOT SOLD SEPARATE Cap	1
9	NSS	膜片(不单独销售)	NOT SOLD SEPARATE Diaphragm	1
10	NSS	不单独销售衬垫-增压	NOT SOLD SEPARATE Gasket - Boost	1
11	NSS	不单独销售衬垫-脉冲	NOT SOLD SEPARATE Gasket - Pulse	1
12	987691	衬垫	GASKET	1
12	8M0204705	衬垫@2	GASKET @2	1
13	987752	安装板	PLATE	1
14	996642	90度弯头接头(0.125-27x0.250)尼龙	FITTING Elbow 90 Degree (.125-27 x .250) Nylon	1
15	82104540		SCREW (M5 x 40) Fuel Pump	2
16	82130050	螺钉(M6×50)泵至曲轴箱	SCREW (M6 x 50) Pump to Crankcase	2
17	144303	底座	BASE	1
18	291112	接头	FITTING	1
19	782792	45度弯头接头(1.25)	FITTING Elbow 45 Degree (1.25)	1
19	8M0207781	弯头	ELBOW	1
20	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	AR
21	830757130	管材 (.312)(70.00英寸整卷)(截取6.00英寸)	TUBING (.312) (70.00 Inches Bulk) (Cut to 6.00 Inch Length)	1
21	8M0108349	软管 (70英寸散装)	HOSE (70 Inches Bulk)	1
22	996642	90度弯头接头(0.125-27x0.250)尼龙	FITTING Elbow 90 Degree (.125-27 x .250) Nylon	1
23	856822A2	软管套管总成(18.00英寸)	HOSE AND SLEEVE ASSEMBLY (18.00 Inches)	1
23	8M0043979	软管套管总成	HOSE AND SLEEVE ASSEMBLY	1
24	822769	连接器	CONNECTOR	1
25	856822A1	油管	TUBING	1
25	8M0064784	成型脉冲软管	HOSE,MOLDED,PULSE	1
26	830756109	软管 (57.00英寸整卷) (裁切为7.50英寸)	HOSE (57.00 Inches Bulk) (Cut to 7.50 Inch Length)	1
26	8M0108355	软管(57英寸散装)	HOSE (57 Inches Bulk)	1
27	858955	连接器	CONNECTOR	1
28	856880	软管卡箍（15.3）	CLAMP Hose (15.3)	AR
28	8M0214964	卡箍	CLAMP	AR
-	813859A02	衬垫套件	GASKET SET	1
-	809430T02	动力头总成	POWERHEAD ASSEMBLY	1

图 12衬垫组件全套动力头和下部单元 Gasket Set Components Complete Powerhead And Lower Unit

REF	零件编号	中文名称	英文名称	数量
-	813859A02	衬垫套装(动力头与下部单元)	GASKET SET Powerhead And Lower Unit	1
0	857005A1	燃油泵膜片维修包	DIAPHRAGM KIT Fuel Pump	1
0	NSS	膜片(不单独销售)	NOT SOLD SEPARATE Diaphragm	2
0	NSS	固定座(不单独销售)	NOT SOLD SEPARATE Retainer	2
0	NSS	弹簧(不单独销售)	NOT SOLD SEPARATE Spring	1
0	NSS	盖帽(不单独销售)	NOT SOLD SEPARATE Cap	1
0	NSS	不单独销售弹簧-增压	NOT SOLD SEPARATE Spring - Boost	1
0	NSS	不单独销售端盖-弹簧末端	NOT SOLD SEPARATE Cap - Spring End	1
0	NSS	不单独销售增压衬垫	NOT SOLD SEPARATE Gasket Boost	1
0	NSS	不单独销售脉冲衬垫	NOT SOLD SEPARATE Gasket Pulse	1
0	987691	燃油泵衬垫	GASKET Fuel Pump	1
0	8M0204705	衬垫@2	GASKET @2	1
0	840484	衬垫（空气处理器适配板）	GASKET Air Handler Adaptor Plate	1
0	54029	O型圈(2.800 x .103)	O-RING (2.800 x .103)	1
0	62700	O型圈(3.237 x .103)	O-RING (3.237 x .103)	1
0	62386	节温器盖衬垫	GASKET Thermostat Cover	2
0	8M0204714	衬垫@4	GASKET @4	2
0	65800	曲轴底部填料	PACKING Crankshaft-Bottom	1
0	8475251	排气分隔板衬垫	GASKET Exhaust Divider Plate	1
0	847525004	衬垫	GASKET	1
0	814754	排气分隔板密封条（12.5英寸）	SEAL (12.50 Inches) Exhaust Divider Plate	1
0	78690002	衬垫(安全阀盖与阀板)	GASKET Relief Valve Cover & Plate	2
0	8231422	排气板衬垫	GASKET Exhaust Plate	2
0	991734	驱动轴壳体衬垫	GASKET Driveshaft Housing	1
0	38970	水管密封件	SEAL Water Tube	1
0	183074	驱动轴壳体板衬垫	GASKET Driveshaft Housing Plate	1
0	782461	排气延长管衬垫	GASKET Exhaust Extension	1
0	25439	O型圈 (.862 x .103)(齿轮箱衬套总成)	O-RING (.862 x .103) Gear Housing Bushing Assembly	1
0	426311	水泵底座下部衬垫	GASKET Water Pump Base-Lower	1
0	8M0204678	衬垫	GASKET	1
0	90011	O型圈(2.175x0.175)水泵底座	O-RING (2.175 x .175) Water Pump Base	1
0	8M0142854	O型圈(2.175 x 0.103)	O-RING (2.175 x .103)	1
0	18051	衬垫-水泵底座(上部)	GASKET Water Pump Base - Upper	1
0	858524	衬垫-水泵底座(上部)	GASKET Water Pump Base - Upper	1
0	88397	水泵体密封件	SEAL Water Pump Body	2
0	38970	水泵体密封件	SEAL Water Pump Body	1
0	31534	轴承座O型圈	O-RING Bearing Carrier	1
0	8M0214920	O型圈	O RING	1

图 13齿轮箱驱动轴-标准/反向-运动大师 Gear Housing Driveshaft-Standard/Counter-SportMaster

REF	零件编号	中文名称	英文名称	数量
0	840560T33	齿轮箱总成(完整)	GEAR HOUSING ASSEMBLY Complete	1
0	840560T34	齿轮箱总成(完整)	GEAR HOUSING ASSEMBLY Complete	1
0	840561T69	齿轮箱总成(完整)	GEAR HOUSING ASSEMBLY Complete	1
0	840561T70	齿轮箱总成(完整)	GEAR HOUSING ASSEMBLY Complete	1
1	849780A2	基础齿轮箱总成	GEAR HOUSING ASSEMBLY Basic	1
1	8M0083306	齿轮箱-SM型	GEAR HOUSING-SM	1
1	849781A2	基础齿轮箱总成	GEAR HOUSING ASSEMBLY Basic	1
1	8M0084203	齿轮箱-SM型	GEAR HOUSING-SM	1
2	847950T4	盖板	COVER	2
2	8479504	盖板	COVER	2
3	34776	O型圈	O-RING	2
4	815904	螺钉(#10-32 x .500)	SCREW (#10-32 x .500)	12
5	43044	定位销-无孔(.375 x .625)	PIN Dowel - Without Hole (.375 x .625)	2
6	42647A1	滚柱轴承总成	BEARING ASSEMBLY Roller	1
7	67891	填充块	FILLER BLOCK	1
7	8M0039169	填充块	FILLER BLOCK	1
8	847949	管塞	PLUG Pipe	1
9	562972	螺柱(0.312-18/0.324-24×3.380)	STUD (.312-18/.324-24 x 3.380)	1
9	8M0034463	螺柱(.312-24 x 3.38)	STUD (.312-24 x 3.38)	1
10	30667	双头螺栓(.250-20/.250-28×3.125)	STUD (.250-20/.250-28 x 3.125)	2
10	306671	螺柱	STUD	2
11	826134Q	阳极块	ANODE	2
12	4000333	螺钉(M6 x 40)	SCREW (M6 x 40)	1
13	401386	螺母(M6)不锈钢	NUT (M6) Stainless Steel	1
14	59579	双头螺柱(.437-14/.437-20 x 2.812)	STUD (.437-14/.437-20 x 2.812)	3
14	786382	螺柱(.437-14/.437-20 x 3.120)	STUD (.437-14/.437-20 x 3.120)	1
14	579203	双头螺栓(.437-14/.437-20×2.060)	STUD (.437-14/.437-20 x 2.060)	2
14	8M0133358	双头螺栓(.437-14/.437-20×2.060)	STUD (.437-14/.437-20 x 2.060)	2
15	NSS	不单独销售	NOT SOLD SEPARATE	1
16	92721	垫圈(.965×0.630)	WASHER (.965 x .630)	1
17	35921	螺母(0.625-18)	NUT (.625-18)	1
18	79953Q2	排水螺钉套件(.375-16 x .250)	SCREW KIT (.375-16 x .250) Drain	1
18	79953Q04	放油螺钉套件	SCREW KIT Drain	1
19	191833	密封件	SEAL	1
19	8M0187157	蓝色密封件@15	SEAL-BLUE @15	1
20	789022	下换挡轴	SHIFT SHAFT Lower	1
21	77631A2	衬套总成	BUSHING ASSEMBLY	1
22	25439	O型圈(.862×0.103)	O-RING (.862 x .103)	1
23	8164641	油封	SEAL Oil	1
23	8M0246145	油封	OIL SEAL	1
24	77674	垫圈(.35 x .75 x .12)	WASHER (.35 x .75 x .12)	1
25	848449A4	驱动轴总成	DRIVESHAFT ASSEMBLY	1
25	8M0192233	驱动轴	DRIVESHAFT	1
25	848449A5	驱动轴总成	DRIVESHAFT ASSEMBLY	1
25	8M0192234	驱动轴	DRIVESHAFT	1
26	38657A1	垫片组	SHIM ASSEMBLY	1
26	8M0063268	垫片组	SHIM SET	1
27	48939A2	圆锥滚子轴承	BEARING Taper Roller	1
27	8M0146553	杯/锥轴承总成	BEARING ASSEMBLY Cup/Cone	1
28	NSS	杯状件(不单独销售)	NOT SOLD SEPARATE Cup	1
29	42637A1	垫片组	SHIM SET	AR
29	8M0063267	垫片组	SHIM SET	AR
30	36387A1	轴承总成(滚子/外圈)	BEARING ASSEMBLY Roller/Cup	1
30	8M0146566	杯/锥轴承总成	BEARING ASSEMBLY Cup/Cone	1
31	NSS	杯状件(不单独销售)	NOT SOLD SEPARATE Cup	1
32	8245191	固定座	RETAINER	1
33	44292A3	水泵底座总成	BASE ASSEMBLY Water Pump	1
34	426311	衬垫	GASKET	1
34	8M0204678	衬垫	GASKET	1
35	90011	O型圈(2.175 x 0.175)	O-RING (2.175 x .175)	1
35	8M0142854	O型圈(2.175 x 0.103)	O-RING (2.175 x .103)	1
36	89238	油封	SEAL Oil	1
37	16977	油封	SEAL Oil	1
38	18051	下衬垫	GASKET Lower	1
39	858524	上衬垫	GASKET Upper	1
40	32435	面板	FACE PLATE	1
40	8M0204677	面板	PLATE-FACE	1
41	847710T1	水泵壳体总成	BODY ASSEMBLY Water Pump	1
41	96148T1	水泵壳体总成	BODY ASSEMBLY Water Pump	1
42	48752T	嵌件	INSERT	1
43	88397	密封件	SEAL	1
43	38970	密封件	SEAL	1
44	847685	套筒	SLEEVE	1
44	29804T	套筒	SLEEVE	1
45	56654	键	KEY	1
45	8M0214992	键@5	KEY @5	1
46	89984T4	叶轮	IMPELLER	1
47	29245	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	2
47	8M0204649	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	2
48	8267119	螺母(.250-28)	NUT (.250-28)	2
49	36001	垫圈	WASHER	1
50	13436	螺母	NUT	1
51	96411	螺钉(#14-8×2.25)	SCREW (#14-8 x 2.25)	1
51	8M0215009	螺钉	SCREW	1
-	89238A3	齿轮箱密封套件	SEAL KIT Gear Housing	1
-	813859A02	衬垫套件	GASKET SET	1
-	90415A24	螺柱套件	STUD KIT	1
-	59579	双头螺柱(.437-14/.437-20 x 2.812)	STUD (.437-14/.437-20 x 2.812)	1

图 14齿轮箱驱动轴-TorqueMaster Gear Housing Driveshaft - TorqueMaster

REF	零件编号	中文名称	英文名称	数量
-	827214T23	齿轮箱总成(完整)	GEAR HOUSING ASSEMBLY Complete	1
1	827214T25	基础齿轮箱总成	GEAR HOUSING ASSEMBLY Basic	1
2	43044	定位销-无孔(.375 x .625)	PIN Dowel - Without Hole (.375 x .625)	2
3	786382	螺柱(.437-14/.437-20 x 3.120)	STUD (.437-14/.437-20 x 3.120)	1
4	579203	双头螺栓(.437-14/.437-20×2.060)	STUD (.437-14/.437-20 x 2.060)	2
4	8M0133358	双头螺栓(.437-14/.437-20×2.060)	STUD (.437-14/.437-20 x 2.060)	2
5	562972	螺柱(0.312-18/0.324-24×3.380)	STUD (.312-18/.324-24 x 3.380)	1
5	8M0034463	螺柱(.312-24 x 3.38)	STUD (.312-24 x 3.38)	1
6	30667	双头螺栓(.250-20/.250-28×3.125)	STUD (.250-20/.250-28 x 3.125)	2
6	306671	螺柱	STUD	2
7	67891	填充块	FILLER BLOCK	1
7	8M0039169	填充块	FILLER BLOCK	1
8	42647A1	滚柱轴承总成	BEARING ASSEMBLY Roller	1
9	826134Q	阳极块	ANODE	2
10	4000333	螺钉(M6 x 40)	SCREW (M6 x 40)	1
11	401386	螺母(M6)不锈钢	NUT (M6) Stainless Steel	1
12	85822A10	连接器总成	CONNECTOR ASSEMBLY	1
13	NSS	不单独销售小齿轮(属于43-44104A7部件)	NOT SOLD SEPARATE Pinion Gear (Part Of 43- 44104A 7)	1
14	92721	垫圈(.965×0.630)	WASHER (.965 x .630)	1
15	35921	螺母(0.625-18)	NUT (.625-18)	1
16	42637A1	垫片组	SHIM SET	AR
16	8M0063267	垫片组	SHIM SET	AR
17	79953Q2	排水螺钉套件(.375-16 x .250)	SCREW KIT (.375-16 x .250) Drain	1
17	79953Q04	放油螺钉套件	SCREW KIT Drain	1
18	191833	密封件	SEAL	2
18	8M0187157	蓝色密封件@15	SEAL-BLUE @15	2
19	67892A1	磁吸式注油/放油塞套件	FITTING KIT Magnetic, Plug Fill/Drain	1
19	8M0058389	放油螺钉套件	SCREW KIT Drain	1
20	789022	换档轴	SHIFT SHAFT	1
21	77631A2	衬套总成	BUSHING ASSEMBLY	1
22	25439	O型圈(.862×0.103)	O-RING (.862 x .103)	1
23	8164641	油封	SEAL Oil	1
23	8M0246145	油封	OIL SEAL	1
24	77674	垫圈(.35 x .75 x .12)	WASHER (.35 x .75 x .12)	1
25	848449A5	驱动轴总成	DRIVESHAFT ASSEMBLY	1
25	8M0192234	驱动轴	DRIVESHAFT	1
26	36387A1	轴承总成(滚子/外圈)	BEARING ASSEMBLY Roller/Cup	1
26	8M0146566	杯/锥轴承总成	BEARING ASSEMBLY Cup/Cone	1
27	NSS	杯状件(不单独销售)	NOT SOLD SEPARATE Cup	1
28	8245191	固定座	RETAINER	1
29	44292A3	水泵底座总成	BASE ASSEMBLY Water Pump	1
30	NSS	固定座(不单独销售)	NOT SOLD SEPARATE Retainer	1
31	426311	衬垫	GASKET	1
31	8M0204678	衬垫	GASKET	1
32	90011	O型圈(2.175 x 0.175)	O-RING (2.175 x .175)	1
32	8M0142854	O型圈(2.175 x 0.103)	O-RING (2.175 x .103)	1
33	89238	油封	SEAL Oil	1
34	16977	油封	SEAL Oil	1
35	18051	衬垫	GASKET	1
36	858524	衬垫	GASKET	1
37	32435	面板	FACE PLATE	1
37	8M0204677	面板	PLATE-FACE	1
38	96148T1	水泵壳体总成	BODY ASSEMBLY Water Pump	1
39	48752T	嵌件	INSERT	1
40	38970	密封件	SEAL	1
41	89984T4	叶轮	IMPELLER	1
42	56654	键	KEY	1
42	8M0214992	键@5	KEY @5	1
43	96411	螺钉(#14-8×2.25)	SCREW (#14-8 x 2.25)	1
43	8M0215009	螺钉	SCREW	1
44	29245	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	2
44	8M0204649	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	2
45	8267119	螺母(.250-28)	NUT (.250-28)	2
46	36001	垫圈	WASHER	1
47	13436	螺母	NUT	1
48	29804T	套筒	SLEEVE	1
-	96148A8	水泵维修套件	WATER PUMP REPAIR KIT	1
-	89238A3	齿轮箱密封套件	SEAL KIT Gear Housing	1
-	813859A02	衬垫套件	GASKET SET	1

图 15齿轮箱螺旋桨轴-反向旋转-运动大师 Gear Housing Propeller Shaft-Counter Rotation-Sportmaster

REF	零件编号	中文名称	英文名称	数量
0	840561T69	齿轮箱总成(完整)	GEAR HOUSING ASSEMBLY Complete	1
0	840561T70	齿轮箱总成(完整)	GEAR HOUSING ASSEMBLY Complete	1
1	849781A2	基础齿轮箱总成	GEAR HOUSING ASSEMBLY Basic	1
1	8M0084203	齿轮箱-SM型	GEAR HOUSING-SM	1
2	89594A1	从动件总成	FOLLOWER ASSEMBLY	1
3	789562	换挡凸轮	SHIFT CAM	1
4	79911A1	杆	ROD	1
5	79910	弹簧	SPRING	2
6	78906	销	PIN	1
6	8M0084245	弹簧定位销	PIN Spring Locator	1
7	78910	垫圈	WASHER	2
8	14469T	轴承杯	CUP Bearing	1
9	88957T	滚珠轴承	BEARING Ball	1
10	NSS	不单独销售倒档齿轮(属于43-15845A2部件)	NOT SOLD SEPARATE Reverse Gear (Part Of 43- 15845A 2)	1
11	15844	滚柱轴承总成	BEARING ASSEMBLY Roller	1
12	42672T	棘轮	RATCHET	1
13	78909	定位销	PIN Detent	2
14	42671	十字销	PIN Cross	1
15	78962	弹簧	SPRING	2
16	15845A2	齿轮组	GEAR SET	1
17	176151	调整垫片(.125)	SPACER SHIM (.125)	AR
17	176152	调整垫片(.127)	SPACER SHIM (.127)	AR
17	176153	调整垫片(.129)	SPACER SHIM (.129)	AR
17	176154	调整垫片(.131)	SPACER SHIM (.131)	AR
17	176155	调整垫片(.133)	SPACER SHIM (.133)	AR
17	176156	调整垫片(.135)	SPACER SHIM (.135)	AR
17	176157	调整垫片(.137)	SPACER SHIM (.137)	AR
17	176158	调整垫片(.139)	SPACER SHIM (.139)	AR
17	176159	调整垫片(.141)	SPACER SHIM (.141)	AR
17	1761510	调整垫片(.143)	SPACER SHIM (.143)	AR
17	1761511	调整垫片(.145)	SPACER SHIM (.145)	AR
17	1761512	调整垫片(.147)	SPACER SHIM (.147)	AR
17	1761513	调整垫片(.149)	SPACER SHIM (.149)	AR
18	15841	滚柱轴承	BEARING Roller	1
19	17616	推力环	THRUST RING	1
20	31534	O型圈	O-RING	1
20	8M0214920	O型圈	O RING	1
21	15838A2	轴承适配器总成	ADAPTER ASSEMBLY Bearing	1
22	15843T	滚针轴承	BEARING Needle	1
23	15834	推力轴承	BEARING Thrust	2
24	840450A2	螺旋桨轴	PROPELLLER SHAFT	1
24	840450A03	螺旋桨轴套件	PROPELLER SHAFT KIT	1
25	847616T1	轴承座	CARRIER Bearing	1
26	817072	滚柱轴承	BEARING Roller	1
27	815565	油封	SEAL Oil	2
28	817071	卡环	RING Snap	1
29	67892A1	磁吸式注油/放油塞套件	FITTING KIT Magnetic, Plug Fill/Drain	1
29	8M0058389	放油螺钉套件	SCREW KIT Drain	1
30	191833	密封件	SEAL	1
30	8M0187157	蓝色密封件@15	SEAL-BLUE @15	1
31	30281	键	KEY	1
32	79447	锁紧垫圈	TAB WASHER	1
33	158401	盖板	COVER	1
34	85344	垫圈(.750内径)	WASHER (.750 Inside Diameter)	1
35	52707Q1	螺旋桨螺母套件 (.750-16)	PROP NUT KIT (.750-16)	1
36	41350	螺钉(.437-14 x 2.50)不锈钢	SCREW (.437-14 x 2.50) Stainless Steel	1
36	66024	螺钉(.437-14 x 1.75)	SCREW (.437-14 x 1.75)	1
37	822836	垫圈(.445 x .805 x .108)	WASHER (.445 x .805 x .108)	2
38	859116	螺母(.437-20)	NUT (.437-20)	2
39	30206	螺钉(.375-16 x 1.00)不锈钢	SCREW (.375-16 x 1.00) Stainless Steel	1
40	76214T3	阳极块	ANODE	1
40	76214Q5	阳极套件	ANODE KIT	1
-	90415A24	螺柱套件	STUD KIT	1
-	59579	双头螺柱(.437-14/.437-20 x 2.812)	STUD (.437-14/.437-20 x 2.812)	1
-	89238A3	齿轮箱密封套件	SEAL KIT Gear Housing	1

图 16齿轮箱螺旋桨轴-标准旋转-运动大师 Gear Housing Propeller Shaft-Standard Rotation-Sportmaster

REF	零件编号	中文名称	英文名称	数量
0	840560T33	齿轮箱总成(完整)	GEAR HOUSING ASSEMBLY Complete	1
0	840560T34	齿轮箱总成(完整)	GEAR HOUSING ASSEMBLY Complete	1
1	849780A2	基础齿轮箱总成	GEAR HOUSING ASSEMBLY Basic	1
1	8M0083306	齿轮箱-SM型	GEAR HOUSING-SM	1
2	89594A1	从动件总成	FOLLOWER ASSEMBLY	1
3	789562	换挡凸轮	SHIFT CAM	1
4	79911A1	杆	ROD	1
5	79910	弹簧	SPRING	2
6	78906	销	PIN	1
6	8M0084245	弹簧定位销	PIN Spring Locator	1
7	78910	垫圈	WASHER	2
8	47397A1	垫片组	SHIM SET	AR
9	78172A1	圆锥滚子轴承总成	BEARING ASSEMBLY Taper Roller	1
10	NSS	杯状件(不单独销售)	NOT SOLD SEPARATE Cup	1
11	44104A7	齿轮组(含全部齿轮)	GEAR SET Includes All Gears	1
12	549281	滚柱轴承	BEARING Roller	1
13	42672T	棘轮	RATCHET	1
14	78909	定位销	PIN Detent	2
15	42671	十字销	PIN Cross	1
16	78962	弹簧	SPRING	2
17	840451A2	螺旋桨轴	PROPELLER SHAFT	1
17	840451A03	螺旋桨轴	PROPELLER SHAFT	1
18	822824A1	倒车齿轮总成	GEAR ASSEMBLY Reverse	1
18	8M0192202	倒挡齿轮	GEAR-REVERSE	1
19	822823	推力环	THRUST RING	1
20	88957T	滚珠轴承	BEARING Ball	1
21	681001	止推环	RING Thrust	1
22	31534	O型圈	O-RING	1
22	8M0214920	O型圈	O RING	1
23	848840T1	轴承座总成	CARRIER ASSEMBLY Bearing	1
23	848840A1	轴承座总成	CARRIER ASSEMBLY Bearing	1
24	817072	滚柱轴承	BEARING Roller	1
25	817071	卡环	RING Snap	1
26	815565	油封	SEAL Oil	2
27	67892A1	磁吸式注油/放油塞套件	FITTING KIT Magnetic, Plug Fill/Drain	1
27	8M0058389	放油螺钉套件	SCREW KIT Drain	1
28	191833	密封件	SEAL	1
28	8M0187157	蓝色密封件@15	SEAL-BLUE @15	1
29	79448	固定座	RETAINER	1
29	8M2011027	固定座	RETAINER	1
30	30281	键	KEY	1
31	79447	锁紧垫圈	TAB WASHER	1
32	85344	垫圈(.750内径)	WASHER (.750 Inside Diameter)	1
33	52707Q1	螺旋桨螺母套件 (.750-16)	PROP NUT KIT (.750-16)	1
34	41350	螺钉(.437-14 x 2.50)不锈钢	SCREW (.437-14 x 2.50) Stainless Steel	1
34	66024	螺钉(.437-14 x 1.75)	SCREW (.437-14 x 1.75)	1
35	76214T3	阳极块	ANODE	1
35	76214Q5	阳极套件	ANODE KIT	1
36	822836	垫圈(.445 x .805 x .108)	WASHER (.445 x .805 x .108)	2
37	859116	螺母(.437-20)	NUT (.437-20)	2
38	30206	螺钉(.375-16 x 1.00)不锈钢	SCREW (.375-16 x 1.00) Stainless Steel	1
-	89238A3	齿轮箱密封套件	SEAL KIT Gear Housing	1
-	90415A24	螺柱套件	STUD KIT	1
-	59579	双头螺柱(.437-14/.437-20 x 2.812)	STUD (.437-14/.437-20 x 2.812)	1

图 17齿轮箱螺旋桨轴-Torque Master Gear Housing Propeller Shaft - Torque Master

REF	零件编号	中文名称	英文名称	数量
-	827214T23	齿轮箱总成(完整)	GEAR HOUSING ASSEMBLY Complete	1
1	827214T25	基础齿轮箱总成	GEAR HOUSING ASSEMBLY Basic	1
2	89594A1	从动件总成	FOLLOWER ASSEMBLY	1
3	789562	换挡凸轮	SHIFT CAM	1
4	79911A1	杆	ROD	1
5	79910	弹簧	SPRING	2
6	78906	销	PIN	1
7	78910	垫圈	WASHER	2
8	47397A1	垫片组	SHIM SET	AR
9	78172A1	圆锥滚子轴承总成	BEARING ASSEMBLY Taper Roller	1
10	NSS	杯状件(不单独销售)	NOT SOLD SEPARATE Cup	1
11	44104A7	齿轮组	GEAR SET	1
12	549281	滚柱轴承	BEARING Roller	1
13	42672T	棘轮	RATCHET	1
14	42671	十字销	PIN Cross	1
15	78909	定位销	PIN Detent	2
16	78962	弹簧	SPRING	2
17	840451A2	螺旋桨轴	PROPELLER SHAFT	1
18	822824A1	倒车齿轮总成	GEAR ASSEMBLY Reverse	1
19	822823	推力环	THRUST RING	1
20	681001	止推环	RING Thrust	1
21	88957T	滚珠轴承	BEARING Ball	1
22	31534	O型圈	O-RING	1
23	848840T1	轴承座总成	CARRIER ASSEMBLY Bearing	1
24	817072	滚柱轴承	BEARING Roller	1
25	817071	卡环	RING Snap	1
26	815565	油封	SEAL Oil	2
27	79448	固定座	RETAINER	1
28	30281	键	KEY	1
29	79447	锁紧垫圈	TAB WASHER	1
30	85344	垫圈(.750内径)	WASHER (.750 Inside Diameter)	1
31	52707Q1	螺旋桨螺母套件 (.750-16)	PROP NUT KIT (.750-16)	1
32	832066A1	进水口板套件	PLATE KIT Water Inlet	1
33	188642	螺钉(#8-32 x .500)	SCREW (#8-32 x .500)	4
34	76214Q5	阳极套件	ANODE KIT	1
35	66024	螺钉(.437-14 x 1.75)	SCREW (.437-14 x 1.75)	1
36	859116	螺母(.437-20)	NUT (.437-20)	2
37	30206	螺钉(.375-16 x 1.00)不锈钢	SCREW (.375-16 x 1.00) Stainless Steel	1
38	822836	垫圈(.445 x .805 x .108)	WASHER (.445 x .805 x .108)	2
39	859432	接头	FITTING	1
40	85944975	管材 (72.00英寸整卷)(截取7.00英寸)	TUBING (72.00 Inches Bulk) (Cut to 7.00 Inch Length)	1
-	89238A3	齿轮箱密封套件	SEAL KIT Gear Housing	1
-	813859A02	衬垫套件	GASKET SET	1

图 18液压泵及安装支架 Hydraulic Pump And Mounting Brackets

REF	零件编号	中文名称	英文名称	数量
-	846859A4	液压泵总成	PUMP ASSEMBLY Hydraulic Complete	1
1	818161A4	液压泵总成	PUMP ASSEMBLY Hydraulic	1
1	8M0051203	配平泵总成	PUMP ASSY-TRIM	1
2	818567	支架	BRACKET	1
3	38837	螺钉(.312-18×1.12)	SCREW (.312-18 x 1.12)	1
4	57792	垫圈	WASHER	2
5	34948	隔套	SPACER	1
6	65999A12	接地线总成	CABLE ASSEMBLY Ground	1
7	79138A9	电缆总成(6英尺)黑色-负极	CABLE ASSEMBLY (6.00 Feet) Black-Negative	1
8	92051	螺钉（10-16 x 0.75）	SCREW (10-16 x .75)	2
9	79147A5	线束总成	HARNESS ASSEMBLY	1
10	79091	保险丝20安培	FUSE 20 Ampere	1
10	8M0207796	保险丝20安培	FUSE 20 AMP	1
11	88075	固定座	RETAINER	1
12	853654A1	电磁阀	SOLENOID	2
13	41508	螺钉(0.250-20×0.500)不锈钢	SCREW (.250-20 x .500) Stainless Steel	4
14	20110	螺母 (#10-32)	NUT (#10-32)	4
15	26484	螺母(.312-18)	NUT (.312-18)	4
15	8M0204646	螺母(.312-18)	NUT (.312-18)	4
16	79023A10	保险丝总成110安培	FUSE ASSEMBLY 110 Ampere	1
16	79023T10	保险丝总成110安培	FUSE ASSEMBLY 110 Ampere	1
17	96457	酚醛垫圈(.27×.81×.062)	WASHER Phenolic (.27 x .81 x .062)	1
18	21825	螺母(.250-28)	NUT (.250-28)	1
19	65999A11	拉线总成	CABLE ASSEMBLY	1
20	79139A12	电缆总成红色-正极	CABLE ASSEMBLY Red-Positive	1
21	46265	护套	BOOT	5
22	22753	垫圈	WASHER	4
23	79139A26	电缆总成(红色)	CABLE ASSEMBLY Red	1
24	87760T	安装板	MOUNTING PLATE	1
25	39349	螺钉(.312-18×0.75)不锈钢	SCREW (.312-18 x .750) Stainless Steel	1
26	26993	锁紧垫圈 (.312)	LOCKWASHER (.312)	1
26	8M0204647	锁紧垫圈 (.312)	LOCKWASHER (.312)	1
27	90271	螺钉(.375-16×0.62)	SCREW (.375-16 x .62)	2
28	58643	锁紧垫圈 (.375)	LOCKWASHER (.375)	2
29	856774	垫圈(0.406×0.750×0.105)不锈钢	WASHER (.406 x .750 x .105) Stainless Steel	4
29	8M0214963	垫圈	WASHER	4
30	87762	支架	BRACKET	1
31	63826	螺钉(.375-16 x 2.50)	SCREW (.375-16 x 2.50)	2
32	82670912	螺母(.375-16)不锈钢	NUT (.375-16) Stainless Steel	2
33	818200	接头	FITTING	1
34	77366	接头	FITTING	2
35	65017A14	线束总成	HARNESS ASSEMBLY	1
36	848017A2	升降线束总成	HARNESS ASSEMBLY Trim	1

图 19液压泵总成 Hydraulic Pump Assembly

REF	零件编号	中文名称	英文名称	数量
-	818161A4	液压泵总成	PUMP ASSEMBLY Hydraulic	1
-	8M0051203	配平泵总成	PUMP ASSY-TRIM	1
1	811491	适配器	ADAPTER	1
1	8M0084543	适配器	ADAPTER	1
2	803852	联轴器	COUPLING	1
3	89498	O型圈	O-RING	1
4	811492T	泵总成(含螺钉)	PUMP ASSEMBLY Includes Screws	1
5	89496	滤清器	FILTER	2
6	89497	O型圈	O-RING	1
7	41219T	储液罐	RESERVOIR	1
8	811493	螺钉套件	SCREW KIT	1
-	17649T	电机总成	MOTOR ASSEMBLY	1
-	891736T	电机总成	MOTOR ASSEMBLY	1
-	891736T	电机总成	MOTOR ASSEMBLY	1
9	17632T	端盖总成	END CAP ASSEMBLY	1
9	891736T	电机总成	MOTOR ASSEMBLY	1
9	NSS	端架(不单独销售)	NOT SOLD SEPARATE End Frame	1
10	17626	螺钉	SCREW	4
10	891736T	电机总成	MOTOR ASSEMBLY	4
10	891741	螺钉	SCREW	4
11	17625	O型圈	O-RING	1
11	891736T	电机总成	MOTOR ASSEMBLY	1
11	891740	O型圈	O-RING	1
12	17621	螺钉	SCREW	2
12	891736T	电机总成	MOTOR ASSEMBLY	2
12	891739	螺钉	SCREW	2
13	17633	支架套件	HOLDER KIT	1
13	891736T	电机总成	MOTOR ASSEMBLY	1
13	891738	支架总成	HOLDER ASSEMBLY	1
14	17631A1	电刷套件	BRUSH KIT	1
14	891736T	电机总成	MOTOR ASSEMBLY	1
14	891737	电刷套件	BRUSH KIT	1
15	17623	电枢	ARMATURE	1
15	891736T	电机总成	MOTOR ASSEMBLY	1
15	NSS	电枢(不单独销售)	NOT SOLD SEPARATE Armature	1
16	17653	垫圈	WASHER	2
16	891736T	电机总成	MOTOR ASSEMBLY	2
16	NSS	止推垫圈(不单独销售)	NOT SOLD SEPARATE Thrust Washer	2
17	17624	磁场框架总成	FIELD AND FRAME ASSEMBLY	1
17	891736T	电机总成	MOTOR ASSEMBLY	1
17	NSS		NOT SOLD SEPARATE Field And Frame	1
18	17622	盖总成	COVER ASSEMBLY	1
18	891736T	电机总成	MOTOR ASSEMBLY	1
18	NSS		NOT SOLD SEPARATE Housing	1
-	812498A1	安全阀套件	VALVE KIT Relief	1

图 20仪表/附件 Instrumentation/Accessories

REF	零件编号	中文名称	英文名称	数量
1	68878A6	蜂鸣报警器总成	HORN ASSEMBLY Buzzer Alarm	1
2	68879	盖板	COVER	1
3	86396A8	转速表线束总成(5.00英尺)	HARNESS ASSEMBLY Tachometer (5.00 Feet)	1
4	19674A1	拉绳开关总成	SWITCH ASSEMBLY Lanyard	1
4	19674A07	开关/拉绳套件	SWITCH/LANYARD KIT	1
5	18303	螺钉 (.190-16 x 1.750) 不锈钢	SCREW (.190-16 x 1.750) Stainless Steel	2
6	813679	适配器	ADAPTER	1
7	15920Q54	拉绳总成	LANYARD ASSEMBLY	1
8	32866	螺钉 (#10-32 x 2.00) 不锈钢	SCREW (#10-32 x 2.00) Stainless Steel	2
9	18321	安装夹	CLAMP Mounting	1
10	24676	垫圈 (.200 x .440 x .032)	WASHER (.200 x .440 x .032)	2
11	68219	螺母 (#10-32) 不锈钢	NUT (#10-32) Stainless Steel	4
12	79146	固定座	RETAINER	AR
13	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	AR
14	812497A2	二极管总成	DIODE ASSEMBLY	1
14	898289A72	双拉绳二极管套件	DIODE KIT-LANYARD Dual	1
15	11149A2	线缆总成 (6.00英寸)	CABLE ASSEMBLY (6.00 Inches)	1
-	879896K4	系统监控套件 SC1000 - 前装式	SYSTEM MONITOR KIT SC1000 - Front Mount	1
-	879896K10	系统监控套件 SC1000 - 前装式	SYSTEM MONITOR KIT SC1000 - Front Mount	1
-	879981T20	线束总成 (SC1000R-20)	HARNESS ASSEMBLY (SC1000R-20)	1
16	878492T4	四通接线盒	JUNCTION BOX 4 Way	1
16	878492T14	四通接线盒	JUNCTION BOX 4 Way	1
17	859318T1	终端接头 10针 (CAN 1和2)	TERMINATOR 10 Pin (CAN 1 and 2)	1
17	8M0210753	终端接线盒	TERMINATOR Junction Box	1
18	859318T2	防水帽 - 10针	CAP Weather - 10 Pin	1
18	8M0210754	防水帽	WEATHER CAP	1
-	879979T1	转速表线束总成 (SC1000-3)	HARNESS ASSEMBLY Tachometer (SC1000-3)	1
-	879979T11	转速表线束总成	HARNESS ASSEMBLY Tachometer	1
-	879918K11	水压表(白色)	WATER PRESSURE GAUGE (White)	1

图 21钥匙开关总成 Key Switch Assembly

REF	零件编号	中文名称	英文名称	数量
1	816626A15	钥匙开关线束总成(15英尺)	HARNESS ASSEMBLY Key Switch (15.00 Feet)	1
2	90468A1	钥匙盖总成	COVER ASSEMBLY Key	2
3	76424	支架	BRACKET	1
4	55422	双头螺柱 (#10-32 x 2.00)	STUD (#10-32 x 2.00)	2
5	24676	垫圈 (.200 x .440 x .032)	WASHER (.200 x .440 x .032)	2
6	68219	螺母 (#10-32) 不锈钢	NUT (#10-32) Stainless Steel	2
7	816479A3	板组件套件	PLATE KIT	2
8	88107A5	钥匙开关套件	SWITCH KIT Key	1
9	879755	特殊螺母-黑色尼龙	NUT Special - Black Nylon	1
10	816492A2	报警器	ALARM	1
10	8M0089727	报警器总成	ALARM ASSEMBLY	1
11	8127111	垫片(0.375)	SPACER (.375)	2
11	812711	隔套(0.250)	SPACER (.250)	2
-	894911	点火钥匙(1A)	KEY Ignition (1A)	1
-	894912	点火钥匙(1B)	KEY Ignition (1B)	1
-	894913	点火钥匙(1C)	KEY Ignition (1C)	1
-	894914	点火钥匙(1D)	KEY Ignition (1D)	1
-	894915	点火钥匙(1E)	KEY Ignition (1E)	1
-	894916	点火钥匙(1F)	KEY Ignition (1F)	1
-	894917	点火钥匙(2A)	KEY Ignition (2A)	1
-	894918	点火钥匙(2B)	KEY Ignition (2B)	1
-	894919	点火钥匙(2C)	KEY Ignition (2C)	1
-	8949110	点火钥匙(2D)	KEY Ignition (2D)	1
-	8949111	点火钥匙(2E)	KEY Ignition (2E)	1
-	8949112	点火钥匙(2F)	KEY Ignition (2F)	1

图 22润滑油系统 Oil System

REF	零件编号	中文名称	英文名称	数量
1	8781051	止回阀	CHECK VALVE	1
2	424254	接头	FITTING	1
2	8M0207780	接头	FITTING	1
3	830756109	软管(57英寸整卷)(裁切为6英寸长度)	HOSE (57.00 Inches Bulk) (Cut to 6.00 Inch Length)	1
3	8M0108355	软管(57英寸散装)	HOSE (57 Inches Bulk)	1
4	NSS	盖帽(不单独销售)	NOT SOLD SEPARATE Cap	2
5	875289	软管	HOSE	1
6	858955	连接器	CONNECTOR	2
7	875284001	滤清器-机油在线式	FILTER Oil - In Line	1
7	875284T01	滤清器-机油在线式	FILTER Oil - In Line	1
8	875283	软管(2.00英寸)	HOSE (2.00 Inches)	1
9	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	AR
9	69355	扎带(5.50英寸)	TIE STRAP (5.50 Inches)	AR
9	8M0214940	扎带	TIE STRAP	AR
9	56762	扎带(4.00英寸)	TIE STRAP (4.00 Inches)	AR
10	892830053	软管(24.00英寸编织型)	HOSE (24.00 Inches Braided)	1
11	85606065	管材 (38.00英寸整卷)(截取21.00英寸)	TUBING (38.00 Inches Bulk) (Cut to 21.00 Inch Length)	1
11	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	1
12	828547753	导管 (.750内径x3.00英尺整卷)(截取10.00英寸)(按需使用)	CONDUIT (.750 Inside Diameter x 3.00 Feet Bulk) (Cut to 10.00 Inch Length) (Use Where Applicable)	1
13	833069T9	储液罐总成	RESERVOIR ASSEMBLY	1
13	8M0063190	油箱总成	OIL TANK ASSY	1
14	NSS	标贴(不单独销售)	NOT SOLD SEPARATE Decal	1
15	855362	护孔环	GROMMET	3
15	855362001	护孔环	GROMMET	3
16	49436	垫圈	WASHER	3
17	60411	螺钉(.312-18 x 1.250)	SCREW (.312-18 x 1.250)	3
18	855634	螺钉	SCREW	3
19	856156A2	开关总成	SWITCH ASSEMBLY	1
19	856156T02	开关总成	SWITCH ASSEMBLY	1
20	58376	螺钉(.164-18 x .375)	SCREW (.164-18 x .375)	1
21	72761	不锈钢垫圈(.203 x .562 x .060)	WASHER (.203 x .562 x .060) Stainless Steel	1
-	809430T02	动力头总成	POWERHEAD ASSEMBLY	1

图 23动力升降组件 8M0231193 Power Trim Components 8M0231193

REF	零件编号	中文名称	英文名称	数量
-	8M0231193	动力升降总成	POWER TRIM ASSEMBLY	1
1	8M0225363	电机套件	MOTOR KIT	1
2	8M0225369	阀套件	VALVE KIT	1
3	8M0225371	手动释放套件	MANUAL RELEASE KIT	1
4	8M0245633	倾斜油缸套件	TILT CYLINDER KIT	1
5	8M0225370	枢轴销套件	PIVOT PIN KIT	1
6	8M0244575	减震杆套件	SHOCK ROD KIT	1
7	8M0244425	销杆眼套件	PIN ROD EYE KIT	1
8	8M0232231	螺钉螺母套件	SCREW NUT KIT	1
9	8M0225373	记忆活塞套件	MEMORY PISTON KIT	1
10	8M0225368	储液罐套件	RESERVOIR KIT	1
11	8M0174135	储液罐塞总成	PLUG RESERVOIR ASSEMBLY	1
12	8M0237525	泵套件	PUMP KIT	1
13	8M0225367	升降杆套件	TRIM ROD KIT	1
14	8M0242846	升降杆套件	TRIM ROD KIT	1
15	8M0225372	重建套件	REBUILD KIT	1

图 24动力升降组件金属马达壳 Power Trim Components Metal Motor Housing

REF	零件编号	中文名称	英文名称	数量
-	855998A3	动力升降倾斜装置总成	POWER TRIM Complete	1
-	855998A11	动力调整套件	POWER TRIM KIT	1
1	878265A4	配平电机	TRIM MOTOR	1
1	8M0031551	配平电机	TRIM MOTOR	1
2	NSS	电枢(不单独销售)	NOT SOLD SEPARATE Armature	1
3	NSS	端架(不单独销售)	NOT SOLD SEPARATE End Frame	1
4	82494830	螺钉 (M6 x 30)	SCREW (M6 x 30)	2
5	400256	锁紧垫圈 (M6)	LOCKWASHER (M6)	2
6	8782451	驱动轴	DRIVESHAFT	1
7	878410A1	压力检查套件	PO CHECK KIT	1
8	813442A2	手动释放总成	MANUAL RELEASE ASSEMBLY	1
8	893929A01	安全阀套件	VALVE KIT Relief	1
9	878241A1	轴套件	SHAFT KIT	1
9	8M0142997	倾斜轴套件	TILT SHAFT KIT	1
10	878267	销	PIN	1
11	878235A1	倾斜油缸总成	TILT CYLINDER ASSEMBLY	1
11	878235A03	倾斜油缸套件	CYLINDER KIT Tilt	1
12	878239A1	导向套件	GUIDE KIT	1
12	878239A02	倾斜缸端盖套件	END CAP KIT Tilt Cylinder	1
13	878409A1	O型圈套件	O-RING KIT	1
13	8M0142999	倾斜油缸O型圈套件	O RING KIT TILT CYLINDER	1
14	878412A1	减震杆套件	SHOCK ROD KIT	1
14	8M0168219	减震杆套件	SHOCK ROD KIT	1
15	878242A1	记忆活塞总成	PISTON ASSEMBLY Memory	1
15	8M0143000	记忆活塞套件	MEMORY PISTON KIT	1
16	878406A1	止回阀修理包	REPAIR KIT Check Valve	1
16	878406A02	止回阀修理包	REPAIR KIT Check Valve	1
17	878414A1	活塞总成	PISTON ASSEMBLY	1
17	878414T01	活塞总成	PISTON ASSEMBLY	1
18	878413A1	活塞总成	PISTON ASSEMBLY	1
19	878243A1	导向器总成	GUIDE ASSEMBLY	2
19	8M0021648	端盖总成	END CAP ASSEMBLY	2
20	878264A1	储液罐套件	RESERVOIR KIT	1
21	811613	塞子总成	PLUG ASSEMBLY	1
22	4000327	螺钉 (M6 x 14)	SCREW (M6 x 14)	4
23	43450	垫圈	WASHER	4
23	4002315	垫圈(6.60x12.5x1.5mm-不锈钢)	WASHER (6.60 X 12.5 X 1.5 mm -SS)	4
24	892251A01	泵套件	PUMP KIT	1
25	878408A1	动力升降倾斜装置维修包	REPAIR KIT Power Trim	1
26	821539	三叶销	PIN Trilobe	1
27	858771	螺钉 (M10 x 30)	SCREW (M10 x 30)	6
28	4002319	垫圈	WASHER	6
29	818298Q1	阳极套件	ANODE KIT	1
30	4000330	螺钉(M6x25)	SCREW (M6 x 25)	2
30	8M0204707	不锈钢六角大帽螺钉(M6x25)	SCREW M6 x 25 HX HD CAP SS	2
31	29245	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	2
31	8M0204649	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	2
32	996251	轴	SHAFT	1
32	99625002	轴	SHAFT	1
33	69205	C形垫圈	C WASHER	2
33	8M0084613	C形垫圈	C-WASHER	2
34	22875	卡扣	CLIP	2
35	878608	螺钉(#10-16 x 0.500)	SCREW (#10-16 x .500)	2
36	828547353	导管 (.350内径 x 3.00英尺散装)	CONDUIT (.350 Inside Diameter x 3.00 Feet Bulk)	1
37	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	1

图 25动力升降组件（塑料马达壳体） Power Trim Components Plastic Motor Housing

REF	零件编号	中文名称	英文名称	数量
-	8M0168222	动力升降总成	POWER TRIM ASSEMBLY	1
1	8M0142591	电机套件	MOTOR KIT	1
2	82494830	螺钉 (M6 x 30)	SCREW (M6 x 30)	2
3	400256	锁紧垫圈 (M6)	LOCKWASHER (M6)	2
4	8M0090403	驱动联轴器	COUPLING Drive	1
5	8M0142996	压力检查套件	PO CHECK KIT	1
6	8M0060141	手动释放套件	MANUAL RELEASE KIT	1
7	8M0142997	倾斜轴套件	TILT SHAFT KIT	1
8	878267	销	PIN	1
9	8M0142998	倾斜油缸总成	TILT CYLINDER ASSEMBLY	1
9	8M0168220	倾斜油缸总成	TILT CYLINDER ASSEMBLY	1
10	8M0142999	倾斜油缸O型圈套件	O RING KIT TILT CYLINDER	1
11	8M0143000	记忆活塞套件	MEMORY PISTON KIT	1
12	8M0142592	升降杆套件左舷	TRIM ROD KIT Port	1
13	8M0143001	活塞总成	PISTON ASSEMBLY	1
14	8M0143003	端盖总成	END CAP ASSEMBLY	1
15	878264A1	储液罐套件	RESERVOIR KIT	1
16	811613	塞子总成	PLUG ASSEMBLY	1
17	4000327	螺钉 (M6 x 14)	SCREW (M6 x 14)	4
18	4002315	垫圈(6.60x12.5x1.5mm-不锈钢)	WASHER (6.60 X 12.5 X 1.5 mm -SS)	4
19	8M0143004	泵套件	PUMP KIT	1
20	8M0148385	动力升降倾斜装置维修包	REPAIR KIT Power Trim	1
21	858771	螺钉 (M10 x 30)	SCREW (M10 x 30)	6
22	4002319	垫圈	WASHER	6
23	8M0094889	销	PIN	1
23	8M0161312	连杆销眼总成	PIN ROD EYE ASSEMBLY	1
24	8M0143005	减震杆套件	SHOCK ROD KIT	1
24	8M0168219	减震杆套件	SHOCK ROD KIT	1

图 26维修/支撑材料 Service/Support Material

零件编号	中文名称	英文名称	数量
80393402	零件手册 225X EFI PROMAX	PARTS MANUAL 225X EFI PROMAX	1
848714040	用户手册	OWNERS MANUAL	1
804673A02	EPA标签信息贴花	DECAL EPA Label Information	1
804673A03	EPA标签信息贴花	DECAL EPA Label Information	1
804673A04	EPA标签信息贴花	DECAL EPA Label Information	1
858610A31	燃油软管总成	HOSE ASSEMBLY Fuel	1
8M0038610	带注油球的燃油软管总成(9英尺)	HOSE ASSEMBLY Fuel (9 Feet) With Primer Bulb	1

图 27启动电机 Starter Motor

REF	零件编号	中文名称	英文名称	数量
1	853329T	启动电机总成	STARTER MOTOR ASSEMBLY	1
1	892339T01	启动电机总成	STARTER MOTOR ASSEMBLY	1
2	803005	贯穿螺栓	THRU BOLT	2
3	880805A1	齿轮套件	GEAR KIT	1
4	809463A1	电磁阀组件	SOLENOID KIT	1
5	69035	螺丝与锁紧垫圈(.250-20 x .625)不锈钢	SCREW AND LOCKWASHER (.250-20 x .625) Stainless Steel	1
6	93388A1	电缆总成(6.00英寸)黑色	CABLE ASSEMBLY (6.00 Inches) Black	1
7	8272822	警告标贴	DECAL Warning	1
8	400255	锁紧垫圈(M5)	LOCKWASHER (M5)	1
9	400211	螺母 (M5)不锈钢 (.25-20)	NUT (M5) Stainless Steel (.25-20)	1
10	26993	锁紧垫圈 (.312)	LOCKWASHER (.312)	1
10	8M0204647	锁紧垫圈 (.312)	LOCKWASHER (.312)	1
11	400213	不锈钢螺母 (M8)	NUT (M8) Stainless Steel	1
12	56703	轴环	COLLAR	2
12	8M0034918	轴环	COLLAR	2
13	879845	停机开关	STOP	1
13	8M0043276	停机开关	STOP	1
14	88439A25	电缆总成蓄电池-正极	CABLE ASSEMBLY Battery - Positive	1

图 28转向连接套件 Steering Attaching Kit

REF	零件编号	中文名称	英文名称	数量
-	92876A8	转向安装套件	ATTACHING KIT Steering	1
1	41055A1	支架总成	BRACKET ASSEMBLY	1
2	71565A2	管总成	TUBE ASSEMBLY	1
3	48462	O型圈 (.614 x .070)	O-RING (.614 x .070)	1
4	821203	锁紧垫圈	LOCKWASHER	2
5	37984	螺母 (.875-14)	NUT (.875-14)	2
5	8M0041651	螺母 (.875-14)	NUT (.875-14)	2
6	38601	螺丝(.250-28 x 1.250)	SCREW (.250-28 x 1.250)	4
7	78968	内锁紧垫圈 (.250)	LOCKWASHER Internal (.250)	4
8	850791T	联轴器	COUPLER	1
9	73732	螺钉 (.375-24 x 1.120)	SCREW (.375-24 x 1.120)	2
10	37828	不锈钢垫圈 (.390 x .625 x .062)	WASHER (.390 x .625 x .062) Stainless Steel	2
11	826709113	不锈钢螺母 (.375-24)	NUT (.375-24) Stainless Steel	3
11	8M0204726	黄铜螺母 (.375-24)	NUT (.375-24) Brass	3

图 29旋转支架和转向臂(长型) Swivel Bracket And Steering Arm (Long)

REF	零件编号	中文名称	英文名称	数量
1	8710T20	黑色旋转支架总成	SWIVEL BRACKET ASSEMBLY Black	1
1	8M0102865	黑色旋转支架总成	SWIVEL BRACKET ASSEMBLY Black	1
2	87735	下油封	SEAL Oil Lower	1
3	818764	衬套	BUSHING	2
4	816039	隔套	SPACER	1
5	33504	O型圈	O-RING	1
5	8M0214926	O型圈 @10	O RING @10	1
6	74036	润滑脂接头	FITTING Grease	2
6	8M0169589	润滑脂接头	FITTING Grease	2
7	821207	衬套	BUSHING	2
8	816432	止推垫片	THRUST WASHER	1
9	78689	螺钉（0.437-20 X 7.50）	SCREW (.437-20 x 7.50)	2
9	8M0176309	螺钉	SCREW	2
10	776981	支架	MOUNT	2
11	78688	垫圈	WASHER	2
12	34933	螺母(.437-20)不锈钢	NUT (.437-20) Stainless Steel	2
12	8M0204653	螺母	NUT	2
13	92876A10	连杆总成	LINK ROD ASSEMBLY	1
13	92876A12	连杆总成	LINK ROD ASSEMBLY	1
14	849838	螺钉(.375-24 x 1.250)	SCREW (.375-24 x 1.250)	1
15	826709113	不锈钢螺母 (.375-24)	NUT (.375-24) Stainless Steel	2
15	8M0204726	黄铜螺母 (.375-24)	NUT (.375-24) Brass	2
16	37828	不锈钢垫圈 (.390 x .625 x .062)	WASHER (.390 x .625 x .062) Stainless Steel	2
17	67706A55	转向臂转销总成	SWIVEL PIN ASSEMBLY Steering Arm	1
17	826432A2	转向臂旋转销总成-不锈钢	SWIVEL PIN ASSEMBLY Steering Arm - Stainless Steel	1
18	86580A1	底部轭架总成	YOKE ASSEMBLY Bottom	1
18	878182T	轭架底部-不锈钢	YOKE Bottom - Stainless Steel	1
19	67684	挡圈	RING Retaining	1
20	54457	J型卡扣	J CLIP	1
21	859187A1	调整传感器总成	SENDER ASSEMBLY Trim	1
22	852368	螺钉（#10-24 X 0.750）	SCREW (#10-24 x .750)	2
23	26996	锁紧垫圈(#10)(不锈钢)	LOCKWASHER (#10) Stainless Steel	2
24	89302	垫圈(0.203×0.406×0.040)	WASHER (.203 x .406 x .040)	2
25	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	1
26	996301	冲击板	STRIKER PLATE	2
26	8M0045383	冲击板	STRIKER PLATE	2
27	58643	锁紧垫圈 (.375)	LOCKWASHER (.375)	2
28	46335	螺母 (.375-24)	NUT (.375-24)	2

图 30旋转支架和转向臂(短型) Swivel Bracket And Steering Arm (Short)

REF	零件编号	中文名称	英文名称	数量
1	818810A14	旋转支架总成	SWIVEL BRACKET ASSEMBLY	1
1	8M0145740	旋转支架	SWIVEL BRACKET	1
2	847729	油封	SEAL Oil	2
3	847726	轴承	BEARING	2
4	74036	润滑脂接头	FITTING Grease	2
4	8M0169589	润滑脂接头	FITTING Grease	2
5	847728	轴承	BEARING	2
6	82203522	轴承	BEARING	1
6	82203516	轴承	BEARING	1
6	82203524	轴承 (1.50英寸)	BEARING (1.50 Inch)	2
7	82203540	轴承 (2.50英寸)	BEARING (2.50 Inch)	2
8	85023	油封	SEAL Oil	2
9	87161	垫圈	WASHER	2
10	48171	O型圈(0.364 x 0.070)	O-RING (.364. x .070)	2
11	85030A2	倾斜锁定杆总成	LEVER ASSEMBLY Tilt Lock	1
11	85028A2	倾斜锁定杆总成	LEVER ASSEMBLY Tilt Lock	1
12	86600	衬套	BUSHING	1
13	85367	弹簧	SPRING	1
14	41052	柱塞	PLUNGER	1
15	88876	螺柱	STUD	1
16	86603	旋钮	KNOB	1
17	864751	联轴器	COUPLING	1
18	69745	滚动销	PIN Roll	2
19	88049	弹簧	SPRING	1
20	93861	开口销	COTTER PIN	1
21	78854	波形垫圈	WAVE WASHER	1
22	86580F4	下轭架	YOKE Bottom	1
23	848125	螺旋锁紧挡圈	RING Retaining - Spiral Lock	2
24	8407871	旋转销	SWIVEL PIN	1
24	8M0192243	旋转销	PIN-SWIVEL	1
25	92876A10	连杆总成	LINK ROD ASSEMBLY	1
25	92876A12	连杆总成	LINK ROD ASSEMBLY	1
26	849838	螺钉(.375-24 x 1.250)	SCREW (.375-24 x 1.250)	1
27	34933	螺母(.437-20)不锈钢	NUT (.437-20) Stainless Steel	2
27	8M0204653	螺母	NUT	2
28	37828	不锈钢垫圈 (.390 x .625 x .062)	WASHER (.390 x .625 x .062) Stainless Steel	2
29	132121	螺钉	SCREW	2
30	816056	垫圈	WASHER	2
31	88512	卡箍	CLAMP	1
32	88829	螺钉(#10-24x0.500)	SCREW (#10-24 x .500)	1
33	841198A1	配平传感器总成	SENSOR ASSEMBLY Trim	1
34	852453	螺钉(#10-24 x .560)	SCREW (#10-24 x .560)	2

图 31油门杆和换挡轴(序列号0T818234及以下) Throttle Lever And Shift Shaft (S/N-0T818234 & Below)

REF	零件编号	中文名称	英文名称	数量
1	8503891	节气门控制杆	LEVER Throttle Control	1
1	8M0040990	节气门控制杆	LEVER Throttle Control	1
2	818165	螺钉 (.375-16 x 1.75)	SCREW (.375-16 x 1.75)	1
3	55164	衬套	BUSHING	1
4	858959	隔套	SPACER	1
5	64022	螺钉(.250-20 x 2.125)	SCREW (.250-20 x 2.125)	1
6	64015	螺母 (.250-20)	NUT (.250-20)	1
7	26852	尼龙帽	CAP Nylon	1
8	42927	嵌件	INSERT	1
9	35459	垫圈	WASHER	1
10	401386	螺母(M6)不锈钢	NUT (M6) Stainless Steel	1
11	858847A2	凸轮	CAM	1
12	932481	衬套	BUSHING	1
12	8M0215006	旋转衬套	BUSHING Swivel	1
13	8235694	螺纹球头	BALL Threaded	1
14	856895	衬套	BUSHING	1
15	856896	轴承	BEARING	1
16	8508152	杆	ROD	1
17	840968	滚轮	ROLLER	1
17	8M0072162	滚轮	ROLLER	1
18	8502861	杠杆	LEVER	1
18	850286A03	油门杆/滚轮套件	LEVER/ROLLER KIT Throttle	1
19	40056107	螺钉(M5×16)	SCREW (M5 x 16)	1
20	89302	垫圈(0.203×0.406×0.040)	WASHER (.203 x .406 x .040)	1
21	27882	垫圈	WASHER	2
22	814283T6	锚支架总成	BRACKET ASSEMBLY Anchor	1
23	98889	闩锁	LATCH	1
24	42975	传动螺钉	DRIVE SCREW	2
25	39519	杯套	CUP	1
26	52100	耐磨板	WEAR PLATE	1
27	38279	闩锁	LATCH	1
27	8M0036768	闩锁	LATCH	1
28	69056	垫圈(.255 x .620 x .030) 不锈钢	WASHER (.255 x .620 x .030) Stainless Steel	1
29	826709109	不锈钢螺母(.250-28)	NUT (.250-28) Stainless Steel	1
30	28782	螺钉(.312-18 x .880)不锈钢	SCREW (.312-18 x .880) Stainless Steel	3
31	814284	导向块	GUIDE BLOCK	1
32	20099	弹簧	SPRING	1
33	67073A1	连杆总成	LINK ROD ASSEMBLY	1
34	79932A18	换挡轴总成	SHIFT SHAFT ASSEMBLY	1
34	79932A16	换挡轴总成	SHIFT SHAFT ASSEMBLY	1
35	NSS	弹性销(不单独销售)	NOT SOLD SEPARATE Roll Pin	1
36	NSS	不单独销售换档轴杆(上部)	NOT SOLD SEPARATE Shift Shaft Lever - Upper	1
37	26856	衬套	BUSHING	1
38	29720	波形垫圈	WAVE WASHER	1
39	35462	垫圈(.2656 x .625 x .0625)不锈钢	WASHER (.2656 x .625 x .0625) Stainless Steel	1
40	826709109	不锈钢螺母(.250-28)	NUT (.250-28) Stainless Steel	1
41	814281A2	开关	SWITCH	1
41	8M0052931	开关	SWITCH	1
42	77478	螺钉 (#6-32 x .875)	SCREW (#6-32 x .875)	2
43	81893440	螺钉 (M8 x 40)	SCREW (M8 x 40)	1
44	932481	衬套	BUSHING	1
44	8M0215006	旋转衬套	BUSHING Swivel	1
-	809430T02	动力头总成	POWERHEAD ASSEMBLY	1

图 32油门杆和换挡轴(序列号0T818235及以上) Throttle Lever And Shift Shaft (S/N-0T818235 & Up)

REF	零件编号	中文名称	英文名称	数量
1	8503891	节气门控制杆	LEVER Throttle Control	1
1	8M0040990	节气门控制杆	LEVER Throttle Control	1
2	818165	螺钉 (.375-16 x 1.75)	SCREW (.375-16 x 1.75)	1
3	55164	衬套	BUSHING	1
4	858959	隔套	SPACER	1
5	64022	螺钉(.250-20 x 2.125)	SCREW (.250-20 x 2.125)	1
6	64015	螺母 (.250-20)	NUT (.250-20)	1
7	26852	尼龙帽	CAP Nylon	1
8	42927	嵌件	INSERT	1
9	35459	垫圈	WASHER	1
10	401386	螺母(M6)不锈钢	NUT (M6) Stainless Steel	1
11	814283T6	锚支架总成	BRACKET ASSEMBLY Anchor	1
12	98889	闩锁	LATCH	1
13	42975	传动螺钉	DRIVE SCREW	2
14	39519	杯套	CUP	1
15	52100	耐磨板	WEAR PLATE	1
16	38279	闩锁	LATCH	1
16	8M0036768	闩锁	LATCH	1
17	35462	垫圈(.2656 x .625 x .0625)不锈钢	WASHER (.2656 x .625 x .0625) Stainless Steel	1
18	826709109	不锈钢螺母(.250-28)	NUT (.250-28) Stainless Steel	1
19	28782	螺钉(.312-18 x .880)不锈钢	SCREW (.312-18 x .880) Stainless Steel	3
20	814284	导向块	GUIDE BLOCK	1
21	20099	弹簧	SPRING	1
22	67073A1	连杆总成	LINK ROD ASSEMBLY	1
23	79932A18	换挡轴总成	SHIFT SHAFT ASSEMBLY	1
23	79932A16	换挡轴总成	SHIFT SHAFT ASSEMBLY	1
24	NSS	弹性销(不单独销售)	NOT SOLD SEPARATE Roll Pin	1
25	NSS	不单独销售换档轴杆(上部)	NOT SOLD SEPARATE Shift Shaft Lever - Upper	1
26	26856	衬套	BUSHING	1
27	29720	波形垫圈	WAVE WASHER	1
28	35462	垫圈(.2656 x .625 x .0625)不锈钢	WASHER (.2656 x .625 x .0625) Stainless Steel	1
29	826709109	不锈钢螺母(.250-28)	NUT (.250-28) Stainless Steel	1
30	889514A02	开关	SWITCH	1
30	889514T02	开关	SWITCH	1
31	77478	螺钉 (#6-32 x .875)	SCREW (#6-32 x .875)	2
32	27882	垫圈	WASHER	2
33	932481	衬套	BUSHING	1
33	8M0215006	旋转衬套	BUSHING Swivel	1
34	8508152	杆	ROD	1
35	858847A2	凸轮	CAM	1
36	8235694	螺纹球头	BALL Threaded	1
37	932481	衬套	BUSHING	1
37	8M0215006	旋转衬套	BUSHING Swivel	1
38	81893440	螺钉 (M8 x 40)	SCREW (M8 x 40)	1
39	856895	衬套	BUSHING	1
40	850286A03	油门杆/滚轮套件	LEVER/ROLLER KIT Throttle	1
41	889610	滚轮	ROLLER	1
41	8M0072162	滚轮	ROLLER	1
42	56681	垫圈 (.203 x .500 x .032)	WASHER (.203 x .500 x .032)	1
42	8M0204666	垫圈 (.203 x .500 x .032)	WASHER (.203 x .500 x .032)	1
43	826709104	螺母(#8-32)不锈钢	NUT (#8-32) Stainless Steel	1
44	889354	专用螺钉	SCREW Special	1
45	881991	杯形垫圈	WASHER Cupped	1
45	8M0095734	垫圈/螺钉套件	WASHER/SCREW KIT	1
46	881992	线轴垫圈	WASHER Spool	1
46	8M0095734	垫圈/螺钉套件	WASHER/SCREW KIT	1
47	69432	外锁紧垫圈(#10)	LOCKWASHER External (#10)	1
-	809430T02	动力头总成	POWERHEAD ASSEMBLY	1

图 33顶罩 Top Cowl

REF	零件编号	中文名称	英文名称	数量
1	849203T23	顶盖总成	TOP COWL ASSEMBLY	1
2	849209A3	护罩	SHIELD	1
3	8488081	锁扣支架	BRACKET Latch	1
4	849179	安装板	PLATE	1
5	18173	锁扣滚轮支架总成	BRACKET ASSEMBLY Latch Roller	1
5	893763	滚轮锁扣支架	BRACKET Roller Latch	1
6	814806	垫圈 (.344 x .688 x .065) 不锈钢	WASHER (.344 x .688 x .065) Stainless Steel	2
6	8M0204690	垫圈 (.344 x .688 x .065) 不锈钢	WASHER (.344 x .688 x .065) Stainless Steel	2
7	53166	锁紧垫圈 (.312)	LOCKWASHER (.312)	2
8	28782	螺钉(.312-18 x .880)不锈钢	SCREW (.312-18 x .880) Stainless Steel	2
9	849011	螺钉(.250-20 x .750)	SCREW (.250-20 x .750)	4
10	849834A1	闩锁	LATCH	1
11	29245	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	7
11	8M0204649	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	7
12	8267098	螺母 (.250-20) 不锈钢	NUT (.250-20) Stainless Steel	3
13	814101	螺母 (.250-20) 不锈钢	NUT (.250-20) Stainless Steel	4
13	8M0207776	螺母	NUT	4
0	840323A1	贴花套件	DECAL SET	1
0	840323A21	贴花套件	DECAL SET	1

图 34艉板支架(长型) Transom Brackets (Long)

REF	零件编号	中文名称	英文名称	数量
1	828334T03	艉板支架总成-右舷	BRACKET ASSEMBLY Transom-Starboard	1
2	828333T08	艉板支架总成-左舷	BRACKET ASSEMBLY Transom-Port	1
3	98727	润滑脂接头	FITTING Grease	1
3	8M0169588	润滑脂接头	FITTING Grease	1
4	826125A1	倾斜管	TILT TUBE	1
5	826135	尼龙锁紧螺母(1.00-14)	NUT Lock (1.00-14) Nylon Insert	1
6	45711	O型圈 (.612 x .103)	O-RING (.612 x .103)	1
7	88750	波浪垫圈 (1.62 x 1.05)	WASHER Wave (1.62 x 1.05)	2
8	826164	螺母 (.875-14)	NUT (.875-14)	1
8	8M0231351	锁紧螺母	NUT Lock	1
9	677551	螺钉(.500-20×4.500)	SCREW (.500-20 x 4.500)	4
9	8M0149747	螺钉	SCREW	4
10	54012	垫圈(0.530×0.870×0.105不锈钢)	WASHER (.530 x .870 x .105) Stainless Steel	4
10	8M0204665	垫圈(0.530×0.880×0.104 630不锈钢)	WASHER (.530 x .880 x .104) 630 Stainless Steel	4
11	28421	垫圈(1.5x3.05x0.13)不锈钢	WASHER (1.5 x 3.05 x 0.13) Stainless Steel	4
11	8M0204648	垫圈(1.5x3.05x0.13)不锈钢	WASHER (1.5 x 3.05 x 0.13) Stainless Steel	4
12	82671117	螺母(.500-20)	NUT (.500-20)	4
13	99629T2	倾斜锁定杆总成	LEVER ASSEMBLY Tilt Lock	1
13	8M0115104	倾斜锁定杆总成	LEVER ASSEMBLY Tilt Lock	1
14	830899	张力弹簧	SPRING Tension	1
15	65830	尼龙衬套	NYLINER	2
16	830900	压缩弹簧	SPRING Compression	1
17	99633	旋钮	KNOB	1
18	99615	槽销	PIN Groove	1
19	99617	销	PIN	1
19	893709	销	PIN	1

图 35艉板支架(短型) Transom Brackets (Short)

REF	零件编号	中文名称	英文名称	数量
1	847800A1	艉板支架总成	BRACKET ASSEMBLY Transom	1
1	844353T01	艉板套件	TRANSOM KIT	1
2	847801A1	艉板支架总成	BRACKET ASSEMBLY Transom	1
2	847801T01	艉板支架-右舷	BRACKET Transom - Starboard	1
3	847798A1	耐磨垫套件	WEAR PAD KIT	1
3	847798A02	耐磨垫套件	WEAR PAD KIT	1
4	86843	螺钉(#10-24x0.500)	SCREW (#10-24 x .500)	4
5	87180	螺栓(0.500-20 x 11.00)	BOLT (.500-20 x 11.00)	1
6	88512	卡箍	CLAMP	4
6	75275	卡箍	CLAMP	2
7	88829	螺钉(#10-24x0.500)	SCREW (#10-24 x .500)	6
8	858869	螺母 (.875-14)	NUT (.875-14)	1
8	859133	螺母(1.00-14)	NUT (1.00-14)	1
8	82671327	螺母(1.0-14)	NUT (1.0-14)	1
9	88750	波浪垫圈 (1.62 x 1.05)	WASHER Wave (1.62 x 1.05)	2
10	99170A2	倾斜管套件	TUBE KIT Tilt	1
10	826125A1	倾斜管	TILT TUBE	1
11	85035T	隔套	SPACER	1
11	8M0237541	艉板隔套	SPACER Transom	1
12	677551	螺钉(.500-20×4.500)	SCREW (.500-20 x 4.500)	4
12	8M0149747	螺钉	SCREW	4
12	677552	螺钉(0.500-20 x 6.500)	SCREW (.500-20 x 6.500)	AR
13	28421	垫圈(1.5x3.05x0.13)不锈钢	WASHER (1.5 x 3.05 x 0.13) Stainless Steel	4
13	8M0204648	垫圈(1.5x3.05x0.13)不锈钢	WASHER (1.5 x 3.05 x 0.13) Stainless Steel	4
14	82671317	螺母(.500-20)	NUT (.500-20)	4
15	82671317	螺母(.500-20)	NUT (.500-20)	1
16	70732	螺钉 (.250-20 x 2.00)	SCREW (.250-20 x 2.00)	4
17	29245	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	4
17	8M0204649	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	4
18	85026T	安装板	PLATE	2
19	28636	螺钉(.250-20 x .750)	SCREW (.250-20 x .750)	4
20	29245	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	4
20	8M0204649	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	4
21	54343	螺柱（.312-24 x 1.380）	STUD (.312-24 x 1.380)	4
21	8M0034451	螺柱	STUD	4
22	89949A1	隔板总成	PLATE ASSEMBLY	1
23	847539	垫圈	WASHER	4
24	82670911	螺母(.312-24)不锈钢	NUT (.312-24) Stainless Steel	4
25	89024	液压软管	HOSE Hydraulic	1
25	89023	液压软管	HOSE Hydaulic	1
26	96993	液压软管	HOSE Hydraulic	1
26	96994	液压软管	HOSE Hydraulic	1
27	87871	盖板	COVER	1
27	87871T	盖板	COVER	1
28	45507	护孔环	GROMMET	1
29	32866	螺钉 (#10-32 x 2.00) 不锈钢	SCREW (#10-32 x 2.00) Stainless Steel	4
30	87775	衬垫	GASKET	1
31	20878	垫圈	WASHER	4
32	826709106	螺母 (#10-32) 不锈钢	NUT (#10-32) Stainless Steel	4
32	8M0204718	螺母	NUT	4
33	79610T29	配平油缸	TRIM CYLINDER	1
33	79610A33	配平油缸套件	TRIM CYLINDER KIT	1
33	79610A21	配平油缸	TRIM CYLINDER	1
33	79610T29	配平油缸	TRIM CYLINDER	1
34	847724	衬套	BUSHING	2
35	841223	轴承	BEARING	1
36	30316	弹簧	SPRING	2
37	85020T	枢轴销	PIN Pivot	2
38	841199	调整销	PIN Trim	1
38	8220752	调整销	PIN Trim	1
39	822076	固定座	RETAINER	1
40	82671317	螺母(.500-20)	NUT (.500-20)	1
41	8071791	紧定螺钉（.250-20 x .820）	SET SCREW (.250-20 x .820)	1
42	85022	垫圈(2.00 x 1.06 x 0.060)	WASHER (2.00 x 1.06 x .060)	2
43	45711	O型圈 (.612 x .103)	O-RING (.612 x .103)	1
44	54012	垫圈(0.530×0.870×0.105不锈钢)	WASHER (.530 x .870 x .105) Stainless Steel	1
44	8M0204665	垫圈(0.530×0.880×0.104 630不锈钢)	WASHER (.530 x .880 x .104) 630 Stainless Steel	1
-	79879A1		REPAIR KIT For Trim Cylinders	1

图 36油气分离器组件 Vapor Separator Components

REF	零件编号	中文名称	英文名称	数量
-	NSS	不单独销售油气分离器总成	NOT SOLD SEPARATE Vapor Seperator Assembly	1
1	883245T3	盖板套件	COVER KIT	1
2	881740	直通接头	FITTING Straight	1
3	883249	接头	FITTING	1
4	NSS	不单独销售弯头	NOT SOLD SEPARATE Elbow	1
5	855437A2	泵出口接头套件	FITTING KIT Pump Outlet	1
6	883209	O型圈	O-RING	1
6	8M0062785	O型圈	O-RING	1
7	883219	阀门	VALVE	1
8	883220	盖帽	CAP	1
9	883208	堵头	PLUG	1
10	883248	密封件	SEAL	1
11	883252	衬垫	GASKET	1
12	883257T1	调节器	REGULATOR	1
13	883593A1	O型圈套件	O-RING KIT	1
14	883258	垫圈	WASHER	1
15	883261	螺钉(M5×0.8)	SCREW (M5 x .8)	2
16	883261	螺钉(M5×0.8)	SCREW (M5 x .8)	1
17	881831	线束总成	WIRE ASSEMBLY	1
18	808612	螺钉及垫圈 (#8-32 x .750)	SCREW AND WASHER (#8-32 x .750)	7
19	883253A1	浮子套件	FLOAT KIT	1
20	F10064	轴	SHAFT	1
21	883247A1	进油阀/阀座组件	VALVE/SEAT KIT Inlet	1
22	883223	螺钉(M6 x 16)	SCREW (M6 x 16)	1
23	18458Q4	燃油水分离滤清器	FILTER Fuel-Water Separating	1
24	8285861	探头	PROBE	1
24	8M0204710	探头	PROBE	1
25	883260	挡板	BAFFLE	1
25	889318002	挡板燃油	BAFFLE Fuel	1
26	883223	螺钉(M6 x 16)	SCREW (M6 x 16)	3
27	881705T1	泵套件	PUMP KIT	1
28	855428	套筒	SLEEVE	1
28	8M6000589	套筒	SLEEVE	1
29	883256T1	油杯套件	BOWL KIT	1
30	883248	密封件	SEAL	1
31	855435A1	塞套件	PLUG KIT	1
32	883209	O型圈	O-RING	1
32	8M0062785	O型圈	O-RING	1
33	81893435	螺钉(M8×35)	SCREW (M8 x 35)	3
33	8M0103814	螺钉 (M8 x 35 毫米)	SCREW (M8 x 35 MM)	3
34	855364	衬套	BUSHING	3
35	855362	护孔环	GROMMET	3
35	855362001	护孔环	GROMMET	3
36	817274	垫圈(0.344×1.00×0.063)不锈钢	WASHER (.344 x 1.00 x .063) Stainless Steel	3

图 37水管 Water Hoses

REF	零件编号	中文名称	英文名称	数量
1	830756109	软管 (57.00英寸整卷)水坝	HOSE (57.00 Inches Bulk) Water Dams	1
1	8M0108355	软管(57英寸散装)	HOSE (57 Inches Bulk)	1
2	881866	接头	FITTING	1
3	85978571	管材 (52.00英寸整卷)(截取12.00英寸)	TUBING (52.00 Inches Bulk) (Cut to 12.00 Inch Length)	1
4	859431	接头	FITTING	1
4	8M0207782	直通接头	FITTING Straight	1
5	875207	三通接头	TEE Fitting	1
6	85978571	管材 (52.00英寸整卷)(截取44.00英寸)	TUBING (52.00 Inches Bulk) (Cut to 44.00 Inch Length)	1
7	859747	联轴器	COUPLER	1
7	8M0214971	耦合接头 (4 MM)	COUPLER Fitting (4 MM)	1
8	859732	堵头	PLUG	1
9	85978571	管材 (52.00英寸整卷)(截取1.50英寸)	TUBING (52.00 Inches Bulk) (Cut to 1.50 Inch Length)	1
-	809430T02	动力头总成	POWERHEAD ASSEMBLY	1