水星 Mercury 250 HP Pro XS 6 CYL (3.0L) 1B426561 THRU 1B752546 - 爆炸图零件明细

两冲程 直喷 DFI OptiMax · USA - Cat.# 90-898101403 · 共 76 个部位 · 3323 条零件

图 1空气压缩机组件 Air Compressor Components

REF	零件编号	中文名称	英文名称	数量
1	828123T31	空气压缩机总成	COMPRESSOR ASSEMBLY Air	1
2	828131A11	端盖总成	END CAP ASSEMBLY	1
2	8M0050793	REF SOB 11-14	REF SOB 11-14	1
3	NSS	卡环(不单独销售)	NOT SOLD SEPARATE Snap Ring	1
4	82130020	螺钉 (M6 x 20)	SCREW (M6 x 20)	4
5	89224001	O型圈	O-RING	1
6	67206001	O型圈	O-RING	1
7	833146T06	连杆总成	CONNECTING ROD ASSEMBLY	1
8	NSS		NOT SOLD SEPARATE Piston Assembly	1
9	8348101	锁环	RING Lock	2
10	835088A10	簧片阀板总成	REED PLATE ASSEMBLY	1
11	67207	O型圈（3.489 x 0.070）	O-RING (3.489 x .070)	2
12	832804	O型圈（2.739 x 0.070）	O-RING (2.739 x .070)	1
13	828225	密封件	SEAL	1
14	835087A3	压缩机缸盖总成	HEAD ASSEMBLY Compressor	1
14	8M0073890	压缩机缸盖套件	HEAD KIT Compressor	1
15	8307535	直通接头	FITTING Straight	1
16	82127335	螺钉 (M8 x 35 毫米)	SCREW (M8 x 35 MM)	4
17	151331	接头	FITTING	1
18	996642	90度弯头接头(0.125-27x0.250)尼龙	FITTING Elbow 90 Degree (.125-27 x .250) Nylon	1
19	428641	止回阀接头	FITTING Check Valve	2
20	856744	接头	FITTING	1
21	16604	直通接头（0.125-27）	FITTING Straight (.125-27)	1
22	831985	O型圈（0.468 x 0.078）	O-RING (.468 x .078)	1
23	13536A14	温度传感器总成	SENSOR ASSEMBLY Temperature	1
24	137151	固定座	RETAINER	1
25	81893414	螺钉（M8 x 14）	SCREW (M8 x 14)	1
26	390721	黄铜管塞 (.125-27)	PLUG Pipe (.125-27) Brass	1
27	85593912	螺钉（M6 x 12）	SCREW (M6 x 12)	6
28	8328233	滑轮	PULLEY	4
28	8M0175171	滑轮	PULLEY	4
29	891570050	螺钉(M8 x 50)	SCREW (M8 x 50)	4
29	8M0045380	螺钉(M8 x 50)	SCREW (M8 x 50)	4
-	832804A03	O型圈套件	O-RING KIT	1

图 2空气处理器 Air Handler

REF	零件编号	中文名称	英文名称	数量
-	878112T08	空气处理器总成	AIR HANDLER ASSEMBLY	1
1	858541T4	适配板	ADAPTER PLATE	1
2	841220	衬垫	GASKET	1
3	840418T04	簧片阀总成	REED BLOCK ASSEMBLY	6
4	840445A04	簧片阀总成	REED PETAL ASSEMBLY	1
5	849038	螺钉 (M3 x 5)	SCREW (M3 x 5)	60
6	840447	簧片阀板	REED PLATE	12
7	8555252	螺钉 (M6)	SCREW (M6)	12
8	855364	衬套	BUSHING	3
9	855362001	护孔环	GROMMET	3
10	817274	垫圈(0.344×1.00×0.063)不锈钢	WASHER (.344 x 1.00 x .063) Stainless Steel	3
11	81893435	螺钉(M8×35)	SCREW (M8 x 35)	3
11	8M0103814	螺钉 (M8 x 35 毫米)	SCREW (M8 x 35 MM)	3
12	8M0001447	支架	BRACKET	1
13	858708T1	空气集气室套件	PLENUM KIT Air	1
14	804679004	衬垫	GASKET	1
15	883942	螺钉(M4×16)	SCREW (M4 x 16)	2
16	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	1
17	804842	卡箍	CLAMP	1
18	857149T05	油泵总成	PUMP ASSEMBLY Oil	1
18	8M0185614	机油泵	OIL PUMP	1
19	854445	MAP传感器	SENSOR MAP	1
19	8M0237529	MAP传感器	SENSOR MAP	1
20	884522	MAP传感器支架	BRACKET MAP Sensor	1
21	1993716	螺钉(M6 x 16)	SCREW (M6 x 16)	1
22	885342002	传感器总成	SENSOR ASSEMBLY	1
22	8M0148668	传感器总成	SENSOR ASSEMBLY	1
23	896699	O型圈（1.78毫米 x 0.08毫米）	O-RING (1.78 mm x .08 mm)	1
24	841194T03	节气门体总成	THROTTLE BODY ASSEMBLY	1
24	841194T04	节气门体总成	THROTTLE BODY ASSEMBLY	1
25	891774	衬套	BUSHING	1
26	853659A01	节气门杆套件	LEVER KIT Throttle	1
27	858851A03	节气门杠杆总成	LEVER ASSEMBLY Throttle	1
28	889610	滚轮	ROLLER	1
28	8M0072162	滚轮	ROLLER	1
29	56681	垫圈 (.203 x .500 x .032)	WASHER (.203 x .500 x .032)	1
29	8M0204666	垫圈 (.203 x .500 x .032)	WASHER (.203 x .500 x .032)	1
30	826709104	螺母(#8-32)不锈钢	NUT (#8-32) Stainless Steel	1
31	889354	专用螺钉	SCREW Special	1
32	881991	杯形垫圈	WASHER Cupped	1
32	8M0095734	垫圈/螺钉套件	WASHER/SCREW KIT	1
33	881992	线轴垫圈	WASHER Spool	1
33	8M0095734	垫圈/螺钉套件	WASHER/SCREW KIT	1
34	69432	外锁紧垫圈(#10)	LOCKWASHER External (#10)	1
35	82130040	螺钉(M6 x 40)	SCREW (M6 x 40)	4
36	855426	O型圈	O-RING	1
37	850296A5	盖板	COVER	1
37	8M0111168	盖板	COVER	1
38	86361	护孔环	GROMMET	1
39	13467	衬套（内径0.88）	GROMMET (.88 Inside Diameter)	1
40	821555001	护孔环	GROMMET	2
40	8M0153609	护孔环	GROMMET	2
41	881865	警示贴纸-挂档启动	DECAL Caution-Start in Gear	1
42	854343T11	空气消音器	ATTENUATOR Air	1
43	82130050	螺钉(M6 x 50)	SCREW (M6 x 50)	1
44	NSS	87辛烷值贴纸（不单独销售）	NOT SOLD SEPARATE Decal-87 Octane	1
45	858902	卡箍	CLAMP	1
46	29245	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	1
46	8M0204649	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	1
47	82130040	螺钉(M6 x 40)	SCREW (M6 x 40)	12
48	29245	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	1
48	8M0204649	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	1
49	881879A16	皮托管传感器总成	SENSOR ASSEMBLY Pitot	1
49	881879T25	皮托管传感器总成	SENSOR ASSEMBLY Pitot	1
50	881879011	压力传感器 (0 - 100 PSI)	SENSOR Pressure (0 - 100 PSI)	1
50	881879T11	压力传感器 (0 - 100 PSI)	SENSOR Pressure (0 - 100 PSI)	1
51	892403	接头	FITTING	1
51	8M0207782	直通接头	FITTING Straight	1
52	883066	夹子 (.865)	CLIP (.865)	1
NS	69056	垫圈(.255 x .620 x .030) 不锈钢	WASHER (.255 x .620 x .030) Stainless Steel	1
-	832933A05	动力头衬垫套件	GASKET SET Powerhead	1
-	841220A03	动力头衬垫套件	GASKET SET Powerhead	1
-	843034A07	动力头总成	POWERHEAD ASSEMBLY	1

图 3空气软管 Air Hoses

REF	零件编号	中文名称	英文名称	数量
1	856842	弯头	ELBOW	1
2	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	AR
3	830757130	管材(.312)(70英寸整卷)(裁切至8英寸)	TUBING (.312) (70.00 Inches Bulk) (Cut to 8 Inches)	1
3	8M0108349	软管 (70英寸散装)	HOSE (70 Inches Bulk)	1
4	856880	软管卡箍（15.3）	CLAMP Hose (15.3)	2
4	8M0214964	卡箍	CLAMP	2
5	8567631	软管总成	HOSE ASSEMBLY	1
6	889314	空气旁通软管	HOSE Air By-Pass	1
7	804829	空气平衡软管总成	HOSE ASSEMBLY Air Balance	1
7	8M6001365	软管总成	HOSE ASSEMBLY	1
-	804532	O型圈套件	O-RING KIT	1
8	888827	软管/套管	HOSE/SLEEVE	1
8	8M0116380	套筒	SLEEVE	1
9	875271	90度接头-黄铜(.125-27)	FITTING 90 Degree - Brass (.125-27)	1
10	887630	成型软管	HOSE Molded	1
-	843034A07	动力头总成	POWERHEAD ASSEMBLY	1

图 4下罩 Bottom Cowl

REF	零件编号	中文名称	英文名称	数量
1	850302A07	下罩盖（左舷）	BOTTOM COWL Port	1
2	854367001	堵头	PLUG	1
3	850301A07	下罩盖（右舷）	BOTTOM COWL Starboard	1
3	8M0107323	下罩盖（右舷）	BOTTOM COWL Starboard	1
4	889246A97	衬垫套件	GASKET KIT	1
5	82130040	螺钉(M6 x 40)	SCREW (M6 x 40)	4
6	824868	螺钉(M6×75)	SCREW (M6 x 75)	3
7	29245	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	2
7	8M0204649	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	2
8	850684F1	前手柄	FRONT HANDLE	1
8	8M0053903	前手柄	FRONT HANDLE	1
9	335891	衬套	BUSHING	2
10	48462	O型圈 (.614 x .070)	O-RING (.614 x .070)	1
11	8219423	棘爪	PAWL	1
12	69057	垫片(.281 x .734 x .063)	WASHER (.281 x .734 x .063)	1
13	401366	螺母(M6)不锈钢	NUT (M6) Stainless Steel	3
14	8214281	螺钉(#10-16x0.625)	SCREW (#10-16 x .625)	1
15	822873	卡扣	CLIP	1
16	896620001	升降倾斜开关	SWITCH Trim	1
16	8M0235191	升降倾斜开关	SWITCH Trim	1
17	842756T01	索具套件	RIGGING KIT	1
18	842744002	支架	BRACKET	1
19	82130012	螺钉（M6 x 12）	SCREW (M6 x 12)	3
20	843185T02	联轴器	COUPLER	1
21	842756005	软管	HOSE	1
22	843174002	联轴器	COUPLER	1
23	47994	螺钉 (#10 x 1.50)	SCREW (#10 x 1.50)	4
24	852361T1	机罩手柄	HANDLE Cowl	2
24	850682A06	支架和手柄套件	BRACKET AND HANDLE KIT	2
24	852361T02	手柄	HANDLE	1
25	29402	波形垫圈	WAVE WASHER	2
26	8M0011984	密封件	SEAL	1
26	8M0109222	密封件	SEAL	1

图 5线圈板 Coil Plate

REF	零件编号	中文名称	英文名称	数量
-	NSS	不单独销售 线圈安装板总成-完整	NOT SOLD SEPARATE Coil Mounting Plate Assembly-Complete	1
1	884272T	线圈安装板	PLATE Coil Mounting	1
2	879984A1	线圈套件	COIL KIT	6
2	8M0077471	点火线圈	IGNITION COIL	6
3	82129130	螺钉 (M6 x 30)	SCREW (M6 x 30)	12
4	881908T	电缆组	CABLE SET	1
5	858414A1	编织电缆总成	CABLE ASSEMBLY Braided	2
6	82129110	螺丝 (M6 x 10)	SCREW (M6 x 10)	4
7	29245	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	4
7	8M0204649	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	4
8	833155	护孔环	GROMMET	4
9	8502341	衬套	BUSHING	4
10	881879A20	传感器总成 压力	SENSOR ASSEMBLY Pressure	1
10	881879T26	传感器 压力	SENSOR Pressure	1
11	892403	接头	FITTING	1
11	8M0207782	直通接头	FITTING Straight	1
12	883066	夹子 (.865)	CLIP (.865)	1
13	85978571	管材（52英寸整卷）（裁切至18英寸）	TUBING (52.00 Inches Bulk) (Cut to 18 Inches)	1
14	892972T04	线圈线束总成	HARNESS ASSEMBLY Coil	1
14	892972T05	线圈线束总成	HARNESS ASSEMBLY Coil	1
15	879962	卡扣	CLIP	1
16	81893435	螺钉(M8×35)	SCREW (M8 x 35)	4
16	8M0103814	螺钉 (M8 x 35 毫米)	SCREW (M8 x 35 MM)	4
17	4002318	垫圈 8.90 x 24.0x 2.4 不锈钢	WASHER 8.90 x 24.0x 2.4 PL SS	4
18	881866	接头	FITTING	1
19	875207	三通接头	TEE Fitting	1
20	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	2
21	65292	J型卡扣	J CLIP	1
21	8M0024808	J型夹	J-CLIP	1
22	843220001	火花塞	SPARK PLUG	6
22	843220Q	NGK IZFR6J @4	NGK IZFR6J @4	6
23	85978571	管材(52英寸整卷)(裁切5英寸)	TUBING (52.00 Inches Bulk) (Cut to 5 Inches)	1
24	85944975	管材（72英寸整料，需裁至52英寸）	TUBING (72.00 Inches Bulk) (Cut to 52 Inches)	1

图 6曲轴、活塞及连杆 Crankshaft, Pistons and Connecting Rods

REF	零件编号	中文名称	英文名称	数量
1	842753A02	曲轴总成	CRANKSHAFT ASSEMBLY	1
2	NSS	磨损套筒(不单独销售)	NOT SOLD SEPARATE Wear Sleeve	1
3	67923T	滚珠轴承(下)	BEARING Ball (Lower)	1
4	67446	环	RING	1
5	843198T01	密封环	RING Seal	7
6	91800	半圆键	KEY Woodruff	1
7	35126	O型圈(.859 x .139)	O-RING (.859 x .139)	1
8	88270A02	轴承/座圈套件	BEARING/RACE KIT	2
9	88269T	轴承总成	BEARING ASSEMBLY	2
10	843199T13	活塞总成	PISTON ASSEMBLY	3
10	843200T13	活塞总成	PISTON ASSEMBLY	3
10	842986T03	活塞总成	PISTON ASSEMBLY	3
11	841202	环	RING	12
12	858772A02	活塞环组	RING SET Piston	1
13	879148T74	连杆总成	CONNECTING ROD ASSEMBLY	6
14	94320	螺钉(.375-24 x 1.250)	SCREW (.375-24 x 1.250)	12
15	844338A01	轴承总成	BEARING ASSEMBLY	6
15	8M0235070	轴承保持架	CAGE BEARING	6
16	88263	止推垫片	THRUST WASHER	12
17	88258001	滚针轴承	BEARING Needle	204
17	8M0204715	滚针@102	NEEDLES-BRG @102	204
18	816773A2		BEARING ASSEMBLY (Upper)	1
19	859093	密封件	SEAL	1
20	823683	O型圈(1.989 x .070)	O-RING (1.989 x .070)	1
-	832933A05	动力头衬垫套件	GASKET SET Powerhead	1
-	841220A03	动力头衬垫套件	GASKET SET Powerhead	1
-	843034A07	动力头总成	POWERHEAD ASSEMBLY	1

图 7气缸体与端盖 Cylinder Block and End Cap

REF	零件编号	中文名称	英文名称	数量
1	899162A06	气缸体总成	CYLINDER BLOCK ASSEMBLY	1
2	81893440	螺钉 (M8 x 40)	SCREW (M8 x 40)	4
3	8569662	支架	BRACKET	2
3	8M0111325	盖板	COVER	2
4	903509	螺柱（M10×1.5×64）	STUD (M10 x 1.5 x 64)	4
5	8154431	螺柱（M10×1.5×155）	STUD (M10 x 1.5 x 155)	6
6	63779	定位销 (.250 x .625)	PIN Dowel (.250 x .625)	4
7	8781051	止回阀	CHECK VALVE	1
8	67296	销	PIN	3
8	8M0036405	销	PIN	3
9	43044	定位销-无孔(.375 x .625)	PIN Dowel - Without Hole (.375 x .625)	1
10	8245021	连接器	CONNECTOR	1
11	81893435	螺钉(M8×35)	SCREW (M8 x 35)	14
11	8M0103814	螺钉 (M8 x 35 毫米)	SCREW (M8 x 35 MM)	14
12	82446180	螺钉(M10×80)	SCREW (M10 x 80)	8
13	8248577	导流板	DEFLECTOR	6
14	82494810	螺丝 (M6 x 10)	SCREW (M6 x 10)	1
15	856774	垫圈(0.406×0.750×0.105)不锈钢	WASHER (.406 x .750 x .105) Stainless Steel	10
15	8M0214963	垫圈	WASHER	10
16	4013610	螺母(M10不锈钢)	NUT (M10) Stainless Steel	10
17	8283582	传感器	SENSOR	1
17	8M0082988	曲轴位置传感器	SENSOR Crankshaft Position	1
18	40011107	不锈钢螺钉(M5x16)	SCREW (M5 x 16) Stainless Steel	2
19	9787A4	端盖总成	END CAP ASSEMBLY	1
20	62700	O型圈(3.237 x .103)	O-RING (3.237 x .103)	1
21	8308981	密封件	SEAL	2
22	82130020	螺钉 (M6 x 20)	SCREW (M6 x 20)	4
23	82130012	螺钉（M6 x 12）	SCREW (M6 x 12)	1
24	421581	衬套	BUSHING	1
25	8215832	特殊销（1.5英寸）	PIN Special (1.5 Inches)	1
26	841021A06	气缸盖总成(右舷)	CYLINDER HEAD ASSEMBLY Starboard	1
26	841020A06	气缸盖总成(左舷)	CYLINDER HEAD ASSEMBLY Port	1
27	818574	密封件	SEAL	2
28	884391	密封件	SEAL	6
29	891570050	螺钉(M8 x 50)	SCREW (M8 x 50)	40
29	8M0045380	螺钉(M8 x 50)	SCREW (M8 x 50)	40
30	885599004	节温器 54°C/130°F	THERMOSTAT 54 Degree C/130 Degree F	2
30	8M0057307	节温器 54°C/130°F	THERMOSTAT 54 Degree C/130 Degree F	2
31	8503181	衬垫	GASKET	2
32	887601	节温器盖	COVER Thermostat	1
32	887601002	左舷盖	COVER Port	1
32	887602	节温器盖	COVER Thermostat	1
32	887602002	右舷盖	COVER Starboard	1
33	82130025	螺钉(M6x25)	SCREW (M6 x 25)	4
34	328022	黄铜管塞 (.125-27)	PLUG Pipe (.125-27) Brass	1
35	885342002	传感器总成	SENSOR ASSEMBLY	2
35	8M0148668	传感器总成	SENSOR ASSEMBLY	2
36	896699	O型圈（1.78毫米 x 0.08毫米）	O-RING (1.78 mm x .08 mm)	2
37	857186A1	隔板总成	PLATE ASSEMBLY	1
37	857186T02	隔板总成	PLATE ASSEMBLY	1
38	855729	支架	MOUNT	3
39	82130145	螺丝(M10 x 45)	SCREW (M10 x 45)	3
40	19565002	护孔环	GROMMET	1
41	855725	垫圈	WASHER	6
42	65292	J型卡扣	J CLIP	1
42	8M0024808	J型夹	J-CLIP	1
43	858424	卡箍	CLAMP	1
44	29245	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	1
44	8M0204649	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	1
45	82130016	螺钉(M6 x 16)	SCREW (M6 x 16)	2
46	858951	J型卡扣	J CLIP	1
-	843034A07	动力头总成	POWERHEAD ASSEMBLY	1
-	832933A05	动力头衬垫套件	GASKET SET Powerhead	1
-	841220A03	动力头衬垫套件	GASKET SET Powerhead	1

图 8驱动轴壳体与排气管 Drivehshaft Housing and Exhaust Tube

REF	零件编号	中文名称	英文名称	数量
1	832937A05	驱动轴壳体总成	HOUSING ASSEMBLY Driveshaft	1
1	832938A5	驱动轴壳体总成	HOUSING ASSEMBLY Driveshaft	1
1	832938A06	传动轴壳体总成-超长/特超长型	HOUSING ASSEMBLY Driveshaft - X/XX-Long	1
2	856983	双头螺柱(M12 x 52)	STUD (M12 x 52)	4
2	8M0008031	双头螺柱(M12 x 1.75 x 52)	STUD (M12 x 1.75 x 52)	4
3	892860	螺钉(M12 x 35)	SCREW (M12 x 35)	1
4	8331231	护孔环	GROMMET	1
5	856982	垫圈(0.5×0.81×0.09英寸)不锈钢	WASHER (.500 x .810 x .090) Stainless Steel	5
6	896895	螺母(M12)	NUT (M12)	4
7	64649	堵头	PLUG	1
8	898834	螺栓（M14×178）	BOLT (M14 x 178)	2
9	88238A10	接地线总成	CABLE ASSEMBLY Ground	2
10	815432	垫圈(.562 x 2.00 x .125)	WASHER (.562 x 2.00 x .125)	2
11	8154331	垫圈（1.25×2.00×0.19）	WASHER (1.25 x 2.00 x .19)	2
12	8137711	支架	MOUNT	2
13	825190	垫圈	WASHER	2
14	896602	螺母(M14)	NUT (M14)	2
15	8186442	卡箍	CLAMP	2
15	879150A90	下支架盖套件	COVER KIT Lower Mount	2
16	8M0033179	螺钉 (M8 x 40)	SCREW (M8 x 40)	4
16	8M0084475	螺钉 (M8 x 40)	SCREW (M8 x 40)	4
17	72521	内齿锁紧垫圈	LOCKWASHER Internal Tooth	1
18	8M0001136	下支架盖	COVER Lower Mount	2
18	879150A90	下支架盖套件	COVER KIT Lower Mount	2
19	69079	螺钉 (#10-16 x .440)	SCREW (#10-16 x .440)	2
20	8329321	密封件	SEAL	1
21	833116A19	排气管总成	TUBE ASSEMBLY Exhaust	1
22	8524052	滤网	STRAINER	1
22	8M0026113	滤网	STRAINER	1
23	81893435	螺钉(M8×35)	SCREW (M8 x 35)	6
23	8M0103814	螺钉 (M8 x 35 毫米)	SCREW (M8 x 35 MM)	6
24	8329417	水管	TUBE Water	1
24	8M0042785	水管	TUBE-WATER	1
24	8329418	水管	TUBE Water	1
24	8M0042786	水管	TUBE Water	1
25	832940001	密封件	SEAL	1
26	8329391	卡箍	CLAMP	1
27	41508	螺钉(0.250-20×0.500)不锈钢	SCREW (.250-20 x .500) Stainless Steel	1
28	81893435	螺钉(M8×35)	SCREW (M8 x 35)	2
28	8M0103814	螺钉 (M8 x 35 毫米)	SCREW (M8 x 35 MM)	2
29	847541	垫圈	WASHER	4

图 9电气板组件 Electrical Plate Components

REF	零件编号	中文名称	英文名称	数量
-	NSS	不单独销售-电气板总成(完整)	NOT SOLD SEPARATE Electrical Plate Assembly-Complete	1
1	899071T01	安装板	PLATE	1
2	899145	绑带夹	CLIP Tie Strap	2
3	82129114	螺钉 (M6 x 14)	SCREW (M6 x 14)	2
4	29245	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	3
4	8M0204649	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	3
5	882751A1	继电器总成	RELAY ASSEMBLY	3
5	8M0207773	调整继电器总成	RELAY ASSEMBLY Trim	3
6	828102	支架	BRACKET	3
6	8M0207771	安装支架	BRACKET Mounting	3
7	818967	护孔环	GROMMET	3
7	8M0207785	护孔环	GROMMET	3
8	818968	衬套	BUSHING	3
8	8M0214955	衬套	BUSHING	3
9	82129125	螺丝(M6 x 25毫米)	SCREW (M6 x 25 mm)	7
10	892971T05	发动机线束总成	HARNESS ASSEMBLY Engine	1
-	83296920	迷你保险丝-黄色-20安	FUSE Mini - Yellow - 20 Ampere	3
-	832969T20	迷你保险丝-黄色-20安	FUSE Mini - Yellow - 20 Ampere	3
-	8329692	迷你保险丝-灰色-2安培	FUSE Mini - Gray - 2 Ampere	1
-	8M0207797	迷你保险丝-灰色-2安培	FUSE Mini - Gray - 2 Ampere	1
-	8329695	迷你保险丝-棕色-5安培	FUSE Mini - Tan - 5 Ampere	1
-	832969T05	迷你保险丝-棕色-5安培	FUSE Mini - Tan - 5 Ampere	1
-	858781A2	直喷器线束总成	HARNESS ASSEMBLY Direct Injector	1
-	879346A49	线束维修套件	HARNESS REPAIR KIT	1
-	858780A2	喷油器线束总成	HARNESS ASSEMBLY Fuel Injector	1
-	879346A50	线束维修套件	HARNESS REPAIR KIT	1
-	881262A2	交流发电机线束总成	HARNESS ASSEMBLY Alternator	1
-	878073A2	节气门位置传感器线束总成	HARNESS ASSEMBLY Throttle Position Sensor	1
-	879346A41	线束维修套件	HARNESS REPAIR KIT	1
11	875302A1	带电螺柱总成	HOT STUD ASSEMBLY	1
12	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	AR
13	85172	垫圈	WASHER	1
14	93388T21	线缆总成(黑色)	CABLE ASSEMBLY Black	1
15	93388A17	线缆总成(8.50英寸)	CABLE ASSEMBLY (8.50 Inches)	1
16	878231A6	保险丝线束总成-100安培	HARNESS ASSEMBLY Fuse - 100 Ampere	1
17	53166	锁紧垫圈 (.312)	LOCKWASHER (.312)	3
18	400213	不锈钢螺母 (M8)	NUT (M8) Stainless Steel	1
19	88439A46	电缆总成 蓄电池-正极	CABLE ASSEMBLY Battery - Positive	1
20	817109A2	电磁阀总成(#10-32/.3125-18端子)	SOLENOID ASSEMBLY (#10-32 / .3125-18 Terminals)	1
21	822179	护孔环	GROMMET	2
22	818968	衬套	BUSHING	2
22	8M0214955	衬套	BUSHING	2
23	88807A16	黑色电缆总成(4.00英寸)	CABLE ASSEMBLY (4.00 Inches) Black	1
24	45076	黄铜螺母(#10-32)	NUT (#10-32) Brass	2
25	813938	盖形螺母(#10-32)	CAP NUT (#10-32)	2
26	68292	螺母(.312-18)	NUT (.312-18)	2
26	8M0204668	螺母(.312-18)	NUT (.312-18)	2
27	819514T26	升降线束总成	HARNESS ASSEMBLY Trim	1

图 10排气板 Exhaust Plate

REF	零件编号	中文名称	英文名称	数量
1	832935A17	排气板总成	PLATE ASSEMBLY Exhaust	1
2	832933006	衬垫	GASKET	1
3	832934006	衬垫(下部)	GASKET (Lower)	1
4	8238051	密封件	SEAL	1
4	8M0043157	密封件	SEAL	1
-	832076A1	接头总成 冲洗	FITTING ASSEMBLY Flush	1
5	8320761	止回阀接头	FITTING Check Valve	1
6	30641	O型圈(0.299x0.103)	O-RING (.299 x .103)	1
7	8219631	止回阀	CHECK VALVE	1
8	817519A1	排水单向阀总成	CHECK VALVE ASSEMBLY Drain	2
9	43044	定位销-无孔(.375 x .625)	PIN Dowel - Without Hole (.375 x .625)	4
10	887603	接头	FITTING	1
11	65663A2	盖总成 (含参考号#18)	COVER ASSEMBLY (Includes Reference #18)	1
11	8M0237835	罩盖总成	COVER ASSY	1
12	81893435	螺钉(M8×35)	SCREW (M8 x 35)	2
12	8M0103814	螺钉 (M8 x 35 毫米)	SCREW (M8 x 35 MM)	2
13	814190	托架	CARRIER	1
14	814191	护孔环	GROMMET	1
15	814189	提动阀	POPPET	1
16	64878	弹簧(黑色)	SPRING (Black)	1
17	65664A1	隔板总成	PLATE ASSEMBLY	1
18	88907003	衬垫	GASKET	2
19	648771	隔膜	DIAPHRAGM	1
20	76451	垫圈	WASHER	1
21	69570	螺钉(#10-16 x .750)	SCREW (#10-16 x .750)	1
22	43585	联轴器	COUPLING	1
23	822002	护孔环	GROMMET	1
24	94848	接头	FITTING	1
25	81893435	螺钉(M8×35)	SCREW (M8 x 35)	6
25	8M0103814	螺钉 (M8 x 35 毫米)	SCREW (M8 x 35 MM)	6
26	850306A04	怠速排气护套套件	BOOT KIT Idle Exhaust	1
27	888910	安装板	PLATE	1
28	82239312	螺钉(M5 x 12)	SCREW (M5 x 12)	2
29	821908	堵头	PLUG	1
30	821915	垫圈	WASHER	1
31	859626A1	冲洗软管套件(进口)	FLUSH HOSE KIT (Inlet)	1
32	8596001	接头	FITTING	1
33	850896	卡箍 (28.6)	CLAMP (28.6)	2
34	821904	示流器接头	FITTING Tell-Tale	1
34	8M0077650	示流器接头	FITTING Tell-Tale	1
35	8348084	滤网	STRAINER	1
36	48237	衬套	BUSHING	1
37	12602002	护孔环	GROMMET	1
-	832933A05	动力头衬垫套件	GASKET SET Powerhead	1
-	841220A03	动力头衬垫套件	GASKET SET Powerhead	1

图 11飞轮/交流发电机 Flywheel/Alternator

REF	零件编号	中文名称	英文名称	数量
1	881247A1	交流发电机	ALTERNATOR
2	8523742	弹簧	SPRING	1
3	400636	螺母	NUT	1
4	856815T2	张紧臂总成	ARM TENSIONER ASSEMBLY	1
5	4002320	垫圈	WASHER	1
6	8M0034457	螺柱(M10×85)	STUD (M10 x 85)	1
6	8M0063255	双头螺栓M10x92	STUD M10x92	1
7	8568941	衬套	BUSHING	1
8	852385A2	皮带轮总成	PULLEY ASSEMBLY	1
8	8M6005030	皮带轮总成	PULLEY ASSY	1
9	4010835	螺钉(M10×35)六角法兰-不锈钢	SCREW (M10 x 35) Hex Flange - Stainless Steel	1
10	828507Q5	皮带	BELT	1
11	859619T1	飞轮	FLYWHEEL	1
12	42979	螺母(M16)	NUT (M16)	1
13	68229	垫圈(.641 x 1.250 x .190)	WASHER (.641 x 1.250 x .190)	1
13	33001	垫圈	WASHER	1
14	47533	垫圈 节温器	WASHER Thermostat	1
15	401386	螺母(M6)不锈钢	NUT (M6) Stainless Steel	1
16	856583A5	线缆总成 至缸体	CABLE ASSEMBLY To Block	1
17	4002319	垫圈	WASHER	1
18	82130150	螺丝(M10 x 50)	SCREW (M10 x 50)	2
19	45907	黄色塞	PLUG Yellow	1

图 12燃油泵 Fuel Pump

REF	零件编号	中文名称	英文名称	数量
-	14360T74	燃油泵总成	PUMP ASSEMBLY Fuel	1
1	NSS	不单独销售 燃油泵	NOT SOLD SEPARATE Fuel Pump	1
2	857005A1	膜片组件	DIAPHRAGM KIT	1
3	NSS	膜片(不单独销售)	NOT SOLD SEPARATE Diaphragm	1
4	NSS	固定座(不单独销售)	NOT SOLD SEPARATE Retainer	2
5	NSS	弹簧(不单独销售)	NOT SOLD SEPARATE Spring	1
6	NSS	盖帽(不单独销售)	NOT SOLD SEPARATE Cap	1
7	NSS	弹簧(不单独销售)	NOT SOLD SEPARATE Spring	1
8	NSS	盖帽(不单独销售)	NOT SOLD SEPARATE Cap	1
9	NSS	膜片(不单独销售)	NOT SOLD SEPARATE Diaphragm	1
10	NSS	增压垫片(不单独销售)	NOT SOLD SEPARATE Gasket-Boost	1
11	NSS	脉冲垫片(不单独销售)	NOT SOLD SEPARATE Gasket-Pulse	1
12	987691	衬垫	GASKET	1
12	8M0204705	衬垫@2	GASKET @2	1
13	805063	O型圈(.301 x .070)	O-RING (.301 x .070)	1
13	8M0204683	O型圈(.070×.301内径)	O-Ring (.070 x .301 ID)	1
14	987752	安装板	PLATE	1
15	996642	90度弯头接头(0.125-27x0.250)尼龙	FITTING Elbow 90 Degree (.125-27 x .250) Nylon	1
16	82104540		SCREW (M5 x 40) Fuel Pump	2
17	82130050	螺钉(M6×50)泵至曲轴箱	SCREW (M6 x 50) Pump to Crankcase	2
18	144303	底座	BASE	1
19	782792	45度弯头接头(1.25)	FITTING Elbow 45 Degree (1.25)	1
19	8M0207781	弯头	ELBOW	1
20	888493	弯头	ELBOW	1
21	822769	连接器	CONNECTOR	1
22	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	2
23	856822A2	软管套管总成(18.00英寸)	HOSE AND SLEEVE ASSEMBLY (18.00 Inches)	1
23	8M0043979	软管套管总成	HOSE AND SLEEVE ASSEMBLY	1
-	832933A05	动力头衬垫套件	GASKET SET Powerhead	1
-	841220A03	动力头衬垫套件	GASKET SET Powerhead	1

图 13燃油系统 Fuel System

REF	零件编号	中文名称	英文名称	数量
-	884433T15	燃油导轨总成(完整)	FUEL RAIL ASSEMBLY Complete	1
1	NSS	燃油轨（左舷）不单独销售	NOT SOLD SEPARATE Fuel Rail (Port)	1
2	NSS	燃油轨（右舷）不单独销售	NOT SOLD SEPARATE Fuel Rail (Starboard)	1
3	804830	卡箍	CLAMP	4
4	804525001	螺丝包(2件)(M5x10)	SCREW PACKAGE (2 Per)(M5 x 10)	11
4	8M0041100	螺钉 (M5 x 10)	SCREW (M5 x 10)	11
5	883542	阀门总成(0.375英寸直径)	VALVE ASSEMBLY (.375 Inch Diameter)	2
5	8M0047053	施拉德阀维修包	VALVE KIT Shrader	2
6	804840	O型圈套件	O-RING KIT	1
7	805515	施拉德阀帽-黄铜	CAP Shrader Valve - Brass	2
7	8M0046566	阀帽	CAP Valve	2
8	804835	堵头	PLUG	1
9	880816	卡箍	CLAMP	1
9	8M0041097	支架	BRACKET	1
10	8048311	卡箍	CLAMP	4
11	804528	喷油器	INJECTOR	6
11	8M0222157	燃油喷射器	FUEL INJECTOR	6
12	804530	O型圈套件(含6件)	O-RING KIT Contains 6 pcs	1
13	804529	O型圈套件(含6件)	O-RING KIT Contains 6 pcs	1
14	804522	卡箍	CLAMP	2
15	804532	O型圈套件 (16件/套)	O-RING KIT (16 per Kit	1
16	804832	卡箍	CLAMP	2
17	804526	螺丝包(M5x16)(2件)	SCREW PACKAGE (M5 x 16) (2 Per)	4
18	804535001	盖板	COVER	1
19	804534001	弹簧	SPRING	1
20	804533	膜片总成	DIAPHRAGM ASSEMBLY	1
21	804536	O型圈	O-RING	1
22	804836	接头	FITTING	1
23	804827	软管	HOSE	1
23	8M6001364	软管总成	HOSE ASSEMBLY	1
24	889310	燃油供给软管	HOSE Fuel Supply	1
24	8M6001362	软管总成	HOSE ASSEMBLY	1
25	889311	燃油旁通软管	HOSE Fuel By Pass	1
25	8M6001363	软管总成	HOSE ASSEMBLY	1
NS	804840	O型圈套件	O-RING KIT	1
26	888852	燃油导向器密封件	SEAL Fuel Director	1
27	884595A01	空气喷射器总成	INJECTOR ASSEMBLY Air	6
27	8M6001744	空气喷射器总成	INJECTOR ASM-AIR	6
28	804875	密封套件	SEAL KIT	1
29	859404002	喷射垫片	WASHER Injection	6
30	828791	卡扣	CLIP	4
31	858778	双头螺栓(M10x91)	STUD (M10 x 91)	4
31	8M0063255	双头螺栓M10x92	STUD M10x92	4
32	826292	螺母(M10)黄铜/镀镍	NUT (M10) Brass/Nickel Plated	4
33	856880	软管卡箍（15.3）	CLAMP Hose (15.3)	1
33	8M0214964	卡箍	CLAMP	1
34	856822A2	软管套管总成(18.00英寸)	HOSE AND SLEEVE ASSEMBLY (18.00 Inches)	1
34	8M0043979	软管套管总成	HOSE AND SLEEVE ASSEMBLY	1
35	822769	连接器	CONNECTOR	1
36	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	2
37	899145	绑带夹	CLIP Tie Strap	4
-	8M6002988	膜片维修包	DIAPHRAM KIT	2
-	8M6002989	燃油调节器维修包(15PSI)	FUEL REGULATOR KIT 15 PSI	1
-	8M6002990	燃油调节器维修包(10PSI)	FUEL REGULATOR KIT 10 PSI	1
-	8M6002991	空气调节器套件	AIR REGULATOR KIT	1

图 14齿轮箱(驱动轴-TorqueMaster型) Gear Housing (Driveshaft - TorqueMaster)

REF	零件编号	中文名称	英文名称	数量
-	842739T08	齿轮箱总成 完整 (长型)(1.75:1)	GEAR HOUSING ASSEMBLY Complete (Long)(1.75:1)	1
-	842739T12	齿轮箱总成 完整 (长型)(1.75:1)	GEAR HOUSING ASSEMBLY Complete (Long)(1.75:1)	1
-	842739T13	齿轮箱总成(完整)(长型)(1.75:1)(黑色)	GEAR HOUSING ASSEMBLY Complete (Long)(1.75:1)(Black)	1
-	842739T06	齿轮箱总成 完整 (加长型)(1.75:1)	GEAR HOUSING ASSEMBLY Complete (X-Long)(1.75:1)	1
-	842739T15	齿轮箱总成(完整)(加长型)(1.75:1)(黑色)	GEAR HOUSING ASSEMBLY Complete (XLong)(1.75:1)(Black)	1
-	842739T14	齿轮箱总成 完整 (加长型)(1.75:1)	GEAR HOUSING ASSEMBLY Complete (X-Long)(1.75:1)	1
-	842739T15	齿轮箱总成(完整)(加长型)(1.75:1)(黑色)	GEAR HOUSING ASSEMBLY Complete (XLong)(1.75:1)(Black)	1
1	842739T03	基础齿轮箱总成	GEAR HOUSING ASSEMBLY Basic	1
1	842739T16	齿轮箱总成(基础)(黑色)	GEAR HOUSING ASSEMBLY Basic (Black)	1
1	842739T16	齿轮箱总成(基础)(黑色)	GEAR HOUSING ASSEMBLY Basic (Black)	1
1	8M0072954	齿轮箱总成 基础型 (银色)	GEAR HOUSING ASSEMBLY Basic (Silver)	1
2	379721	销	PIN	1
3	821526001	填充块	FILLER BLOCK	1
4	826134Q	阳极块	ANODE	2
5	4000333	螺钉(M6 x 40)	SCREW (M6 x 40)	1
6	401386	螺母(M6)不锈钢	NUT (M6) Stainless Steel	1
7	42647A1	滚柱轴承总成	BEARING ASSEMBLY Roller	1
8	43044	定位销-无孔(.375 x .625)	PIN Dowel - Without Hole (.375 x .625)	2
9	79953Q04	放油螺钉套件	SCREW KIT Drain	1
10	830749	密封件	SEAL	1
10	8M0204693	放油螺塞密封件	SEAL Drain Plug	1
11	859402	皮托管	PITOT TUBE	1
12	8164641	油封	SEAL Oil	1
12	8M0246145	油封	OIL SEAL	1
13	881866	接头	FITTING	1
14	858934	盖板	COVER	1
15	858935	衬垫	GASKET	1
16	36318	O型圈(0.799英寸)	O-RING (.799)	1
16	8M0214927	O型圈@5	O RING @5	1
16	896522	O型圈(799×.103)	O-RING (799 x .103)	1
17	82130016	螺钉(M6 x 16)	SCREW (M6 x 16)	2
17	1993716	螺钉(M6 x 16)	SCREW (M6 x 16)	2
18	82130016	螺钉(M6 x 16)	SCREW (M6 x 16)	4
18	1993716	螺钉(M6 x 16)	SCREW (M6 x 16)	4
19	NSS	小齿轮(不单独销售)	NOT SOLD SEPARATE Pinion Gear	1
20	92721	垫圈(.965×0.630)	WASHER (.965 x .630)	1
21	35921	螺母(0.625-18)	NUT (.625-18)	1
22	77674	垫圈(.35 x .75 x .12)	WASHER (.35 x .75 x .12)	1
23	824145	换档轴	SHIFT SHAFT	1
24	43037	键	KEY	1
24	8M0204723	键	KEY	1
25	881938	驱动轴	DRIVESHAFT	1
25	881942	驱动轴	DRIVESHAFT	1
26	38657A1	垫片组	SHIM ASSEMBLY	AR
26	8M0063268	垫片组	SHIM SET	AR
27	48939A2	圆锥滚子轴承	BEARING Taper Roller	1
27	8M0146553	杯/锥轴承总成	BEARING ASSEMBLY Cup/Cone	1
28	NSS	杯状件(不单独销售)	NOT SOLD SEPARATE Cup	1
29	42637A1	垫片组	SHIM SET	AR
29	8M0063267	垫片组	SHIM SET	AR
30	36387A1	轴承总成(滚子/外圈)	BEARING ASSEMBLY Roller/Cup	1
30	8M0146566	杯/锥轴承总成	BEARING ASSEMBLY Cup/Cone	1
31	NSS	杯状件(不单独销售)	NOT SOLD SEPARATE Cup	1
32	8245191	固定座	RETAINER	1
33	840836A2	托架总成	CARRIER ASSEMBLY	1
33	8M0192207	密封载体套件	CARRIER KIT-SEAL	1
34	90011	O型圈(2.175 x 0.175)	O-RING (2.175 x .175)	1
34	8M0142854	O型圈(2.175 x 0.103)	O-RING (2.175 x .103)	1
35	66302	油封	SEAL Oil	1
35	8M0214939	油封@3	SEAL @3	1
36	66302	油封	SEAL Oil	1
36	8M0214939	油封@3	SEAL @3	1
37	82130016	螺钉(M6 x 16)	SCREW (M6 x 16)	2
37	1993716	螺钉(M6 x 16)	SCREW (M6 x 16)	2
38	817275A1	水泵壳体套件	HOUSING KIT Water Pump	1
39	816575A2	密封套件	SEAL KIT	1
40	430331	衬垫	GASKET	1
41	8172771	水泵上垫片	GASKET Water Pump, Upper	1
42	8172761	面板	FACEPLATE	1
42	8M0204709	面板	FACEPLATE	1
43	43026T2	叶轮	IMPELLER	1
44	832942A1	联轴器总成	COUPLING ASSEMBLY	1
45	21836	O型圈(.796 x .139)	O-RING (.796 x .139)	1
45	8M0204645	O型圈(.796 x .139)	O-RING (.796 x .139)	1
46	35027	O型圈(1.046英寸)	O-RING (1.046)	1
46	8M0204654	O型圈	O-RING	1
-	816575A6	齿轮箱密封套件	SEAL KIT Gear Housing	1

图 15齿轮箱螺旋桨轴-TorqueMaster型 Gear Housing Propeller Shaft - TorqueMaster

REF	零件编号	中文名称	英文名称	数量
-	842739T08	齿轮箱总成 完整 (长型)(1.75:1)	GEAR HOUSING ASSEMBLY Complete (Long)(1.75:1)	1
-	842739T12	齿轮箱总成 完整 (长型)(1.75:1)	GEAR HOUSING ASSEMBLY Complete (Long)(1.75:1)	1
-	842739T13	齿轮箱总成(完整)(长型)(1.75:1)(黑色)	GEAR HOUSING ASSEMBLY Complete (Long)(1.75:1)(Black)	1
-	842739T06	齿轮箱总成 完整 (加长型)(1.75:1)	GEAR HOUSING ASSEMBLY Complete (X-Long)(1.75:1)	1
-	842739T15	齿轮箱总成(完整)(加长型)(1.75:1)(黑色)	GEAR HOUSING ASSEMBLY Complete (XLong)(1.75:1)(Black)	1
-	842739T14	齿轮箱总成 完整 (加长型)(1.75:1)	GEAR HOUSING ASSEMBLY Complete (X-Long)(1.75:1)	1
-	842739T15	齿轮箱总成(完整)(加长型)(1.75:1)(黑色)	GEAR HOUSING ASSEMBLY Complete (XLong)(1.75:1)(Black)	1
1	842739T03	基础齿轮箱总成	GEAR HOUSING ASSEMBLY Basic	1
1	842739T16	齿轮箱总成(基础)(黑色)	GEAR HOUSING ASSEMBLY Basic (Black)	1
1	842739T16	齿轮箱总成(基础)(黑色)	GEAR HOUSING ASSEMBLY Basic (Black)	1
1	8M0072954	齿轮箱总成 基础型 (银色)	GEAR HOUSING ASSEMBLY Basic (Silver)	1
2	859403	堵头	PLUG	1
3	823903	换挡曲柄	SHIFT CRANK	1
3	8M0226861	换挡曲柄	CRANK-SHIFTER	1
4	19755T7	阀芯总成	SPOOL ASSEMBLY	1
4	8M0235940	阀芯总成	SPOOL ASSY	1
5	NSS	不单独销售线轴	NOT SOLD SEPARATE Spool	1
6	NSS	不单独销售套筒	NOT SOLD SEPARATE Sleeve	1
7	NSS	不单独销售开口销	NOT SOLD SEPARATE Cotter Pin	1
8	47397A1	垫片组	SHIM SET	AR
9	859321T04	前进/小齿轮组	GEAR SET Forward/Pinion	1
10	828437A2	轴承总成	BEARING ASSEMBLY	1
11	NSS	杯状件(不单独销售)	NOT SOLD SEPARATE Cup	1
12	30895T	滚针轴承	BEARING Needle	1
13	856823	挡圈	RING Retaining	1
14	848878T	离合器	CLUTCH	1
15	78909	定位销	PIN Detent	2
16	848838	十字销	PIN Cross	1
17	78962	弹簧	SPRING	2
18	841978	螺旋桨轴	PROPELLER SHAFT	1
19	848881A1	倒挡齿轮	GEAR Reverse	1
19	8M0192235	倒挡齿轮	GEAR-REVERSE	1
20	8241081	推力垫片	THRUST SPACER	1
21	88957T	滚珠轴承	BEARING Ball	1
22	681001	止推环	RING Thrust	1
23	31534	O型圈	O-RING	1
23	8M0214920	O型圈	O RING	1
23	896524	O型圈(3.850×.210)	O-RING (3.850 x .210)	1
23	8M0142840	O型圈(3.85×0.210)	O-RING (3.85 x 0.210)	1
24	848840T1	轴承座总成	CARRIER ASSEMBLY Bearing	1
24	848840A1	轴承座总成	CARRIER ASSEMBLY Bearing	1
25	817072	滚柱轴承	BEARING Roller	1
26	817071	卡环	RING Snap	1
27	815565	油封	SEAL Oil	2
28	30281	键	KEY	1
29	67892A06	磁性放油塞套件	PLUG KIT Drain - Magnetic	1
29	8M0058389	放油螺钉套件	SCREW KIT Drain	1
29	79953Q04	放油螺钉套件	SCREW KIT Drain	1
30	830749	密封件	SEAL	1
30	8M0204693	放油螺塞密封件	SEAL Drain Plug	1
31	79447	锁紧垫圈	TAB WASHER	1
32	79448	固定座	RETAINER	1
32	8M2011027	固定座	RETAINER	1
33	762145	阳极块	ANODE	1
33	76214Q5	阳极套件	ANODE KIT	1
34	66024	螺钉(.437-14 x 1.75)	SCREW (.437-14 x 1.75)	1
-	816575A6	齿轮箱密封套件	SEAL KIT Gear Housing	1

图 16润滑系统 Oiling System

REF	零件编号	中文名称	英文名称	数量
1	85606065	管材(38英寸散装)(截断至11.5英寸)	TUBING (38.00 Inches Bulk) (Cut to 11.50 Inches)	2
2	85606065	管材(38英寸整卷)(裁切至5英寸)	TUBING (38.00 Inches Bulk) (Cut to 5 Inches)	1
2	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	1
3	18206001	燃油滤清器	FILTER Fuel	2
3	8M0207786	滤清器	FILTER	2
4	85606065	管材(38英寸整卷)(裁切至9英寸)	TUBING (38.00 Inches Bulk) (Cut to 9 Inches)	1
4	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	1
5	884525T1	机油箱	TANK Oil	1
5	8M0064075	机油箱	TANK Oil	1
6	NSS	不单独销售标签-储液罐	NOT SOLD SEPARATE Decal-Reservoir	1
7	855362001	护孔环	GROMMET	3
8	855364	衬套	BUSHING	2
9	883050	隔套	SPACER	1
10	58376	螺钉(.164-18 x .375)	SCREW (.164-18 x .375)	1
11	72761	不锈钢垫圈(.203 x .562 x .060)	WASHER (.203 x .562 x .060) Stainless Steel	1
12	856156A4	开关	SWITCH	1
12	856156T04	开关	SWITCH	1
13	885553	软管	HOSE	1
14	424254	接头	FITTING	1
14	8M0207780	接头	FITTING	1
15	887609	堵头	PLUG	1
16	4002318	垫圈 8.90 x 24.0x 2.4 不锈钢	WASHER 8.90 x 24.0x 2.4 PL SS	3
17	81893435	螺钉(M8×35)	SCREW (M8 x 35)	2
17	8M0103814	螺钉 (M8 x 35 毫米)	SCREW (M8 x 35 MM)	2
18	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	AR
19	8752891	软管	HOSE	1
20	858955	连接器	CONNECTOR	2
21	875283	软管(2.00英寸)	HOSE (2.00 Inches)	1
22	875284001	滤清器-机油在线式	FILTER Oil - In Line	1
22	875284T01	滤清器-机油在线式	FILTER Oil - In Line	1
23	NSS	不单独销售 塞	NOT SOLD SEPARATE Plug	2
24	892830053	软管(24英寸编织)(截断至22英寸)	HOSE (24.00 Inches Braided) (Cut to 22 Inches)	1
25	81893460	螺钉 (M8 x 60)	SCREW (M8 x 60)	1
26	858870	止回阀	CHECK VALVE	6
27	859230T	固定座	RETAINER	2
28	85583466	软管 (40.00英寸整卷) (裁至34英寸)	HOSE (40.00 Inches Bulk) (Cut to 34 Inches)	1
28	8M0054213	软管	HOSE	1
29	85606065	管材 (38.00英寸整卷) (裁至19.50英寸)	TUBING (38.00 Inches Bulk) (Cut to 19.50 Inches)	1
29	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	1
30	56762	扎带(4.00英寸)	TIE STRAP (4.00 Inches)	AR
31	85606065	管材(38英寸整卷)(裁切至11英寸)	TUBING (38.00 Inches Bulk) (Cut to 11 Inches)	1
31	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	1
32	85606065	管材 (38.00英寸整卷) (裁至6英寸)	TUBING (38.00 Inches Bulk) (Cut to 6 Inches)	1
32	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	1
33	85606065	管材 (38.00英寸整卷) (裁至4英寸)	TUBING (38.00 Inches Bulk) (Cut to 4 Inches)	1
33	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	1
34	883988	弯头	ELBOW	2
35	85606065	管材(38英寸整卷)(裁切至22英寸)	TUBING (38.00 Inches Bulk) (Cut to 22 Inches)	1
35	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	1
36	85606065	管材(38英寸散装)(截断至16.5英寸)	TUBING (38.00 Inches Bulk) (Cut to 16.50 Inches)	1
36	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	1
37	85606065	管材(38英寸散装)(截断至7英寸)	TUBING (38.00 Inches Bulk) (Cut to 7 Inches)	2
37	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	2

图 17PCM 安装 PCM Mounting

REF	零件编号	中文名称	英文名称	数量
1	89790609T	推进控制模块PCM	PCM Propulsion Control Module	1
2	82130025	螺钉(M6x25)	SCREW (M6 x 25)	3
3	65567	不锈钢垫圈(0.265x0.750x0.048)	WASHER (.265 x .750 x .048) Stainless Steel	3
4	834985	护孔环	GROMMET	3
4	8M0190980	护孔环	GROMMET	3
5	856954	衬套	BUSHING	3
6	891520001	卡扣	CLIP	1
7	82129114	螺钉 (M6 x 14)	SCREW (M6 x 14)	1
8	82130012	螺钉（M6 x 12）	SCREW (M6 x 12)	4
9	13541	公插头	PLUG Male	1
10	88439A26	蓄电池负极电缆总成	CABLE ASSEMBLY Battery - Negative	1
11	81893420	螺钉(M8 x 20)	SCREW (M8 x 20)	1
12	830796A04	防水插头总成-4针公头	CONNECTOR ASSEMBLY Weather Cap - 4 Position Male	1
13	877613A02	防水插头总成6针	CONNECTOR ASSEMBLY Weather Cap 6 Pin	1
14	881176A1	盖总成 3位公连接器	CAP ASSEMBLY 3 Position-Male Connector	1
15	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	AR

图 18左舷中央主润滑系统 Port Center Main Oiling System

REF	零件编号	中文名称	英文名称	数量
1	887801	弯头配件90度(.0625-27)	FITTING Elbow 90 Degree (.0625-27)	3
2	887801	弯头配件90度(.0625-27)	FITTING Elbow 90 Degree (.0625-27)	2
3	85606065	管材(38英寸散装)(截断至20.5英寸)	TUBING (38.00 Inches Bulk) (Cut to 20.50 Inches)	1
3	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	1
4	85606065	管材(38英寸整卷)(裁切至5英寸)	TUBING (38.00 Inches Bulk) (Cut to 5 Inches)	1
4	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	1
5	8592352	止回阀90度(.0625-27)	CHECK VALVE 90 Degree (.0625-27)	3
6	85606065	管材(38英寸整卷)(裁切至13英寸)	TUBING (38.00 Inches Bulk) (Cut to 13 Inches)	1
6	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	1
7	8282182	止回阀	CHECK VALVE	1
8	8582362	止回阀	CHECK VALVE	2
9	23567	卡扣	CLIP	1
10	878608	螺钉(#10-16 x 0.500)	SCREW (#10-16 x .500)	1
11	85606065	管材(38英寸整卷)(裁切至11英寸)	TUBING (38.00 Inches Bulk) (Cut to 11 Inches)	1
11	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	1
12	85606065	管材(38英寸散装)(截断至9.5英寸)	TUBING (38.00 Inches Bulk) (Cut to 9.50 Inches)	1
12	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	1
-	843034A07	动力头总成	POWERHEAD ASSEMBLY	1

图 19动力头衬垫组件 Powerhead Gasket Set Components

REF	零件编号	中文名称	英文名称	数量
-	832933A05	动力头衬垫套件	GASKET SET Powerhead	1
-	857005A1	燃油泵膜片维修包	DIAPHRAGM KIT Fuel Pump	1
-	NSS	膜片(不单独销售)	NOT SOLD SEPARATE Diaphragm	2
-	NSS	固定座(不单独销售)	NOT SOLD SEPARATE Retainer	2
-	NSS	弹簧(不单独销售)	NOT SOLD SEPARATE Spring	1
-	NSS	盖帽(不单独销售)	NOT SOLD SEPARATE Cap	1
-	NSS	增压弹簧(不单独销售)	NOT SOLD SEPARATE Spring-Boost	1
-	NSS	不单独销售 端盖-弹簧	NOT SOLD SEPARATE Cap-Spring End	1
-	NSS	增压垫片(不单独销售)	NOT SOLD SEPARATE Gasket-Boost	1
-	NSS	脉冲垫片(不单独销售)	NOT SOLD SEPARATE Gasket-Pulse	1
-	987691	燃油泵衬垫	GASKET Fuel Pump	1
-	8M0204705	衬垫@2	GASKET @2	1
-	841220	衬垫（空气处理器适配板）	GASKET Air Handler Adaptor Plate	1
-	62700	O型圈(3.237x0.103)下端盖	O-RING (3.237 x .103) Lower End Cap	1
-	818574	密封件（气缸盖）	SEAL Cylinder Head	2
-	8503181	节温器盖衬垫	GASKET Thermostat Cover	2
-	35126	O型圈(.859 x .139)曲轴-下部	O-RING (.859 x .139) Crankshaft-Lower	1
-	823683	O型圈（1.989×0.070）（曲轴上端）	O-RING (1.989 x .070) Crankshaft-Upper	1
-	8329335	衬垫 排气板-上部	GASKET Exhaust Plate-Upper	1
-	832933006	衬垫	GASKET	1
-	8329344	衬垫 排气板-下部	GASKET Exhaust Plate-Lower	1
-	832934006	衬垫	GASKET	1
-	88907003	安全阀盖与板衬垫	GASKET Relief Valve Cover and Plate	2

图 20动力升降组件 8M0231193 Power Trim Components 8M0231193

REF	零件编号	中文名称	英文名称	数量
-	8M0231193	动力升降总成	POWER TRIM ASSEMBLY	1
1	8M0225363	电机套件	MOTOR KIT	1
2	8M0225369	阀套件	VALVE KIT	1
3	8M0225371	手动释放套件	MANUAL RELEASE KIT	1
4	8M0245633	倾斜油缸套件	TILT CYLINDER KIT	1
5	8M0225370	枢轴销套件	PIVOT PIN KIT	1
6	8M0244575	减震杆套件	SHOCK ROD KIT	1
7	8M0244425	销杆眼套件	PIN ROD EYE KIT	1
8	8M0232231	螺钉螺母套件	SCREW NUT KIT	1
9	8M0225373	记忆活塞套件	MEMORY PISTON KIT	1
10	8M0225368	储液罐套件	RESERVOIR KIT	1
11	8M0174135	储液罐塞总成	PLUG RESERVOIR ASSEMBLY	1
12	8M0237525	泵套件	PUMP KIT	1
13	8M0225367	升降杆套件	TRIM ROD KIT	1
14	8M0242846	升降杆套件	TRIM ROD KIT	1
15	8M0225372	重建套件	REBUILD KIT	1

图 21动力升降组件金属马达壳 Power Trim Components Metal Motor Housing

REF	零件编号	中文名称	英文名称	数量
-	855998A05	完整动力升降总成	POWER TRIM ASSEMBLY Complete	1
1	878265A4	配平电机	TRIM MOTOR	1
1	8M0031551	配平电机	TRIM MOTOR	1
2	NSS	电枢(不单独销售)	NOT SOLD SEPARATE Armature	1
3	NSS	端架(不单独销售)	NOT SOLD SEPARATE End Frame	1
-	878285	O型圈	O-RING	1
4	82494830	螺钉 (M6 x 30)	SCREW (M6 x 30)	2
5	400256	锁紧垫圈 (M6)	LOCKWASHER (M6)	2
6	8782451	驱动轴	DRIVESHAFT	1
7	878410A1	压力检查套件	PO CHECK KIT	1
8	813442A2	手动释放总成 (含参考号#26)	MANUAL RELEASE ASSEMBLY (Includes Reference #26)	1
8	893929A01	安全阀套件	VALVE KIT Relief	1
9	878241A02	轴套件	SHAFT KIT	1
9	8M0142997	倾斜轴套件	TILT SHAFT KIT	1
10	878267	销	PIN	1
11	878235A02	倾斜油缸总成	TILT CYLINDER ASSEMBLY	1
11	878235A03	倾斜油缸套件	CYLINDER KIT Tilt	1
12	878239A1	导向套件 (含参考号#26)	GUIDE KIT (Includes Reference #26)	1
12	878239A02	倾斜缸端盖套件	END CAP KIT Tilt Cylinder	1
13	878409A1	O型圈套件 (含参考号#26)	O-RING KIT (Includes Reference #26)	1
13	8M0142999	倾斜油缸O型圈套件	O RING KIT TILT CYLINDER	1
14	878412A1	减震杆套件 (含参考号#26)	SHOCK ROD KIT (Includes Reference #26)	1
14	8M0168219	减震杆套件	SHOCK ROD KIT	1
15	878242A1	记忆活塞总成	PISTON ASSEMBLY Memory	1
15	8M0143000	记忆活塞套件	MEMORY PISTON KIT	1
16	878406A1	止回阀修理包 (含参考号#26)	REPAIR KIT Check Valve (Includes Reference #26)	1
16	878406A02	止回阀修理包	REPAIR KIT Check Valve	1
17	878414A1	活塞总成	PISTON ASSEMBLY	1
17	878414T01	活塞总成	PISTON ASSEMBLY	1
18	878413A1	活塞总成	PISTON ASSEMBLY	1
19	878243A1	导向器总成	GUIDE ASSEMBLY	2
19	8M0021648	端盖总成	END CAP ASSEMBLY	2
20	878264A1	储液罐套件	RESERVOIR KIT	1
21	811613	塞子总成	PLUG ASSEMBLY	1
22	4000327	螺钉 (M6 x 14)	SCREW (M6 x 14)	4
23	43450	垫圈	WASHER	4
23	4002315	垫圈(6.60x12.5x1.5mm-不锈钢)	WASHER (6.60 X 12.5 X 1.5 mm -SS)	4
24	892251A01	泵套件	PUMP KIT	1
25	878408A1	动力升降倾斜装置维修包	REPAIR KIT Power Trim	1
26	821539	三叶销	PIN Trilobe	1
27	858771	螺钉 (M10 x 30)	SCREW (M10 x 30)	6
28	4002319	垫圈	WASHER	6
29	818298Q1	阳极套件	ANODE KIT	1
30	4000330	螺钉(M6x25)	SCREW (M6 x 25)	2
30	8M0204707	不锈钢六角大帽螺钉(M6x25)	SCREW M6 x 25 HX HD CAP SS	2
31	29245	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	2
31	8M0204649	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	2
32	99625002	轴	SHAFT	1
33	69205	C形垫圈	C WASHER	1
33	8M0084613	C形垫圈	C-WASHER	1
34	26550	卡箍	CLAMP	2
35	878609	螺钉 (#10-16 x .600)	SCREW (#10-16 x .600)	1
36	828547353	导管(内径0.350x3英尺散装)(裁切至12英寸)	CONDUIT (.350 Inside Diameter x 3.00 Feet Bulk) (Cut to 12 Inches)	1
37	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	1

图 22动力升降组件（塑料马达壳体） Power Trim Components Plastic Motor Housing

REF	零件编号	中文名称	英文名称	数量
-	8M0168222	动力升降总成	POWER TRIM ASSEMBLY	1
1	8M0142591	电机套件	MOTOR KIT	1
2	82494830	螺钉 (M6 x 30)	SCREW (M6 x 30)	2
3	400256	锁紧垫圈 (M6)	LOCKWASHER (M6)	2
4	8M0090403	驱动联轴器	COUPLING Drive	1
5	8M0142996	压力检查套件	PO CHECK KIT	1
6	8M0060141	手动释放套件	MANUAL RELEASE KIT	1
7	8M0142997	倾斜轴套件	TILT SHAFT KIT	1
8	878267	销	PIN	1
9	8M0142998	倾斜油缸总成	TILT CYLINDER ASSEMBLY	1
9	8M0168220	倾斜油缸总成	TILT CYLINDER ASSEMBLY	1
10	8M0142999	倾斜油缸O型圈套件	O RING KIT TILT CYLINDER	1
11	8M0143000	记忆活塞套件	MEMORY PISTON KIT	1
12	8M0142592	升降杆套件 左舷	TRIM ROD KIT Port	1
13	8M0143001	活塞总成	PISTON ASSEMBLY	1
14	8M0143003	端盖总成	END CAP ASSEMBLY	1
15	878264A1	储液罐套件	RESERVOIR KIT	1
16	811613	塞子总成	PLUG ASSEMBLY	1
17	4000327	螺钉 (M6 x 14)	SCREW (M6 x 14)	4
18	4002315	垫圈(6.60x12.5x1.5mm-不锈钢)	WASHER (6.60 X 12.5 X 1.5 mm -SS)	4
19	8M0143004	泵套件	PUMP KIT	1
20	8M0148385	动力升降倾斜装置维修包	REPAIR KIT Power Trim	1
21	858771	螺钉 (M10 x 30)	SCREW (M10 x 30)	6
22	4002319	垫圈	WASHER	6
23	8M0094889	销	PIN	1
23	8M0161312	连杆销眼总成	PIN ROD EYE ASSEMBLY	1
24	8M0143005	减震杆套件	SHOCK ROD KIT	1
24	8M0168219	减震杆套件	SHOCK ROD KIT	1

图 23维修/支撑材料 Service/Support Material

REF	零件编号	中文名称	英文名称	数量
-	896328006	零件手册 225 PRO XS (3.0L) DFI	PARTS MANUAL 225 PRO XS (3.0L) DFI	1
-	841916R01	维修手册	SERVICE MANUAL	1
-	841915060	用户手册	OWNERS MANUAL	1
-	841914060	安装手册	INSTALLATION MANUAL	1
-	842795A01	装配示意图	DIAGRAM ASSEMBLY	1
-	842800	顶盖与套筒	TOC and SLEEVE	1
-	842795	线路图03	DIAGRAM 03 Wiring	1
-	842796	线路图04	DIAGRAM 04 Wiring	1
-	842797	罐体示意图	DIAGRAM Can	1
-	842804	燃油系统图03	DIAGRAM 03 Fuel	1
-	842798	燃油系统图04	DIAGRAM 04 Fuel	1
-	842799	水流示意图	DIAGRAM Water Flow	1
-	889246A38	EPA标签信息贴花	DECAL EPA Label Information	1
-	898246A07	EPA标签信息贴花	DECAL EPA Label Information	1
-	898246A08	EPA标签信息贴花	DECAL EPA Label Information	1

图 24右舷中央主润滑系统 Starboard Center Main Oiling System

REF	零件编号	中文名称	英文名称	数量
1	85606065	管材(38英寸散装)(截断至15.5英寸)	TUBING (38.00 Inches Bulk) (Cut to 15.50 Inches)	1
2	8592352	止回阀90度(.0625-27)	CHECK VALVE 90 Degree (.0625-27)	3
3	85606065	管材(38英寸散装)(截断至16.5英寸)	TUBING (38.00 Inches Bulk) (Cut to 16.50 Inches)	1
3	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	1
4	85606065	管材(38英寸整卷)(裁切至15英寸)	TUBING (38.00 Inches Bulk) (Cut to 15 Inches)	1
4	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	1
5	23567	卡扣	CLIP	1
6	878608	螺钉(#10-16 x 0.500)	SCREW (#10-16 x .500)	1
7	887801	弯头配件90度(.0625-27)	FITTING Elbow 90 Degree (.0625-27)	3
-	843034A07	动力头总成	POWERHEAD ASSEMBLY	1

图 25启动电机 Starter Motor

REF	零件编号	中文名称	英文名称	数量
1	892339T01	启动电机总成	STARTER MOTOR ASSEMBLY	1
2	NSS	贯穿螺栓(不单独销售)	NOT SOLD SEPARATE Thru Bolt	2
3	880805A1	齿轮套件	GEAR KIT	1
4	809463A1	电磁阀组件	SOLENOID KIT	1
5	8M0065258	电刷组	BRUSH SET	1
6	69035	螺丝与锁紧垫圈(.250-20 x .625)不锈钢	SCREW AND LOCKWASHER (.250-20 x .625) Stainless Steel	1
7	93388A1	电缆总成(6.00英寸)黑色	CABLE ASSEMBLY (6.00 Inches) Black	1
8	8272822	警告标贴	DECAL Warning	1
9	400255	锁紧垫圈(M5)	LOCKWASHER (M5)	1
10	400211	不锈钢螺母(M5)	NUT (M5) Stainless Steel	1
11	26993	锁紧垫圈 (.312)	LOCKWASHER (.312)	1
11	8M0204647	锁紧垫圈 (.312)	LOCKWASHER (.312)	1
12	400213	不锈钢螺母 (M8)	NUT (M8) Stainless Steel	1
13	8M0034918	轴环	COLLAR	1
14	879845	停机开关	STOP	1
14	8M0043276	停机开关	STOP	1

图 26旋转支架与转向臂 Swivel Bracket and Steering Arm

REF	零件编号	中文名称	英文名称	数量
1	8710T20	黑色旋转支架总成	SWIVEL BRACKET ASSEMBLY Black	1
2	33504	O型圈	O-RING	1
2	8M0214926	O型圈 @10	O RING @10	1
3	818764	衬套	BUSHING	2
4	816039	隔套	SPACER	1
5	87735		SEAL Oil (Lower)	1
6	74036	润滑脂接头	FITTING Grease	2
6	8M0169589	润滑脂接头	FITTING Grease	2
7	821207	衬套	BUSHING	2
8	816432	止推垫片	THRUST WASHER	1
9	826364T	下轭架	YOKE Bottom	1
10	67684	挡圈	RING Retaining	1
11	996301	冲击板	STRIKER PLATE	2
11	8M0045383	冲击板	STRIKER PLATE	2
12	58643	锁紧垫圈 (.375)	LOCKWASHER (.375)	2
13	46335	螺母 (.375-24)	NUT (.375-24)	2
14	64014	螺钉(.250-28x.500)	SCREW (.250-28 x .500)	2
15	NSS	不单独销售-序列号覆膜标贴	NOT SOLD SEPARATE Decal-Serial Overlaminate	1
16	821180A6	调整传感器总成	SENDER ASSEMBLY Trim	1
16	8M0074846	ORDER 8M0098273	ORDER 8M0098273	1
17	852368	螺钉（#10-24 X 0.750）	SCREW (#10-24 x .750)	2
18	26996	锁紧垫圈(#10)(不锈钢)	LOCKWASHER (#10) Stainless Steel	2
19	89302	垫圈(0.203×0.406×0.040)	WASHER (.203 x .406 x .040)	2
20	826432A2	转向臂旋转销总成-不锈钢	SWIVEL PIN ASSEMBLY Steering Arm - Stainless Steel	1
20	8M0132731	旋转销总成	SWIVEL PIN ASSY	1
21	8M0000517	螺钉(M12×190)	SCREW (M12 x 190)	2
21	8M0141069	螺钉	SCREW	2
22	824998001	缓冲垫	BUMPER	1
23	8163851	上部支架	MOUNT Upper	2
24	8154371	垫圈	WASHER	2
25	815436	垫圈	WASHER	2
26	896963	螺母(M12)	NUT (M12)	2
27	813769	卡箍	CLAMP	1
27	8M0036783	卡箍	CLAMP	1
28	81893435	螺钉(M8×35)	SCREW (M8 x 35)	3
28	8M0103814	螺钉 (M8 x 35 毫米)	SCREW (M8 x 35 MM)	3
30	92876A12	连杆总成	LINK ROD ASSEMBLY	1
31	849838	螺钉(.375-24 x 1.250)	SCREW (.375-24 x 1.250)	1
32	826709113	不锈钢螺母 (.375-24)	NUT (.375-24) Stainless Steel	2
32	8M0204726	黄铜螺母 (.375-24)	NUT (.375-24) Brass	2
33	37828	不锈钢垫圈 (.390 x .625 x .062)	WASHER (.390 x .625 x .062) Stainless Steel	2

图 27节气门联动装置 Throttle Linkage

REF	零件编号	中文名称	英文名称	数量
1	8252682	杠杆	LEVER	1
2	81893460	螺钉 (M8 x 60)	SCREW (M8 x 60)	1
3	887605	衬套	BUSHING	1
4	821113	衬套	BUSHING	1
5	40124	螺钉 (M6 x 55)	SCREW (M6 x 55)	2
6	400212	螺母(M6)不锈钢	NUT (M6) Stainless Steel	2
7	42942	盖帽	CAP	2
8	42927	嵌件	INSERT	1
9	401386	螺母(M6)不锈钢	NUT (M6) Stainless Steel	1
10	932481	衬套	BUSHING	1
10	8M0215006	旋转衬套	BUSHING Swivel	1
11	884834	连接杆	LINK	1
12	8240102	锚支架	BRACKET Anchor	1
12	824010T05	支架	BRACKET	1
13	824016	闩锁	LATCH	1
14	42975	传动螺钉	DRIVE SCREW	2
15	824015	筒形保持杯	CUP Barrel Retainer	2
16	82155025	螺丝(M8 x 25 mm)不锈钢	SCREW (M8 x 25 mm) Stainless Steel	2
17	43430	垫圈	WASHER	1
18	82155025	螺丝(M8 x 25 mm)不锈钢	SCREW (M8 x 25 mm) Stainless Steel	1
19	896662	滑动支架	BRACKET Slide	1
19	8M0039052	滑动支架	BRACKET Slide	1
20	889514A01	开关	SWITCH	1
20	8M0207794	开关	SWITCH	1
21	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	1
22	82470620	螺钉 (M3.5 x 20)	SCREW (M3.5 x 20)	2
23	35459	垫圈	WASHER	2
24	883142A03	换挡连杆套件	SHIFT LINK KIT	1
25	8539683	滑块	SLIDE	1
26	401386	螺母(M6)不锈钢	NUT (M6) Stainless Steel	2
27	42994	衬套	BUSHING	1
28	896669001	上换挡轴	SHIFT SHAFT Upper	1
28	8M0036408	换挡轴	SHAFT-SHIFT	1
28	896669002	上换挡轴	SHIFT SHAFT Upper	1
28	8M0187153	XL型上换挡轴	SHAFT SHIFT UP XL	1
29	40011113	不锈钢螺丝(M5x45)	SCREW (M5 x 45) Stainless Steel	3
30	8582261	盖板	COVER	1
31	8M0008111	连接杆	LINK	1
32	883081	杠杆	LEVER	1
33	83295211	油门位置指示器	INDICATOR Throttle Position	1
33	8M6005165	TPI	TPI	1
34	82130025	螺钉(M6x25)	SCREW (M6 x 25)	3
35	65567	不锈钢垫圈(0.265x0.750x0.048)	WASHER (.265 x .750 x .048) Stainless Steel	3
36	834985	护孔环	GROMMET	3
36	8M0190980	护孔环	GROMMET	3
37	856954	衬套	BUSHING	3
38	8544862	支架	BRACKET	1
39	858932	卡扣	CLIP	1
40	858353A09	凸轮总成	CAM ASSEMBLY	1
40	858353T10	凸轮总成	CAM ASSEMBLY	1
41	8235694	螺纹球头	BALL Threaded	1
42	932481	衬套	BUSHING	1
42	8M0215006	旋转衬套	BUSHING Swivel	1
43	40011155	不锈钢螺钉(M8x55)	SCREW (M8 x 55) Stainless Steel	1
44	8807371	衬套	BUSHING	1
45	56720	垫圈(0.330×0.750×0.060)不锈钢	WASHER (.330 x .750 x .060) Stainless Steel	1
46	475451	卡扣	CLIP	1

图 28顶罩 Top Cowl

REF	零件编号	中文名称	英文名称	数量
1	881288T58	顶盖总成	TOP COWL ASSEMBLY	1
1	881288T66	顶罩总成(黑色)	TOP COWL ASSEMBLY (Black)	1
1	8M0063392	ORD 100-8M0075372	ORD 100-8M0075372	1
2	82130030	螺钉 (M6 x 30)	SCREW (M6 x 30)	4
3	884041A1	隔音毯套装	SOUND BLANKET KIT	1
3	884041A04	隔音毯套装	SOUND BLANKET KIT	1
4	NSS	不单独出售-顶部隔音垫	NOT SOLD SEPARATE Sound Blanket-Top	1
5	NSS	不单独销售 隔音垫-左舷	NOT SOLD SEPARATE Sound Blanket-Port	1
6	93702	垫圈(.250外齿星形)	WASHER (.250 External Star)	6
7	826639T	盖板	COVER	1
8	850682T4	后锁钩总成	HOOK ASSEMBLY Rear Latch	2
8	850682A06	支架和手柄套件	BRACKET AND HANDLE KIT	2
8	8M0010389	罩壳支架总成	BRACKET ASSEMBLY Cowl	2
9	NSS		NOT SOLD SEPARATE Pin	2
10	8237951	挡圈	RING Retaining	2
11	815263	滚轮	ROLLER	2
11	8M0207770	滚轮@3	ROLLER @3	2
12	850685002	护孔环	GROMMET	1
12	850685T02	护孔环	GROMMET	1
13	821249M2	前支架	BRACKET Front	1
13	8M0036792	支架	BRACKET	1
14	82130020	螺钉 (M6 x 20)	SCREW (M6 x 20)	2
15	815477	缓冲器锁扣	BUMPER Latch	1
16	8155381	滚动销	PIN Roll	1
17	401366	螺母(M6)不锈钢	NUT (M6) Stainless Steel	1
18	29245	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	1
18	8M0204649	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	1
19	8237951	挡圈	RING Retaining	1
20	815263	滚轮	ROLLER	1
20	8M0207770	滚轮@3	ROLLER @3	1
21	87161	垫圈	WASHER	1
-	897136A07	贴花套装 ProXS(不含马力贴花)	DECAL SET ProXS, HP decal not included	1
-	892564006	225马力标识贴	DECAL Horsepower 225	1
-	8M0061186	贴花	DECAL	1

图 29艉板支架 Transom Brackets

REF	零件编号	中文名称	英文名称	数量
1	828334T03	艉板支架总成-右舷	BRACKET ASSEMBLY Transom-Starboard	1
2	828333T08	艉板支架总成-左舷	BRACKET ASSEMBLY Transom-Port	1
3	98727	润滑脂接头	FITTING Grease	1
3	8M0169588	润滑脂接头	FITTING Grease	1
4	826125A1	倾斜管	TILT TUBE	1
5	826135	尼龙锁紧螺母(1.00-14)	NUT Lock (1.00-14) Nylon Insert	1
6	45711	O型圈 (.612 x .103)	O-RING (.612 x .103)	1
7	88750	波浪垫圈 (1.62 x 1.05)	WASHER Wave (1.62 x 1.05)	2
8	826164	螺母 (.875-14)	NUT (.875-14)	1
8	8M0231351	锁紧螺母	NUT Lock	1
9	677551	螺钉(.500-20×4.500)	SCREW (.500-20 x 4.500)	4
9	8M0149747	螺钉	SCREW	4
10	54012	垫圈(0.530×0.870×0.105不锈钢)	WASHER (.530 x .870 x .105) Stainless Steel	4
10	8M0204665	垫圈(0.530×0.880×0.104 630不锈钢)	WASHER (.530 x .880 x .104) 630 Stainless Steel	4
11	28421	垫圈(1.5x3.05x0.13)不锈钢	WASHER (1.5 x 3.05 x 0.13) Stainless Steel	4
11	8M0204648	垫圈(1.5x3.05x0.13)不锈钢	WASHER (1.5 x 3.05 x 0.13) Stainless Steel	4
12	82671117	螺母(.500-20)	NUT (.500-20)	4
13	99629T2	倾斜锁定杆总成	LEVER ASSEMBLY Tilt Lock	1
13	8M0115104	倾斜锁定杆总成	LEVER ASSEMBLY Tilt Lock	1
14	830899	张力弹簧	SPRING Tension	1
15	65830	尼龙衬套	NYLINER	2
16	830900	压缩弹簧	SPRING Compression	1
17	99633	旋钮	KNOB	1
18	99615	槽销	PIN Groove	1
19	99617	销	PIN	1
19	893709	销	PIN	1
20	96930A1	螺栓总成	BOLT ASSEMBLY	1
21	23161	螺母 (.375-24)	NUT (.375-24)	1