水星 Mercury 200 HP XS 6 CYL (2.5L) ROS 1E050852 THRU 1E053876 - 爆炸图零件明细

两冲程 直喷 DFI OptiMax · Cat.# 90-8M0055491 · 共 33 个部位 · 1133 条零件

图 1空气压缩机组件 SN 1B884880及以下 Air Compressor Components SN 1B884880 and below

REF	零件编号	中文名称	英文名称	数量
1	8M0050656	空气压缩机套件	COMPRESSOR KIT Air	1
1	8M0060053	空气压缩机总成	COMPRESSOR ASSEMBLY Air	1
2	NSS	不单独销售本体	NOT SOLD SEPARATE Body	1
3	8M0050792	端盖总成	END CAP ASSEMBLY	1
4	NSS	非单独销售挡圈	NOT SOLD SEPARATE Retaining Ring	1
5	67206001	O型圈	O-RING	1
6	67206001	O型圈	O-RING	1
7	85593920	螺钉 (M6 x 20)	SCREW (M6 x 20)	4
8	833146T06	连杆总成	CONNECTING ROD ASSEMBLY	1
9	NSS	轴承（不单独销售）	NOT SOLD SEPARATE Bearing	1
10	NSS	轴承（不单独销售）	NOT SOLD SEPARATE Bearing	1
11	NSS	不单独销售 活塞组件(含环和销)	NOT SOLD SEPARATE Piston assembly (W/Rings and Pin)	1
12	NSS	刮油环（不单独销售）	NOT SOLD SEPARATE Oil Scraper Ring	1
13	NSS	顶环（不单独销售）	NOT SOLD SEPARATE Top Ring	1
14	NSS	油环（不单独销售）	NOT SOLD SEPARATE Oil Ring	1
15	NSS	活塞销（不单独销售）	NOT SOLD SEPARATE Wrist Pin	1
16	NSS	带活塞销的活塞（不单独销售）	NOT SOLD SEPARATE Piston with Wrist Pin	1
17	8348101	锁紧环	RING Lock Lock	2
18	835088A10	簧片阀板总成	REED PLATE ASSEMBLY	1
19	67207	O型圈（3.489 x 0.070）	O-RING (3.489 x .070)	2
20	832804	O型圈（2.739 x 0.070）	O-RING (2.739 x .070)	1
21	828225	密封件	SEAL	1
22	835087A04	压缩机缸盖套件	HEAD KIT Compressor	1
22	8M0073890	压缩机缸盖套件	HEAD KIT Compressor	1
23	8307535	直通接头	FITTING Straight	1
23	8M0042974	接头（1.87英寸）	FITTING (1.87 Inches)	1
24	82127335	螺钉 (M8 x 35 毫米)	SCREW (M8 x 35 MM)	4
25	13536A14	温度传感器总成	SENSOR ASSEMBLY Temperature	1
26	137151	固定座	RETAINER	1
27	81893414	螺钉（M8 x 14）	SCREW (M8 x 14)	1
28	831985	O型圈（0.468 x 0.078）	O-RING (.468 x .078)	1
29	151331	接头	FITTING	1
30	428641	止回阀接头	FITTING Check Valve	2
31	856744	接头	FITTING	1
32	14868	接头	FITTING	1
33	NSS	贴纸-装配说明（不单独销售）	NOT SOLD SEPARATE Decal-Assy. Instructions	1
34	85593920	螺钉 (M6 x 20)	SCREW (M6 x 20)	6
35	855349002	护孔环	GROMMET	1
36	851975	弯头接头-45度-黄铜（0.125-27）	FITTING Elbow - 45 Degree - Brass (.125-27)	1
37	4010825	螺丝(M10 x 25)六角法兰-不锈钢	SCREW (M10 x 25) Hex Flange - Stainless Steel	2
38	858762001	双头螺柱（0.312-18/0.312-24 x 4.190）	STUD (.312-18/.312-24 x 4.190)	2
39	854640	特殊垫圈	WASHER Special	4
40	46356	螺母(.312-24)	NUT (.312-24)	2
41	8M0051194	压缩机皮带轮	PULLEY Compressor	1
41	8M0138680	滑轮	PULLEY	1
42	8M0024533	卡箍	CLAMP	1
43	884594	垫圈	WASHER	1
-	832804A03	O型圈套件	O-RING KIT	1

图 2空气压缩机组件 SN 1B884881及以上 Air Compressor Components SN 1B884881 and up

REF	零件编号	中文名称	英文名称	数量
1	8M0060053	空气压缩机总成	COMPRESSOR ASSEMBLY Air	1
2	NSS	不单独销售本体	NOT SOLD SEPARATE Body	1
3	8M0060381	端盖总成	END CAP ASSEMBLY	1
4	8M0045380	螺钉(M8 x 50)	SCREW (M8 x 50)	1
5	67206001	O型圈	O-RING	1
6	67206001	O型圈	O-RING	1
7	85593920	螺钉 (M6 x 20)	SCREW (M6 x 20)	4
8	833146T06	连杆总成	CONNECTING ROD ASSEMBLY	1
9	NSS	轴承（不单独销售）	NOT SOLD SEPARATE Bearing	1
10	NSS	轴承（不单独销售）	NOT SOLD SEPARATE Bearing	1
11	NSS	不单独销售 活塞组件(含环和销)	NOT SOLD SEPARATE Piston assembly (W/Rings and Pin)	1
12	NSS	刮油环（不单独销售）	NOT SOLD SEPARATE Oil Scraper Ring	1
13	NSS	顶环（不单独销售）	NOT SOLD SEPARATE Top Ring	1
14	NSS	油环（不单独销售）	NOT SOLD SEPARATE Oil Ring	1
15	NSS	活塞销（不单独销售）	NOT SOLD SEPARATE Wrist Pin	1
16	NSS	带活塞销的活塞（不单独销售）	NOT SOLD SEPARATE Piston with Wrist Pin	1
17	8348101	锁紧环	RING Lock Lock	2
18	835088A10	簧片阀板总成	REED PLATE ASSEMBLY	1
19	67207	O型圈（3.489 x 0.070）	O-RING (3.489 x .070)	2
20	832804	O型圈（2.739 x 0.070）	O-RING (2.739 x .070)	1
21	828225	密封件	SEAL	1
22	8M0073890	压缩机缸盖套件	HEAD KIT Compressor	1
23	8307535	直通接头	FITTING Straight	1
23	8M0042974	接头（1.87英寸）	FITTING (1.87 Inches)	1
24	82127335	螺钉 (M8 x 35 毫米)	SCREW (M8 x 35 MM)	4
25	13536A14	温度传感器总成	SENSOR ASSEMBLY Temperature	1
26	137151	固定座	RETAINER	1
27	81893414	螺钉（M8 x 14）	SCREW (M8 x 14)	1
28	831985	O型圈（0.468 x 0.078）	O-RING (.468 x .078)	1
29	151331	接头	FITTING	1
30	428641	止回阀接头	FITTING Check Valve	2
31	856744	接头	FITTING	1
32	14868	接头	FITTING	1
33	NSS	贴纸-装配说明（不单独销售）	NOT SOLD SEPARATE Decal-Assy. Instructions	1
34	85593920	螺钉 (M6 x 20)	SCREW (M6 x 20)	6
35	855349002	护孔环	GROMMET	1
36	851975	弯头接头-45度-黄铜（0.125-27）	FITTING Elbow - 45 Degree - Brass (.125-27)	1
37	4010825	螺丝(M10 x 25)六角法兰-不锈钢	SCREW (M10 x 25) Hex Flange - Stainless Steel	2
38	858762001	双头螺柱（0.312-18/0.312-24 x 4.190）	STUD (.312-18/.312-24 x 4.190)	2
39	854640	特殊垫圈	WASHER Special	4
40	46356	螺母(.312-24)	NUT (.312-24)	2
41	8M0051194	压缩机皮带轮	PULLEY Compressor	1
41	8M0138680	滑轮	PULLEY	1
42	8M0024533	卡箍	CLAMP	1
43	884594	垫圈	WASHER	1
-	832804A03	O型圈套件	O-RING KIT	1

图 3空气处理器组件 Air Handler Components

REF	零件编号	中文名称	英文名称	数量
-	8M0055651	空气处理器总成	AIR HANDLER ASSEMBLY	1
1	8M0055654	适配板套件	ADAPTER PLATE KIT	1
2	840484	衬垫	GASKET	1
3	840485	衬垫	GASKET	1
4	840805T1	簧片阀总成	REED BLOCK ASSEMBLY	6
5	15133	接头	FITTING	2
6	884522	MAP传感器支架	BRACKET MAP Sensor	1
7	892296	支架	BRACKET	1
8	55715	螺钉(.250-20×0.880)	SCREW (.250-20 x .880)	12
9	857149T05	油泵总成	PUMP ASSEMBLY Oil	1
9	8M0185614	机油泵	OIL PUMP	1
10	855364	衬套	BUSHING	6
11	855362001	护孔环	GROMMET	6
12	81893435	螺钉(M8×35)	SCREW (M8 x 35)	3
12	8M0103814	螺钉 (M8 x 35 毫米)	SCREW (M8 x 35 MM)	3
13	817274	垫圈(0.344×1.00×0.063)不锈钢	WASHER (.344 x 1.00 x .063) Stainless Steel	6
14	850248T03	空气集气室套件	PLENUM KIT Air	1
15	81893430	螺钉 (M8 x 30)	SCREW (M8 x 30)	3
15	81893435	螺钉(M8×35)	SCREW (M8 x 35)	3
16	885342002	传感器总成	SENSOR ASSEMBLY	1
16	8M0148668	传感器总成	SENSOR ASSEMBLY	1
17	896699	O型圈（1.78毫米 x 0.08毫米）	O-RING (1.78 mm x .08 mm)	1
18	883942	螺钉(M4×16)	SCREW (M4 x 16)	2
19	855422A1	节气门体套件	THROTTLE BODY KIT	1
20	855423	O型圈	O-RING	1
21	82130040	螺钉(M6 x 40)	SCREW (M6 x 40)	4
22	1993716	螺钉(M6 x 16)	SCREW (M6 x 16)	1
23	854445	MAP传感器	SENSOR MAP	1
23	8M0237529	MAP传感器	SENSOR MAP	1
24	8M0020312	簧片	REED	12
-	848040A51	动力头总成（部分）	POWERHEAD ASSEMBLY Partial	1

图 4空气处理器/飞轮盖 Air Handler/Flywheel Cover

REF	零件编号	中文名称	英文名称	数量
-	8M0042543	飞轮盖总成	COVER ASSEMBLY Flywheel	1
-	8M0059111	飞轮盖	COVER - FLYWHEEL	1
1	NSS	飞轮盖不单独销售	NOT SOLD SEPARATE FLYWHEEL COVER	1
2	821555001	护孔环	GROMMET	2
2	8M0153609	护孔环	GROMMET	2
3	853333T	滤清器	FILTER	1
4	853352	盖板	COVER	1
5	857101	护孔环	GROMMET	1
6	855613	护孔环	GROMMET	1
7	881865	警示贴纸-挂档启动	DECAL Caution-Start in Gear	1
8	8283582	传感器	SENSOR	1
8	8M0082988	曲轴位置传感器	SENSOR Crankshaft Position	1
9	40011107	不锈钢螺钉(M5x16)	SCREW (M5 x 16) Stainless Steel	2
10	8215832	特殊销（1.5英寸）	PIN Special (1.5 Inches)	1
10	8M0042972	特殊销（1.75英寸）	PIN Special (1.75 Inches)	1
11	883080	J型卡扣	J CLIP	2
12	817504	螺钉（0.250-20 x 1.500）不锈钢	SCREW (.250-20 x 1.500) Stainless Steel	12
13	55098	J型卡扣	J CLIP	1
13	8M0024808	J型夹	J-CLIP	1
-	848040A51	动力头总成（部分）	POWERHEAD ASSEMBLY Partial	1

图 5空气软管 Air Hoses

REF	零件编号	中文名称	英文名称	数量
1	996642	90度弯头接头(0.125-27x0.250)尼龙	FITTING Elbow 90 Degree (.125-27 x .250) Nylon	1
2	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	2
3	8M0047448	管材（0.312英寸）（70英寸卷料/裁切6英寸）	TUBING (.312) (70 Inches Bulk) (Cut to 6 Inches)	1
3	8M0108349	软管 (70英寸散装)	HOSE (70 Inches Bulk)	1
4	856880	软管卡箍（15.3）	CLAMP Hose (15.3)	2
4	8M0214964	卡箍	CLAMP	2
5	8502512	软管	HOSE	1
6	85687631	套管（16.00英寸）	SLEEVE (16.00 Inches)	1
7	804823	软管/接头总成	HOSE/FITTING ASSEMBLY	1
7	8M6000383	软管总成	HOSE ASSEMBLY	1
8	804824	软管/接头总成	HOSE/FITTING ASSEMBLY	1
8	8M6000382	软管总成	HOSE ASSEMBLY	1
9	804532	O型圈套件	O-RING KIT	1
10	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	2
11	881197	空气消声器	MUFFLER Air	1
12	85833939	软管（17英寸卷料/连接底壳）	HOSE (17.00 Inches Bulk) To Bottom Pan	1

图 6下罩 Bottom Cowl

REF	零件编号	中文名称	英文名称	数量
1	849479T08	底壳	BOTTOM PAN	1
2	848810	锁扣支架	BRACKET Latch	1
3	28782	螺钉(.312-18 x .880)不锈钢	SCREW (.312-18 x .880) Stainless Steel	2
4	814806	垫圈 (.344 x .688 x .065) 不锈钢	WASHER (.344 x .688 x .065) Stainless Steel	2
4	8M0204690	垫圈 (.344 x .688 x .065) 不锈钢	WASHER (.344 x .688 x .065) Stainless Steel	2
5	812707	衬套	BUSHING	2
6	848985	密封件	SEAL	1
7	848815T1	手柄	HANDLE	1
8	F2047	波形垫圈	WASHER Wave	1
9	8M0001081	凸轮	CAM	1
10	4002316	垫圈(6.60 X 17.0 X 1.5不锈钢)	WASHER (6.60 X 17.0 X 1.5SS)	1
10	8M0214930	垫圈6.60 x 17.0 x 1.5	WASHER 6.60 x 17.0 x 1.5	1
11	28635	不锈钢螺丝(.250-20 x .620)	SCREW (.250-20 x .620) Stainless Steel	1
12	849830T1	闩锁	LATCH	1
13	849011	螺钉(.250-20 x .750)	SCREW (.250-20 x .750)	2
14	8M0042805	安装板	PLATE	1
15	38601	螺丝(.250-28 x 1.250)	SCREW (.250-28 x 1.250)	14
16	826709109	不锈钢螺母(.250-28)	NUT (.250-28) Stainless Steel	14
17	29245	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	14
17	8M0204649	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	14
18	849750	护孔环	GROMMET	1
19	8177133	护孔环	GROMMET	2
20	690201	螺钉(#10-32 x .875)	SCREW (#10-32 x .875)	2
21	826709106	螺母 (#10-32) 不锈钢	NUT (#10-32) Stainless Steel	2
21	8M0204718	螺母	NUT	2
22	849767	密封件	SEAL	2
22	8M0043399	密封件	SEAL	2
23	8M0043398	罩盖密封件	SEAL Cowl	1
24	849765	密封件	SEAL	1
24	8M0043397	罩盖密封条	SEAL-COWL	1
25	8496191	支撑架	BRACE	2
26	849011	螺钉(.250-20 x .750)	SCREW (.250-20 x .750)	4
27	8267098	螺母 (.250-20) 不锈钢	NUT (.250-20) Stainless Steel	4
28	NSS		NOT SOLD SEPARATE RETAINER	1
29	849831A1	锁手柄总成	LATCH HANDLE ASSEMBLY	1
29	8M0192237	闩锁手柄	LATCH HANDLE	1
30	843118	双头螺柱（0.250-20×3.45）	STUD (.250-20 x 3.45)	2
31	849832	销	PIN	1
32	NSS	标贴(不单独销售)	NOT SOLD SEPARATE Decal	1
33	842776	弹簧（外径0.420英寸）	SPRING (.420 Outside Diameter)	2
34	846673	不锈钢垫圈(.265 x .500 x .060)	WASHER (.265 x .500 x .060) Stainless Steel	2
35	8267098	螺母 (.250-20) 不锈钢	NUT (.250-20) Stainless Steel	2
36	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	1
37	840404	护孔环	GROMMET	2
37	8M0058484	护孔环	GROMMET	2
38	812830T01	微调开关堵头	PLUG Trim Switch	1
39	8M0032848	开关固定座	RETAINER Switch
40	76256	喷嘴	NOZZLE	1

图 7线圈板总成 Coil Plate Assembly

REF	零件编号	中文名称	英文名称	数量
-	NSS	不单独销售 线圈板总成-完整	NOT SOLD SEPARATE Coil Plate Assembly-Complete	1
1	884271	线圈安装板	PLATE Coil Mounting	1
2	8502341	衬套	BUSHING	4
3	833155	护孔环	GROMMET	4
4	82129110	螺丝 (M6 x 10)	SCREW (M6 x 10)	2
5	29245	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	2
5	8M0204649	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	2
6	899145	绑带夹	CLIP Tie Strap	4
7	858414A1	编织电缆总成	CABLE ASSEMBLY Braided	2
8	892910T03	线圈线束总成	HARNESS ASSEMBLY Coil	1
9	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	4
10	883066	夹子 (.865)	CLIP (.865)	2
11	881879010	传感器	SENSOR	1
11	8M0157742	水压传感器	SENSOR Water Pressure	1
12	892403	接头	FITTING	2
12	8M0207782	直通接头	FITTING Straight	2
13	85978571	管材（52英寸卷料/裁切4英寸）	TUBING (52.00 Inches Bulk) (Cut to 4 Inches)	1
14	875207	三通接头	TEE Fitting	1
15	85978571	管材(52英寸整卷)(裁切5英寸)	TUBING (52.00 Inches Bulk) (Cut to 5 Inches)	1
16	881879T11	压力传感器 (0 - 100 PSI)	SENSOR Pressure (0 - 100 PSI)	1
17	82129130	螺钉 (M6 x 30)	SCREW (M6 x 30)	12
18	881908T	电缆组	CABLE SET	1
19	82854735	导管	CONDUIT	1
20	879984T01	点火线圈	COIL Ignition	6
20	8M0077471	点火线圈	IGNITION COIL	6
21	60411	螺钉(.312-18 x 1.250)	SCREW (.312-18 x 1.250)	4
22	8M0042642	垫圈(.323 x .562 x .063)	WASHER (.323 x .562 x .063)	2
23	49436	垫圈	WASHER	4
24	8M0009927	火花塞（NGK-IZFR7M）	SPARK PLUG (NGK-IZFR7M)	6

图 8曲轴、活塞及连杆 Crankshaft, Pistons and Connecting Rods

REF	零件编号	中文名称	英文名称	数量
1	850690T7	曲轴总成	CRANKSHAFT ASSEMBLY	1
2	78662	耐磨套	WEAR SLEEVE	1
3	67923T	滚珠轴承(下)	BEARING Ball (Lower)	1
4	67446	环	RING	1
5	54196A6	托架总成	CARRIER ASSEMBLY	1
6	65800	填料	PACKING	1
7	67377T	密封环	RING Sealing	9
8	16756A6	轴承套件	BEARING KIT	2
9	NSS	轴承座圈不单独销售	NOT SOLD SEPARATE Bearing-Race	2
10	841134T01	活塞总成	PISTON ASSEMBLY	3
10	841135T01	活塞总成	PISTON ASSEMBLY	3
11	840684A12	活塞环套装（每套12环）	RING SET Piston (12 Rings per Set)	1
12	857196	锁紧环	LOCK RING	12
13	8M0081411	连杆总成	CONNECTING ROD ASSEMBLY	6
14	763491	螺钉(.312-24 x .875)	SCREW (.312-24 x .875)	12
15	8M0012298	止推垫片	THRUST WASHER	12
16	8M0082405	轴承套件	BEARING KIT	6
17	822553	滚针轴承	BEARING Needle	174
17	8M0204691	滚针轴承@200	BRG-NEEDLE @200	174

图 9气缸体与端盖 Cylinder Block and End Caps

REF	零件编号	中文名称	英文名称	数量
1	8M8027364	气缸体总成	CYLINDER BLOCK ASSEMBLY	1
2	8M0034455	螺柱1.750	STUD 1.750	6
3	670654	螺柱(.375-16/.375-24 x 5.620)	STUD (.375-16/.375-24 x 5.620)	2
3	8M0034454	螺柱(.375-16/.375-24 x 6.87)	STUD (.375-16/.375-24 x 6.87)	2
4	43044	定位销-无孔(.375 x .625)	PIN Dowel - Without Hole (.375 x .625)	2
5	8M0036405	销(轴承座圈)	PIN (BEARING RACE)	2
6	8M0041759	支架	BRACKET	1
6	8M0111325	盖板	COVER	1
7	828213	螺钉(.312-18 x 1.500)六角法兰	SCREW (.312-18 x 1.500) Hex Flange	2
8	76867	底盖	COVER (Bottom)	1
9	828214	螺钉(.312-18 x 2.00)六角法兰	SCREW (.312-18 x 2.00) Hex Flange	2
10	66717	螺钉(.375-16 x 3.250)	SCREW (.375-16 x 3.250)	8
11	74824	螺钉(.312-18 x 1.250)	SCREW (.312-18 x 1.250)	6
12	26852	尼龙帽	CAP Nylon	1
13	856832	螺丝 (.250-20 x 1.750)	SCREW (.250-20 x 1.750)	1
14	64015	螺母 (.250-20)	NUT (.250-20)	1
15	832760T1	端盖总成	END CAP ASSEMBLY	1
16	54029	O型圈(2.800 x .103)	O-RING (2.800 x .103)	1
17	16756A4	轴承套件	BEARING KIT	1
18	NSS	不单独销售 轴承座圈	NOT SOLD SEPARATE Bearing Race	1
19	41953	密封件	SEAL	1
20	881190	螺丝(.312-18 x 1.00)	SCREW (.312-18 x 1.00)	4
21	8M0050233	端盖总成	END CAP ASSEMBLY	1
22	62700	O型圈(3.237 x .103)	O-RING (3.237 x .103)	1
23	41953	密封件	SEAL	2
24	28636	螺钉(.250-20 x .750)	SCREW (.250-20 x .750)	2
25	26992	锁紧垫圈(.250)不锈钢	LOCKWASHER (.250) Stainless Steel	2
26	8M0046139	平头螺钉（0.250-20×0.75）	SCREW Flat Head (.250-20 x 0.75)	2
27	8519371	节气门位置指示器杠杆	LEVER Throttle Position Indicator	1
28	8538821	节气门位置指示器安装支架	BRACKET Throttle Position Indicator Mount	1
29	856954	衬套	BUSHING	3
30	69035	螺丝与锁紧垫圈(.250-20 x .625)不锈钢	SCREW AND LOCKWASHER (.250-20 x .625) Stainless Steel	1
31	834985	护孔环	GROMMET	3
31	8M0190980	护孔环	GROMMET	3
32	83295211	节气门位置指示器(内侧)	INDICATOR Throttle Position (Inside)	1
32	8M6005165	TPI	TPI	1
33	8582261	TPS盖	COVER TPS	1
34	8508281	螺丝 (#10-32 x 2.00) TPS至支架	SCREW (#10-32 x 2.00) TPS to Bracket	3
35	8M0008117	连杆总成	LINK ASSEMBLY	1
35	8M0084738	连杆总成	LINK ASSY	1
36	88439A26	蓄电池负极电缆总成	CABLE ASSEMBLY Battery - Negative	1
36	88439A46	电缆总成 蓄电池-正极	CABLE ASSEMBLY Battery - Positive	1
37	81893414	螺钉（M8 x 14）	SCREW (M8 x 14)	1
38	93388A1	电缆总成(6.00英寸)黑色	CABLE ASSEMBLY (6.00 Inches) Black	1
39	8M0047428	软管（内径0.25英寸，57英寸卷料/裁切1.5英寸）	HOSE (.25 inch ID, 57.00 Inches Bulk) (Cut to 1-1/2 Inches)	2
39	8M0108355	软管(57英寸 散装)	HOSE (57 Inches Bulk)	2
40	8M0047428	软管（内径0.25英寸，57英寸卷料/裁切1.25英寸）	HOSE (.25 inch ID, 57.00 Inches Bulk) (Cut to 1-1/4 Inches)	2
40	8M0108355	软管(57英寸 散装)	HOSE (57 Inches Bulk)	2

图 10气缸盖 Cylinder Head

REF	零件编号	中文名称	英文名称	数量
1	8M8025141	气缸盖总成	CYLINDER HEAD ASSEMBLY	1
1	8M8025142	气缸盖总成	CYLINDER HEAD ASSEMBLY	1
2	878217	螺丝 (.375-16 x 2.750)	SCREW (.375-16 x 2.750)	24
2	8M0125882	螺钉	SCREW	24
3	63779	定位销 (.250 x .625)	PIN Dowel (.250 x .625)	4
4	62386001	衬垫	GASKET	2
4	8M0204714	衬垫@4	GASKET @4	2
5	8307372	盖板	COVER	2
5	8M0039353	盖板	COVER	2
6	833072003	节温器 62°C (143°F)	THERMOSTAT 62°C (143°F)	2
7	82130025	螺钉(M6x25)	SCREW (M6 x 25)	4
8	885342002	传感器总成	SENSOR ASSEMBLY	2
8	8M0148668	传感器总成	SENSOR ASSEMBLY	2
9	896699	O型圈（1.78毫米 x 0.08毫米）	O-RING (1.78 mm x .08 mm)	2
10	8584521	密封件	SEAL	2
10	8M0149612	气缸盖密封	SEAL CYLINDER HEA	2
11	8597721	密封件	SEAL	6

图 11驱动轴壳体 Driveshaft Housing

REF	零件编号	中文名称	英文名称	数量
1	818900T24	驱动轴壳体（短）	HOUSING Driveshaft (Short)	1
2	59579	双头螺柱（0.437-14/0.437-20×2.812）（短型）	STUD (.437-14/.437-20 x 2.812) (Short)	2
3	818908	双头螺柱（0.500-13/0.500-20×4.120）（短型）	STUD (.500-13/.500-20 x 4.120) (Short)	2
4	816056	垫圈（短型）	WASHER (Short)	2
5	898832	螺母（0.500-20）（短型）	NUT (.500-20) (Short)	2
6	39349	不锈钢螺钉（0.312-18×0.750）（短型）	SCREW (.312-18 x .750) Stainless Steel (Short)	1
7	847539	垫圈（短型）	WASHER (Short)	1
8	818909	排气挡板	PLATE Exhaust Blockoff	1
9	822838	垫圈（0.401×0.745×0.097）（短型）	WASHER (.401 x .745 x .097) (Short)	10
10	826709113	不锈钢螺母（0.375-24）（短型）	NUT (.375-24) Stainless Steel (Short)	2
10	8M0204726	黄铜螺母 (.375-24)	NUT (.375-24) Brass	2
10	82671013	不锈钢螺母（0.375-24）（短型）	NUT (.375-24) Stainless Steel (Short)	8
11	822836	垫圈(.445 x .805 x .108)	WASHER (.445 x .805 x .108)	3
12	859116	螺母(.437-20)	NUT (.437-20)	3
-	881805A01	发动机垫片组	GASKET SET Engine	1

图 12电气板总成 Electrical Plate Assembly

REF	零件编号	中文名称	英文名称	数量
-	NSS	不单独销售-电气板总成(完整)	NOT SOLD SEPARATE Electrical Plate Assembly-Complete	1
1	899071T01	安装板	PLATE	1
2	899145	绑带夹	CLIP Tie Strap	2
3	82129114	螺钉 (M6 x 14)	SCREW (M6 x 14)	1
4	29245	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	2
4	8M0204649	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	2
5	882751A1	继电器总成	RELAY ASSEMBLY	1
5	8M0207773	调整继电器总成	RELAY ASSEMBLY Trim	1
6	828102	支架	BRACKET	1
6	8M0207771	安装支架	BRACKET Mounting	1
7	818967	护孔环	GROMMET	1
7	8M0207785	护孔环	GROMMET	1
8	818968	衬套	BUSHING	1
8	8M0214955	衬套	BUSHING	1
9	82129125	螺丝(M6 x 25毫米)	SCREW (M6 x 25 mm)	5
10	892926T03	发动机线束总成	HARNESS ASSEMBLY Engine	1
-	832969T20	迷你保险丝-黄色-20安	FUSE Mini - Yellow - 20 Ampere	2
-	832969T15	迷你保险丝-蓝色-15安培	FUSE Mini - Blue - 15 Ampere	1
-	8329692	迷你保险丝-灰色-2安培	FUSE Mini - Gray - 2 Ampere	1
-	8M0207797	迷你保险丝-灰色-2安培	FUSE Mini - Gray - 2 Ampere	1
-	832969T05	迷你保险丝-棕色-5安培	FUSE Mini - Tan - 5 Ampere	1
-	879346A49	线束修理包（直喷喷油器）	HARNESS REPAIR KIT (Direct Injector)	1
-	879346A50	线束修理包（燃油喷油器）	HARNESS REPAIR KIT (Fuel Injector)	1
-	881262A2	交流发电机线束总成	HARNESS ASSEMBLY Alternator	1
-	878073A2	线束总成（节气门位置传感器）	HARNESS ASSEMBLY (Throttle Position Sensor)	1
-	879346A41	线束维修套件	HARNESS REPAIR KIT	1
11	875302A1	带电螺柱总成	HOT STUD ASSEMBLY	1
12	400213	不锈钢螺母 (M8)	NUT (M8) Stainless Steel	1
13	85172	垫圈	WASHER	1
14	93388T21	线缆总成(黑色)	CABLE ASSEMBLY Black	1
15	8M0006811	启动机电缆总成	CABLE ASSEMBLY Starter	1
16	878231A03	保险丝线束总成-100安培	HARNESS ASSEMBLY Fuse - 100 Ampere	1
17	53166	锁紧垫圈 (.312)	LOCKWASHER (.312)	3
18	400213	不锈钢螺母 (M8)	NUT (M8) Stainless Steel	1
19	88439A46	电缆总成 蓄电池-正极	CABLE ASSEMBLY Battery - Positive	1
20	817109A2	电磁阀总成(#10-32/.3125-18端子)	SOLENOID ASSEMBLY (#10-32 / .3125-18 Terminals)	1
21	822179	护孔环	GROMMET	2
22	818968	衬套	BUSHING	2
22	8M0214955	衬套	BUSHING	2
23	88807A16	黑色电缆总成(4.00英寸)	CABLE ASSEMBLY (4.00 Inches) Black	1
24	45076	黄铜螺母(#10-32)	NUT (#10-32) Brass	2
25	813938	盖形螺母(#10-32)	CAP NUT (#10-32)	2
26	68292	螺母(.312-18)	NUT (.312-18)	2
26	8M0204668	螺母(.312-18)	NUT (.312-18)	2
27	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	3

图 13排气板 Exhaust Plate

REF	零件编号	中文名称	英文名称	数量
1	190506	衬垫	GASKET	1
2	828343A05	排气分隔板总成	PLATE ASSEMBLY Exhaust Divider	1
3	814754	密封件(12.50英寸)	SEAL (12.50 Inches)	1
4	8263561	螺钉带垫圈(.312-18 x 1.500)	SCREW AND WASHER (.312-18 x 1.500)	16
5	881190	螺丝(.312-18 x 1.00)	SCREW (.312-18 x 1.00)	2
6	8M0039767	安全阀盖	COVER Relief Valve	1
7	31984	螺钉(0.312-18×1.375)	SCREW (.312-18 x 1.375)	4
8	69570	螺钉(#10-16 x .750)	SCREW (#10-16 x .750)	1
9	76451	垫圈	WASHER	1
10	144791	隔膜	DIAPHRAGM	1
11	16496	导水板	DEFLECTOR Water	1
12	16497A1	安装板	PLATE	1
13	78690002	衬垫	GASKET	2
14	42996	不锈钢弹簧	SPRING (Stainless Steel)	1
15	14480	提动阀	POPPET	1
16	64872	护孔环	GROMMET	1
17	65848	托架	CARRIER	1
18	8231422	衬垫	GASKET	1
19	90192	不锈钢螺钉（0.250-20×0.750）（长型）	SCREW (.250-20 x .750) Stainless Steel (Long)	6
20	879288T71	排气管延长段	EXTENSION Exhaust	1
21	428611	管接头-黄铜(.750-14)	FITTING Pipe - Brass (.750-14)	1
21	8M0204679	管接头-黄铜(.750-14)	FITTING Pipe - Brass (.750-14)	1
22	8603001	缸体顶部接头	FITTING Top of Block	1
23	36382	黄铜提升阀盖接头（0.250-18×0.62）	FITTING (.250-18 x .62) Brass Poppet Cover	1
24	390721	黄铜管塞 (.125-27)	PLUG Pipe (.125-27) Brass	2
25	36373	六角堵头（.375-18）-钢制	PLUG (.375-18) Hex - Steel	1
25	8M0204657	堵头	PLUG	1
26	91903	螺钉（0.437-14×1.750）（短型）	SCREW (.437-14 x 1.750) (Short)	3
27	822836	垫圈（0.445×0.805×0.108）（短型）	WASHER (.445 x .805 x .108) (Short)	3
28	8M0043826	定位销（板至动力头）	PIN Dowel (Plate to Powerhead)	2
29	672951	水管	TUBE Water	1
30	43044	无孔定位销（0.375×0.625）（板至驱动轴壳体）	PIN Dowel - Without Hole (.375 x .625) (Plate to Driveshaft Housing)	2
31	38970	密封件	SEAL	1
-	817717A7	排气延伸板总成（短型）	PLATE ASSEMBLY Exhaust Extension (Short)	1
32	26992	不锈钢锁紧垫圈（0.250）（短型）	LOCKWASHER (.250) Stainless Steel (Short)	1
33	NSS	排气延伸板不单独销售	NOT SOLD SEPARATE PLATE, Exhaust Extension	1
34	44260	固定座（短型）	RETAINER (Short)	1
35	28635	不锈钢螺钉（0.250-20×0.620）（短型）	SCREW (.250-20 x .620) Stainless Steel (Short)	1
36	8M0047146	螺钉(0.25-20×1.50)	SCREW (0.25-20 x 1.50)	6
37	35044	垫圈(0.281×0.625×0.065)不锈钢	WASHER (.281 x .625 x .065) Stainless Steel	6
38	390721	黄铜管塞 (.125-27)	PLUG Pipe (.125-27) Brass	2
39	774572	软管（48英寸卷料/缸体至压缩机进水口）	HOSE (48.00 Inches Bulk) Cylinder Block to Compressor Water Inlet	1
-	881805A01	发动机垫片组	GASKET SET Engine	1
-	848040A51	动力头总成（部分）	POWERHEAD ASSEMBLY Partial	1

图 14飞轮/交流发电机 Flywheel/Alternator

REF	零件编号	中文名称	英文名称	数量
1	889955A03	交流发电机套件	ALTERNATOR KIT	1
1	8M0064021	交流发电机	ALTERNATOR	1
2	8M0012503	螺钉(M10×1.5)	SCREW (M10 x 1.5)	1
3	40108120	螺钉(M10×120)六角法兰-不锈钢	SCREW (M10 x 120) Hex Flange - Stainless Steel	1
4	8M0042641	垫圈(0.390×1.00×0.06)	WASHER (.390 x 1.00 x .06)	3
5	856975	支架	MOUNT	3
6	858391T01	支架	BRACKET	1
7	845998	垫圈(0.406×1.250×0.089)	WASHER (.406 x 1.250 x .089)	3
8	858393T01	支架	BRACKET	1
9	826292	螺母(M10)黄铜/镀镍	NUT (M10) Brass/Nickel Plated	2
10	82446155	螺钉(M10×55)	SCREW (M10 x 55)	1
11	856583T2	拉线总成	CABLE ASSEMBLY	1
12	8215832	特殊销（1.5英寸）	PIN Special (1.5 Inches)	1
12	8M0042972	特殊销（1.75英寸）	PIN Special (1.75 Inches)	1
13	857142T	支架	BRACKET	1
14	812618	不锈钢螺钉(.312-18 x 1.00)带尼龙垫	SCREW (.312-18 x 1.00) Stainless Steel With Nylon Patch	3
15	855798001	弹簧	SPRING	1
16	856815T2	张紧臂总成	ARM TENSIONER ASSEMBLY	1
17	8M0034457	螺柱(M10×85)	STUD (M10 x 85)	1
18	826292	螺母(M10)黄铜/镀镍	NUT (M10) Brass/Nickel Plated	1
19	8568941	衬套	BUSHING	1
20	4002320	垫圈	WASHER	2
21	852385A2	皮带轮总成	PULLEY ASSEMBLY	1
21	8M6005030	皮带轮总成	PULLEY ASSY	1
22	4010835	螺钉(M10×35)六角法兰-不锈钢	SCREW (M10 x 35) Hex Flange - Stainless Steel	1
23	828507Q4	皮带	BELT	1
24	859734T1	飞轮	FLYWHEEL	1
25	52901	螺母(0.625-18)	NUT (.625-18)	1
26	68229	垫圈(.641 x 1.250 x .190)	WASHER (.641 x 1.250 x .190)	1
26	33001	垫圈	WASHER	1
27	45907	黄色塞	PLUG Yellow	1
28	401386	螺母(M6)不锈钢	NUT (M6) Stainless Steel	1
29	4002319	垫圈	WASHER	1

图 15燃油软管 Fuel Hoses

REF	零件编号	中文名称	英文名称	数量
1	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	AR
2	856880	软管卡箍（15.3）	CLAMP Hose (15.3)	AR
2	8M0214964	卡箍	CLAMP	AR
3	858955	连接器	CONNECTOR	1
4	8M0047428	软管（内径0.25英寸，57英寸卷料/裁切7.5英寸）	HOSE (.25 inch ID, 57.00 Inches Bulk) (Cut to 7.5 Inches)	1
4	8M0108355	软管(57英寸 散装)	HOSE (57 Inches Bulk)	1
5	897972	燃油泵软管	HOSE To Fuel Pump	1
5	8M0064784	成型脉冲软管	HOSE,MOLDED,PULSE	1
6	858757A1	软管总成(25.50英寸)	HOSE ASSEMBLY (25.50 Inches)	1
6	8M0062344	软管总成	HOSE ASSY	1
7	804822	燃油回油软管	HOSE Fuel Return	1
7	8M6001914	软管	HOSE	1
8	804821002	燃油平衡软管(14.00英寸)	HOSE (14.00 Inches) Fuel Balance	1
8	8M6001755	软管总成	HOSE ASSY	1
9	804840	O型圈套件	O-RING KIT	1
10	85677870	软管	HOSE	1
10	8M0064634	软管	HOSE	1
11	85677887	软管	HOSE	1
11	8M0064635	软管	HOSE	1
12	NLA	套管（已停产）	No Longer Available SLEEVE	2
13	13791	卡箍(15.7)	CLAMP (15.7)	2
13	8M0214911	卡箍@5	CLAMP @5	2
14	8557611	止回阀	CHECK VALVE	1

图 16燃油泵 Fuel Pump

REF	零件编号	中文名称	英文名称	数量
-	14360T75	燃油泵总成	PUMP ASSEMBLY Fuel	1
1	NSS	不单独销售-燃油泵本体	NOT SOLD SEPARATE Body-Fuel Pump	1
2	857005A1	膜片组件	DIAPHRAGM KIT	1
3	NSS	膜片(不单独销售)	NOT SOLD SEPARATE Diaphragm	1
4	NSS	固定座(不单独销售)	NOT SOLD SEPARATE Retainer	2
5	NSS	弹簧(不单独销售)	NOT SOLD SEPARATE Spring	1
6	NSS	盖帽(不单独销售)	NOT SOLD SEPARATE Cap	1
7	NSS	弹簧(不单独销售)	NOT SOLD SEPARATE Spring	1
8	NSS	盖帽(不单独销售)	NOT SOLD SEPARATE Cap	1
9	NSS	膜片(不单独销售)	NOT SOLD SEPARATE Diaphragm	1
10	NSS	增压垫片(不单独销售)	NOT SOLD SEPARATE Gasket-Boost	1
11	NSS	脉冲垫片(不单独销售)	NOT SOLD SEPARATE Gasket-Pulse	1
12	987691	衬垫	GASKET	1
12	8M0204705	衬垫@2	GASKET @2	1
13	987752	安装板	PLATE	1
14	996642	90度弯头接头(0.125-27x0.250)尼龙	FITTING Elbow 90 Degree (.125-27 x .250) Nylon	1
15	82104540	螺钉(M5 x 40)	SCREW (M5 x 40)	2
16	82130050	螺钉(M6×50)泵至曲轴箱	SCREW (M6 x 50) Pump to Crankcase	2
17	144303	底座	BASE	1
18	291112	接头	FITTING	1
19	782792	45度弯头接头(1.25)	FITTING Elbow 45 Degree (1.25)	1
19	8M0207781	弯头	ELBOW	1
20	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	2
21	856822A2	软管套管总成(18.00英寸)	HOSE AND SLEEVE ASSEMBLY (18.00 Inches)	1
21	8M0043979	软管套管总成	HOSE AND SLEEVE ASSEMBLY	1
22	822769	连接器	CONNECTOR	1
-	881805A01	发动机垫片组	GASKET SET Engine	1

图 17燃油导轨 Fuel Rails

REF	零件编号	中文名称	英文名称	数量
-	8M0055705	燃油导轨总成(完整)	FUEL RAIL ASSEMBLY Complete	1
-	8M0185153	燃油导轨总成	FUEL RAIL ASSY	1
1	NSS	燃油轨（左舷）不单独销售	NOT SOLD SEPARATE Fuel Rail (Port)	1
2	NSS	燃油轨（右舷）不单独销售	NOT SOLD SEPARATE Fuel Rail (Starboard)	1
3	804830	卡箍	CLAMP	4
4	804525001	螺丝包(2件)(M5x10)	SCREW PACKAGE (2 Per)(M5 x 10)	16
4	8M0041100	螺钉 (M5 x 10)	SCREW (M5 x 10)	16
5	883542	阀门总成(0.375英寸直径)	VALVE ASSEMBLY (.375 Inch Diameter)	2
5	8M0047053	施拉德阀维修包	VALVE KIT Shrader	2
6	804840	O型圈套件	O-RING KIT	1
7	805515	施拉德阀帽-黄铜	CAP Shrader Valve - Brass	2
7	8M0046566	阀帽	CAP Valve	2
8	804835	塞(左舷)	PLUG (Port)	1
9	880816	卡箍	CLAMP	1
9	8M0041097	支架	BRACKET	1
10	8048311	卡箍	CLAMP	4
11	804528	喷油器	INJECTOR	6
11	8M0222157	燃油喷射器	FUEL INJECTOR	6
12	804530	O型圈套件(含6件)	O-RING KIT Contains 6 pcs	1
13	804529	O型圈套件(含6件)	O-RING KIT Contains 6 pcs	1
14	804522	卡箍	CLAMP	2
15	880808	卡箍	CLAMP	1
16	880807T04	空气调节器	REGULATOR Air	1
16	8M0222159	空气调节器	AIR REGULATOR	1
17	880809	O型圈套件	O-RING KIT	1
18	804832	卡箍	CLAMP	2
19	804526	螺丝包(M5x16)(2件)	SCREW PACKAGE (M5 x 16) (2 Per)	4
20	804535	盖板	COVER	1
20	804535001	盖板	COVER	1
21	804534	弹簧	SPRING	1
22	804533	膜片总成	DIAPHRAGM ASSEMBLY	1
23	804536	O型圈	O-RING	2
24	804834	塞(右舷)	PLUG (Starboard)	1
25	804836	接头	FITTING	1
26	804532	O型圈套件	O-RING KIT	1
27	884595A01	空气喷射器总成	INJECTOR ASSEMBLY Air	6
27	8M6001744	空气喷射器总成	INJECTOR ASM-AIR	6
28	804875	直喷器密封套件	SEAL KIT Direct Injector	6
29	8M0034470	双头螺柱（M10×92）	STUD (M10 x 92)	4
29	8M0063255	双头螺栓M10x92	STUD M10x92	4
30	826292	螺母(M10)黄铜/镀镍	NUT (M10) Brass/Nickel Plated	4
31	859404002	喷射垫片	WASHER Injection	6
32	899145	绑带夹	CLIP Tie Strap	4

图 18衬垫组件套装(完整动力头及下部单元) Gasket Set Components Complete Powerhead and Lower Unit

REF	零件编号	中文名称	英文名称	数量
-	881805A01	发动机动力头与下部单元衬垫套装	GASKET SET Engine Powerhead and Lower Unit	1
0	857005A1	膜片组件	DIAPHRAGM KIT	1
0	NSS	膜片(不单独销售)	NOT SOLD SEPARATE Diaphragm	2
0	NSS	固定座(不单独销售)	NOT SOLD SEPARATE Retainer	2
0	NSS	弹簧(不单独销售)	NOT SOLD SEPARATE Spring	1
0	NSS	盖帽(不单独销售)	NOT SOLD SEPARATE Cap	1
0	NSS	增压弹簧(不单独销售)	NOT SOLD SEPARATE Spring-Boost	1
0	NSS	不单独销售 端盖-弹簧	NOT SOLD SEPARATE Cap-Spring End	1
0	NSS	增压垫片(不单独销售)	NOT SOLD SEPARATE Gasket-Boost	1
0	NSS	脉冲垫片(不单独销售)	NOT SOLD SEPARATE Gasket-Pulse	1
0	987691	燃油泵衬垫	GASKET Fuel Pump	1
0	8M0204705	衬垫@2	GASKET @2	1
0	54029	O型圈(2.800x0.103)上端盖	O-RING (2.800 x .103) Upper End Cap	1
0	62700	O型圈(3.237x0.103)下端盖	O-RING (3.237 x .103) Lower End Cap	1
0	62386001	节温器盖衬垫	GASKET Thermostat Cover	2
0	8M0204714	衬垫@4	GASKET @4	2
0	65800	曲轴下密封填料	PACKING Crankshaft-Lower	1
0	190506	排气分隔板衬垫	GASKET Exhaust Divider Plate	1
0	814754	排气分隔板密封条（12.5英寸）	SEAL (12.50 Inches) Exhaust Divider Plate	1
0	78690002	安全阀盖与板衬垫	GASKET Relief Valve Cover and Plate	2
0	8231422	气缸体衬垫	GASKET Cylinder Block	1
0	183076	驱动轴壳体板衬垫-长型	GASKET DriveShaft Housing Plate - Long	1
0	782461	排气延伸衬垫-长型	GASKET Exhaust Extension - Long	1
0	38970	驱动轴壳体板密封条-长型	SEAL DriveShaft Housing Plate - Long	1
0	991734	驱动轴壳体衬垫-长型	GASKET Driveshaft Housing - Long	1
0	25439	O型圈(.862×0.103)	O-RING (.862 x .103)	1
0	426311	水泵底座下部衬垫	GASKET Water Pump Base-Lower	1
0	8M0204678	衬垫	GASKET	1
0	90011	水泵底座下部O型圈(2.175x0.175)	O-RING (2.175 x .175) Water Pump Base-Lower	1
0	8M0142854	O型圈(2.175 x 0.103)	O-RING (2.175 x .103)	1
0	18051	水泵底座下部衬垫	GASKET Water Pump Base-Lower	1
0	858524	水泵底座上部衬垫	GASKET Water Pump Base-Upper	1
0	38970	水泵体密封件	SEAL Water Pump Body	1

图 19齿轮箱(驱动)标准/反向旋转-Sportmaster型 Gear Housing (Drive) Standard/Counter Rotatation-Sportmaster

REF	零件编号	中文名称	英文名称	数量
-	840560A09	齿轮箱总成(完整)(1.75)	GEAR HOUSING ASSEMBLY Complete (1.75)	1
-	840561A45	齿轮箱总成(完整)(1.75)	GEAR HOUSING ASSEMBLY Complete (1.75)	1
1	849780A2	基础齿轮箱总成	GEAR HOUSING ASSEMBLY Basic	1
1	8M0083306	齿轮箱-SM型	GEAR HOUSING-SM	1
1	849781A2	基础齿轮箱总成	GEAR HOUSING ASSEMBLY Basic	1
1	8M0084203	齿轮箱-SM型	GEAR HOUSING-SM	1
2	8479504	盖板	COVER	2
3	34776	O型圈	O-RING	2
4	815904	螺钉(#10-32 x .500)	SCREW (#10-32 x .500)	12
5	43044	定位销-无孔(.375 x .625)	PIN Dowel - Without Hole (.375 x .625)	2
6	42647A1	滚柱轴承总成	BEARING ASSEMBLY Roller	1
7	8M0039169	填充块	FILLER BLOCK	1
8	847949	管塞	PLUG Pipe	1
9	8M0034463	螺柱(.312-24 x 3.38)	STUD (.312-24 x 3.38)	1
10	30667	双头螺栓(.250-20/.250-28×3.125)	STUD (.250-20/.250-28 x 3.125)	2
10	306671	螺柱	STUD	2
11	826134Q	阳极块	ANODE	2
12	4000333	螺钉(M6 x 40)	SCREW (M6 x 40)	1
13	401386	螺母(M6)不锈钢	NUT (M6) Stainless Steel	1
14	59579	双头螺柱(.437-14/.437-20 x 2.812)	STUD (.437-14/.437-20 x 2.812)	3
15	NSS	小齿轮(不单独销售)	NOT SOLD SEPARATE Pinion Gear	1
16	92721	垫圈(.965×0.630)	WASHER (.965 x .630)	1
17	35921	螺母(0.625-18)	NUT (.625-18)	1
18	79953Q04	放油螺钉套件	SCREW KIT Drain	1
19	830749	密封件	SEAL	1
19	8M0204693	放油螺塞密封件	SEAL Drain Plug	1
20	789022		SHIFT SHAFT (Lower)	1
21	77631A2	衬套总成	BUSHING ASSEMBLY	1
22	25439	O型圈(.862×0.103)	O-RING (.862 x .103)	1
23	8164641	油封	SEAL Oil	1
23	8M0246145	油封	OIL SEAL	1
24	77674	垫圈(.35 x .75 x .12)	WASHER (.35 x .75 x .12)	1
25	848449A4	驱动轴总成	DRIVESHAFT ASSEMBLY	1
25	8M0192233	驱动轴	DRIVESHAFT	1
26	38657A1	垫片组	SHIM ASSEMBLY	1
26	8M0063268	垫片组	SHIM SET	1
27	48939A2	圆锥滚子轴承	BEARING Taper Roller	1
27	8M0146553	杯/锥轴承总成	BEARING ASSEMBLY Cup/Cone	1
28	NSS	滚子轴承杯(不单独销售)	NOT SOLD SEPARATE Cup-Roller Bearing	1
29	42637A1	垫片组	SHIM SET	AR
29	8M0063267	垫片组	SHIM SET	AR
30	36387A1	轴承总成(滚子/外圈)	BEARING ASSEMBLY Roller/Cup	1
30	8M0146566	杯/锥轴承总成	BEARING ASSEMBLY Cup/Cone	1
31	NSS	杯形轴承(不单独销售)	NOT SOLD SEPARATE Cup-Bearing	1
32	8245191	固定座	RETAINER	1
33	44292A3	水泵底座总成	BASE ASSEMBLY Water Pump	1
34	426311	衬垫	GASKET	1
34	8M0204678	衬垫	GASKET	1
35	90011	O型圈(2.175 x 0.175)	O-RING (2.175 x .175)	1
35	8M0142854	O型圈(2.175 x 0.103)	O-RING (2.175 x .103)	1
36	89238	油封	SEAL Oil	1
37	16977	油封	SEAL Oil	1
38	18051	衬垫(下部)	GASKET (Lower)	1
39	858524		GASKET (Upper)	1
40	324351	面板	FACE PLATE	1
40	8M0204677	面板	PLATE-FACE	1
41	96148A8	水泵维修套件	WATER PUMP REPAIR KIT	1
42	48752T	嵌件	INSERT	1
43	38970	密封件	SEAL	1
44	29804T	套筒	SLEEVE	1
45	8M0032834	键	KEY	1
45	8M0214992	键@5	KEY @5	1
46	89984T4	叶轮	IMPELLER	1
47	29245	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	2
47	8M0204649	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	2
48	8267119	螺母(.250-28)	NUT (.250-28)	2
49	36001	垫圈	WASHER	1
50	13436	螺母	NUT	1
51	96411	螺钉(#14-8×2.25)	SCREW (#14-8 x 2.25)	1
51	8M0215009	螺钉	SCREW	1
-	89238A3	齿轮箱密封套件	SEAL KIT Gear Housing	1
-	881805A01	发动机垫片组	GASKET SET Engine	1
-	59579	双头螺柱(.437-14/.437-20 x 2.812)	STUD (.437-14/.437-20 x 2.812)	3

图 20齿轮箱螺旋桨轴-反向-Sportmaster型 Gear Housing Propeller Shaft-Counter-Sportmaster

REF	零件编号	中文名称	英文名称	数量
-	840561A45	齿轮箱总成(完整)(1.75)	GEAR HOUSING ASSEMBLY Complete (1.75)	1
1	849781A2	齿轮箱总成(基础)(不含螺柱，需另购螺柱16-59579)	GEAR HOUSING ASSEMBLY Basic (Does not Include Studs. Order Stud 16-59579 Listed Below)	1
1	8M0084203	齿轮箱-SM型	GEAR HOUSING-SM	1
2	89594A1	从动件总成	FOLLOWER ASSEMBLY	1
3	789562	换挡凸轮	SHIFT CAM	1
4	79911A1	杆	ROD	1
5	79910	弹簧	SPRING	2
6	78906	销	PIN	1
6	8M0084245	弹簧定位销	PIN Spring Locator	1
7	78910	垫圈	WASHER	2
8	14469T	轴承杯	CUP Bearing	1
9	88957T	滚珠轴承	BEARING Ball	1
10	78962	弹簧	SPRING	2
11	15844	滚柱轴承总成	BEARING ASSEMBLY Roller	1
12	8M0052635	棘轮	RATCHET	1
13	78909	定位销	PIN Detent	2
14	42671	十字销	PIN Cross	1
15	826182A1	倒车齿轮总成	GEAR ASSEMBLY Reverse	1
16	8M0063398	小齿轮/前进齿轮总成	GEAR ASSEMBLY Pinion/Forward	1
17	176151	调整垫片(.125)	SPACER SHIM (.125)	AR
17	176152	调整垫片(.127)	SPACER SHIM (.127)	AR
17	176153	调整垫片(.129)	SPACER SHIM (.129)	AR
17	176154	调整垫片(.131)	SPACER SHIM (.131)	AR
17	176155	调整垫片(.133)	SPACER SHIM (.133)	AR
17	176156	调整垫片(.135)	SPACER SHIM (.135)	AR
17	176157	调整垫片(.137)	SPACER SHIM (.137)	AR
17	176158	调整垫片(.139)	SPACER SHIM (.139)	AR
17	176159	调整垫片(.141)	SPACER SHIM (.141)	AR
17	1761510	调整垫片(.143)	SPACER SHIM (.143)	AR
17	1761511	调整垫片(.145)	SPACER SHIM (.145)	AR
17	1761512	调整垫片(.147)	SPACER SHIM (.147)	AR
17	1761513	调整垫片(.149)	SPACER SHIM (.149)	AR
18	15841	滚柱轴承	BEARING Roller	1
19	17616	推力环	THRUST RING	1
20	31534	O型圈	O-RING	1
20	8M0214920	O型圈	O RING	1
21	15838A2	轴承适配器总成	ADAPTER ASSEMBLY Bearing	1
22	15843T	滚针轴承	BEARING Needle	1
23	15834	推力轴承	BEARING Thrust	2
24	840450A03	螺旋桨轴套件	PROPELLER SHAFT KIT	1
-	840389K06	螺旋桨毂套件	PROP HUB KIT	1
-	8M0183487	重型螺旋桨轮毂套件	HUB KIT-HD PROP	1
-	840382A02	缓冲条套件	SNUBBER STRIP KIT	1
25	847616T1	轴承座	CARRIER Bearing	1
26	817072	滚柱轴承	BEARING Roller	1
27	815565	油封	SEAL Oil	2
28	817071	卡环	RING Snap	1
29	67892A06	磁性放油塞套件	PLUG KIT Drain - Magnetic	1
29	8M0058389	放油螺钉套件	SCREW KIT Drain	1
30	191833	密封件	SEAL	1
30	8M0187157	蓝色密封件@15	SEAL-BLUE @15	1
31	30281	键	KEY	1
32	79447	锁紧垫圈	TAB WASHER	1
33	158401	盖板	COVER	1
34	85344	垫圈(.750内径)	WASHER (.750 Inside Diameter)	1
35	52707Q1	螺旋桨螺母套件 (.750-16)	PROP NUT KIT (.750-16)	1
36	41350	螺钉(.437-14 x 2.50)不锈钢	SCREW (.437-14 x 2.50) Stainless Steel	1
37	822836	垫圈(.445 x .805 x .108)	WASHER (.445 x .805 x .108)	2
38	859116	螺母(.437-20)	NUT (.437-20)	2
39	30206	螺钉(.375-16 x 1.00)不锈钢	SCREW (.375-16 x 1.00) Stainless Steel	1
40	76214T3	阳极块	ANODE	1
-	89238A3	齿轮箱密封套件	SEAL KIT Gear Housing	1
-	59579	双头螺柱(.437-14/.437-20 x 2.812)	STUD (.437-14/.437-20 x 2.812)	3

图 21齿轮箱螺旋桨轴-标准-Sportmaster Gear Housing Propeller Shaft-Standard-Sportmaster

REF	零件编号	中文名称	英文名称	数量
-	840560A09	齿轮箱总成(完整)(1.75)	GEAR HOUSING ASSEMBLY Complete (1.75)	1
1	849780A2	齿轮箱总成(基础)(不含螺柱，需另购螺柱16-59579)	GEAR HOUSING ASSEMBLY Basic (Does Not Include Studs. Order the Stud 16-59579 listed below)	1
1	8M0083306	齿轮箱-SM型	GEAR HOUSING-SM	1
2	89594A1	从动件总成	FOLLOWER ASSEMBLY	1
3	789562	换挡凸轮	SHIFT CAM	1
4	79911A1	杆	ROD	1
5	79910	弹簧	SPRING	2
6	78906	销	PIN	1
6	8M0084245	弹簧定位销	PIN Spring Locator	1
7	78910	垫圈	WASHER	2
8	47397A1	垫片组	SHIM SET	AR
9	78172A1	圆锥滚子轴承总成	BEARING ASSEMBLY Taper Roller	1
10	NSS	杯状件(不单独销售)	NOT SOLD SEPARATE Cup	1
11	30281	键	KEY	1
12	79447	锁紧垫圈	TAB WASHER	1
13	8M0052635	棘轮	RATCHET	1
14	78909	定位销	PIN Detent	2
15	42671	十字销	PIN Cross	1
16	78962	弹簧	SPRING	2
17	840451A03	螺旋桨轴	PROPELLER SHAFT	1
-	840389K06	螺旋桨毂套件	PROP HUB KIT	1
-	8M0183487	重型螺旋桨轮毂套件	HUB KIT-HD PROP	1
-	840382A02	缓冲条套件	SNUBBER STRIP KIT	1
18	849189T2	齿轮转换套件	GEAR CONVERSION KIT	1
19	822823	推力环	THRUST RING	1
20	88957T	滚珠轴承	BEARING Ball	1
21	681001	止推环	RING Thrust	1
22	NSS	倒车齿轮(不单独销售)(1.75)	NOT SOLD SEPARATE REVERSE GEAR, 1.75	1
23	549281	滚柱轴承	BEARING Roller	1
24	848840A1	轴承座总成	CARRIER ASSEMBLY Bearing	1
25	817071	卡环	RING Snap	2
26	815565	油封	SEAL Oil	2
27	817072	滚柱轴承	BEARING Roller	1
28	67892A06	磁性放油塞套件	PLUG KIT Drain - Magnetic	1
28	8M0058389	放油螺钉套件	SCREW KIT Drain	1
29	191833	密封件	SEAL	1
29	8M0187157	蓝色密封件@15	SEAL-BLUE @15	1
30	8M2011027	轴承座固定环	RETAINER Bearing Carrier	1
30	8M2000347	固定座	RETAINER	1
31	31534	O型圈	O-RING	1
31	8M0214920	O型圈	O RING	1
32	85344	垫圈(.750内径)	WASHER (.750 Inside Diameter)	1
33	52707Q1	螺旋桨螺母套件 (.750-16)	PROP NUT KIT (.750-16)	1
34	41350	螺钉(.437-14 x 2.50)不锈钢	SCREW (.437-14 x 2.50) Stainless Steel	1
35	76214T3	阳极块	ANODE	1
36	822836	垫圈(.445 x .805 x .108)	WASHER (.445 x .805 x .108)	3
37	859116	螺母(.437-20)	NUT (.437-20)	3
38	30206	螺钉(.375-16 x 1.00)不锈钢	SCREW (.375-16 x 1.00) Stainless Steel	1
-	89238A3	齿轮箱密封套件	SEAL KIT Gear Housing	1
-	59579	双头螺柱(.437-14/.437-20 x 2.812)	STUD (.437-14/.437-20 x 2.812)	3

图 22机油喷射组件 Oil Injection Components

REF	零件编号	中文名称	英文名称	数量
1	85606065	管材(38英寸整卷)(裁切24英寸)	TUBING (38.00 Inches Bulk) (Cut to 24 Inches)	1
1	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	1
2	85606065		TUBING (38.00 Inches Bulk) (Cut to 18.5 Inches)	1
2	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	1
3	85606065		TUBING (38.00 Inches Bulk) (Cut to 15.5 Inches)	1
3	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	1
4	85606065	管材(38英寸整料)(裁切至24.5英寸)	TUBING (38.00 Inches Bulk) (Cut to 24.5 Inches)	2
4	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	2
5	85606065	管材(38英寸整卷)(裁切27英寸)	TUBING (38.00 Inches Bulk) (Cut to 27 Inches)	1
5	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	1
6	858805	止回阀	CHECK VALVE	6
7	69355	扎带(5.50英寸)	TIE STRAP (5.50 Inches)	AR
7	8M0214940	扎带	TIE STRAP	AR
8	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	AR
8	56762	扎带(4.00英寸)	TIE STRAP (4.00 Inches)	AR
9	892830053	软管(24.00英寸编织型)	HOSE (24.00 Inches Braided)	1
10	85583466	软管(40英寸整卷)(裁切32英寸)	HOSE (40.00 Inches Bulk) (Cut to 32 Inches)	1
10	8M0054213	软管	HOSE	1
11	8781051	止回阀	CHECK VALVE	1
12	424254	接头	FITTING	1
12	8M0207780	接头	FITTING	1
13	8M0047428	软管(内径0.25英寸，57英寸整料)(裁切至6英寸)	HOSE (.25 inch ID, 57.00 Inches Bulk) (Cut to 6 Inches)	1
13	8M0108355	软管(57英寸 散装)	HOSE (57 Inches Bulk)	1
14	NSS	盖帽(不单独销售)	NOT SOLD SEPARATE Cap	2
15	875289	软管	HOSE	1
16	858955	连接器	CONNECTOR	2
17	875284T01	滤清器-机油在线式	FILTER Oil - In Line	1
18	875283	软管(2.00英寸)	HOSE (2.00 Inches)	1
19	833069T9	储液罐总成	RESERVOIR ASSEMBLY	1
19	8M0063190	油箱总成	OIL TANK ASSY	1
20	NSS	警告标贴-机油溢出(不单独销售)	NOT SOLD SEPARATE Decal-Warning-Oil Overflow	1
21	855362001	护孔环	GROMMET	3
22	49436	垫圈	WASHER	3
23	60411	螺钉(.312-18 x 1.250)	SCREW (.312-18 x 1.250)	3
24	855364	衬套	BUSHING	3
25	856156T02	开关总成	SWITCH ASSEMBLY	1
26	58376	螺钉(.164-18 x .375)	SCREW (.164-18 x .375)	1
27	72761	不锈钢垫圈(.203 x .562 x .060)	WASHER (.203 x .562 x .060) Stainless Steel	1
28	814634	卡箍	CLAMP	1
29	NLA	导管(已停产)	No Longer Available CONDUIT	1
30	NSS	机油推荐标贴(不单独销售)	NOT SOLD SEPARATE Decal-Oil Recommendation	1

图 23油管 Oil Lines

REF	零件编号	中文名称	英文名称	数量
1	85606065	管材(38英寸整卷)(裁切30英寸)	TUBING (38.00 Inches Bulk) (Cut to 30 Inches)	1
1	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	1
2	85606065	管材(38英寸整料)(裁切至22.5英寸)	TUBING (38.00 Inches Bulk) (Cut to 22.5 Inches)	1
2	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	1
3	887801	弯头配件90度(.0625-27)	FITTING Elbow 90 Degree (.0625-27)	2
4	8592352	止回阀90度(.0625-27)	CHECK VALVE 90 Degree (.0625-27)	2
5	85606065	管材(38英寸整料)(裁切至16.5英寸)	TUBING (38.00 Inches Bulk) (Cut to 16.5 Inches)	2
5	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	2
6	151333	接头	FITTING	2
7	69355	扎带(5.50英寸)	TIE STRAP (5.50 Inches)	AR
7	8M0214940	扎带	TIE STRAP	AR
8	85606065	管材(38英寸整料)(按需裁切)	TUBING (38.00 Inches Bulk) (Cut to fit)	1
8	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	1
9	59169003	三通接头	FITTING Tee	2
10	85606065	管材(38英寸整料)(裁切至1.5英寸)	TUBING (38.00 Inches Bulk) (Cut to 1.5 Inches)	2
10	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	2
11	85606065	管材(38英寸整料)(按需裁切)	TUBING (38.00 Inches Bulk) (Cut to fit)	2
11	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	2
12	85606065	管材(38英寸整料)(按需裁切)	TUBING (38.00 Inches Bulk) (Cut to fit)	1
12	8M0054152	管材(39.00英寸整卷)	TUBING (39.00 Inches Bulk)	1
13	426233	止回阀	CHECK VALVE	3
14	426982	止回阀	CHECK VALVE	1

图 24PCM 安装 PCM Mounting

REF	零件编号	中文名称	英文名称	数量
1	8M8025140	推进控制模块PCM	PCM Propulsion Control Module	1
2	82130025	螺钉(M6x25)	SCREW (M6 x 25)	3
3	65567	不锈钢垫圈(0.265x0.750x0.048)	WASHER (.265 x .750 x .048) Stainless Steel	3
4	834985	护孔环	GROMMET	3
4	8M0190980	护孔环	GROMMET	3
5	856954	衬套	BUSHING	3
6	858953	支架	BRACKET	1
7	82129114	螺钉 (M6 x 14)	SCREW (M6 x 14)	1
8	82130012	螺钉（M6 x 12）	SCREW (M6 x 12)	3
9	830796A04	防水插头总成-4针公头	CONNECTOR ASSEMBLY Weather Cap - 4 Position Male	1
10	877613A02	防水插头总成6针	CONNECTOR ASSEMBLY Weather Cap 6 Pin	1
11	65292	J型卡扣	J CLIP	1
11	8M0024808	J型夹	J-CLIP	1

图 25维修/支撑材料 Service/Support Material

REF	零件编号	中文名称	英文名称	数量
-	8M0142637	零件手册175/200/225 3.4L V6四冲程/200 3.4L V6四冲程SEAPRO	PARTS MANUAL 175/200/225 3.4L V6 4 Stroke/ 200 3.4L V6 4 Stroke SEAPRO	1
-	8M0124302	维修手册175-300马力四冲程	SERVICE MANUAL 175-300 Hp FourStroke	1
-	8M0227198	维修手册V6/V8 CMS	SERVICE MANUAL V6/V8 CMS	1
-	8M0145934	安装手册V6/V8 CMS	INSTALLATION MANUAL V6/V8 CMS	1
-	8M0156797	安装手册V6(175-225)/V8(200-300)CMS	INSTALLATION MANUAL V6 (175-225), V8 (200-300) CMS	1
-	8M0145541	操作手册V6/V8 CMS机械式	OPERATION MANUAL V6/V8 CMS Mechanical	1
-	8M0175491	操作手册	MANUAL- OPERATION	1
-	8M0145542	操作手册V6/V8 CMS DTS	OPERATION MANUAL V6/V8 CMS DTS	1
-	8M0230588	操作手册150R和200R	OPERATION MANUAL 150R and 200R	1
-	8M0146617	诊断维修手册	SERVICE MANUAL Diagnostic	1
-	8M0182076	诊断手册	DIAGNOSTIC MANUAL	1
-	NSS	不单独销售贴纸, EPA	NOT SOLD SEPARATE DECAL, EPA	1

图 26启动电机 Starter Motor

REF	零件编号	中文名称	英文名称	数量
1	892339T01	启动电机总成	STARTER MOTOR ASSEMBLY	1
2	NSS		NOT SOLD SEPARATE THRU BOLT	2
3	880805A1	齿轮套件	GEAR KIT	1
4	809463A1	电磁阀组件	SOLENOID KIT	1
5	8M0065258	电刷组	BRUSH SET	1
6	69035	螺丝与锁紧垫圈(.250-20 x .625)不锈钢	SCREW AND LOCKWASHER (.250-20 x .625) Stainless Steel	1
7	93388A1	电缆总成(6.00英寸)黑色	CABLE ASSEMBLY (6.00 Inches) Black	1
8	8272822	高压警告标贴	DECAL Warning High Voltage	1
9	400255	锁紧垫圈(M5)	LOCKWASHER (M5)	1
10	400211	不锈钢螺母(M5)	NUT (M5) Stainless Steel	1
11	26993	锁紧垫圈 (.312)	LOCKWASHER (.312)	1
11	8M0204647	锁紧垫圈 (.312)	LOCKWASHER (.312)	1
12	400213	不锈钢螺母 (M8)	NUT (M8) Stainless Steel	1
13	8M0034918	轴环	COLLAR	2
14	8M0043276	橡胶止挡	STOP Rubber	1

图 27旋转支架(短型) Swivel Bracket (Short)

REF	零件编号	中文名称	英文名称	数量
1	818810T16	旋转支架总成	SWIVEL BRACKET ASSEMBLY	1
1	8M0145740	旋转支架	SWIVEL BRACKET	1
2	847729	油封	SEAL Oil	2
3	8M0042131	轴承	BEARING	2
4	74036	润滑脂接头	FITTING Grease	2
4	8M0169589	润滑脂接头	FITTING Grease	2
5	847728	轴承	BEARING	2
6	82203516	轴承	BEARING	1
6	82203522	轴承	BEARING	1
7	82203540	轴承(2.5英寸)	BEARING (2.5 Inches)	2
8	78854	波形垫圈	WAVE WASHER	1
9	86580F4	下轭架	YOKE Bottom	1
10	848125	螺旋锁紧挡圈	RING Retaining - Spiral Lock	2
11	8M0028057	旋转销(黑色)	SWIVEL PIN (Black)	1
11	8M0192243	旋转销	PIN-SWIVEL	1
12	132121	螺钉	SCREW	2
13	816056	垫圈	WASHER	2

图 28油门杆与换挡轴 Throttle Lever and Shift Shaft

REF	零件编号	中文名称	英文名称	数量
1	8M0040990	节气门控制杆	LEVER Throttle Control	1
2	818165	螺钉 (.375-16 x 1.75)	SCREW (.375-16 x 1.75)	1
3	55164	衬套	BUSHING	1
4	858959	隔套	SPACER	1
5	64022	螺钉(.250-20 x 2.125)	SCREW (.250-20 x 2.125)	1
6	64015	螺母 (.250-20)	NUT (.250-20)	1
7	26852	尼龙帽	CAP Nylon	1
8	42927	嵌件	INSERT	1
9	35459	垫圈	WASHER	1
10	401386	螺母(M6)不锈钢	NUT (M6) Stainless Steel	1
11	814283T6	锚支架总成	BRACKET ASSEMBLY Anchor	1
12	98889	闩锁	LATCH	1
13	42975	传动螺钉	DRIVE SCREW	2
14	39519	杯套	CUP	1
15	52100	耐磨板	WEAR PLATE	1
16	8M0036768	闩锁	LATCH	1
17	69056	垫圈(.255 x .620 x .030) 不锈钢	WASHER (.255 x .620 x .030) Stainless Steel	1
18	826709109	不锈钢螺母(.250-28)	NUT (.250-28) Stainless Steel	1
19	28782	螺钉(.312-18 x .880)不锈钢	SCREW (.312-18 x .880) Stainless Steel	3
20	814284	导向块	GUIDE BLOCK	1
21	20099	弹簧	SPRING	1
22	67073A1	连杆总成	LINK ROD ASSEMBLY	1
23	79932A18	换挡轴总成	SHIFT SHAFT ASSEMBLY	1
24	24800	销	PIN	1
25	NSS	换挡杆轴上段(不单独销售)	NOT SOLD SEPARATE Lever-Shift Shaft-Upper	1
26	26856	衬套	BUSHING	1
27	29720	波形垫圈	WAVE WASHER	1
28	35462	垫圈(.2656 x .625 x .0625)不锈钢	WASHER (.2656 x .625 x .0625) Stainless Steel	1
29	826709109	不锈钢螺母(.250-28)	NUT (.250-28) Stainless Steel	1
30	8M0052939	开关	SWITCH	1
30	8M0207794	开关	SWITCH	1
31	77478	螺钉 (#6-32 x .875)	SCREW (#6-32 x .875)	2
32	27882	垫圈	WASHER	2
33	932481	旋转衬套	BUSHING Swivel	2
33	8M0215006	旋转衬套	BUSHING Swivel	2
34	8508152	杆	ROD	1
35	8562211	凸轮	CAM	1
36	856895	衬套	BUSHING	1
37	NA	轴承(无货)	NOT AVAILABLE BEARING	1
38	81893440	螺钉 (M8 x 40)	SCREW (M8 x 40)	1
39	850286A03	油门杆/滚轮套件	LEVER/ROLLER KIT Throttle	1
40	889610	滚轮	ROLLER	1
40	8M0072162	滚轮	ROLLER	1
41	56681	垫圈 (.203 x .500 x .032)	WASHER (.203 x .500 x .032)	1
41	8M0204666	垫圈 (.203 x .500 x .032)	WASHER (.203 x .500 x .032)	1
42	826709104	螺母(#8-32)不锈钢	NUT (#8-32) Stainless Steel	1
43	889354	专用螺钉	SCREW Special	1
44	881992	线轴垫圈	WASHER Spool	1
44	8M0095734	垫圈/螺钉套件	WASHER/SCREW KIT	1
45	69432	外锁紧垫圈(#10)	LOCKWASHER External (#10)	1
46	881991	杯形垫圈	WASHER Cupped	1
46	8M0095734	垫圈/螺钉套件	WASHER/SCREW KIT	1

图 29顶罩 Top Cowl

REF	零件编号	中文名称	英文名称	数量
1	849203T23	顶盖总成	TOP COWL ASSEMBLY	1
2	849209A3	护罩	SHIELD	1
3	8488081	锁扣支架	BRACKET Latch	1
4	849179	安装板	PLATE	1
5	893763	滚轮锁扣支架	BRACKET Roller Latch	1
6	8267098	螺母 (.250-20) 不锈钢	NUT (.250-20) Stainless Steel	3
7	814101	螺母 (.250-20) 不锈钢	NUT (.250-20) Stainless Steel	4
7	8M0207776	螺母	NUT	4
8	807717	螺钉 (0.312-18 x 0.750)	SCREW (.312-18 x .750)	2
9	849011	螺钉(.250-20 x .750)	SCREW (.250-20 x .750)	4
10	849834A1	闩锁	LATCH	1
11	29245	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	7
11	8M0204649	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	7
-	840323A1	标贴套件(基础)	DECAL SET (Basic)	1
-	840323A18	标贴套件(补丁)	DECAL SET (Patch)	1

图 30艉板支架(短型) Transom Brackets (Short)

REF	零件编号	中文名称	英文名称	数量
1	847800A03	艉板支架总成-左舷	BRACKET ASSEMBLY Transom - Port	1
2	847801A03	艉板支架总成 - 右舷	BRACKET ASSEMBLY Transom - Starboard	1
3	847798A02	耐磨垫套件	WEAR PAD KIT	1
4	86843	螺钉(#10-24x0.500)	SCREW (#10-24 x .500)	4
5	8M0034469	螺柱	STUD	2
6	88512	卡箍	CLAMP	4
7	88829	螺钉(#10-24x0.500)	SCREW (#10-24 x .500)	6
8	858869	螺母 (.875-14)	NUT (.875-14)	1
8	NLA	螺母(1.00-14)(已停产)	No Longer Available NUT (1.00-14)	1
9	88750	波浪垫圈 (1.62 x 1.05)	WASHER Wave (1.62 x 1.05)	2
10	826125A1	倾斜管	TILT TUBE	1
11	85035T	隔套	SPACER	1
11	8M0237541	艉板隔套	SPACER Transom	1
12	677551	螺钉(.500-20×4.500)	SCREW (.500-20 x 4.500)	2/4
12	8M0149747	螺钉	SCREW	2/4
12	677552	螺钉(0.500-20 x 6.500)	SCREW (.500-20 x 6.500)	2
13	28421	垫圈(1.5x3.05x0.13)不锈钢	WASHER (1.5 x 3.05 x 0.13) Stainless Steel	4
13	8M0204648	垫圈(1.5x3.05x0.13)不锈钢	WASHER (1.5 x 3.05 x 0.13) Stainless Steel	4
14	82671117	螺母(.500-20)	NUT (.500-20)	4
15	826709117	螺母(0.500-20)不锈钢	NUT (.500-20) Stainless Steel	2
16	70732	螺钉 (.250-20 x 2.00)	SCREW (.250-20 x 2.00)	4
17	29245	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	4
17	8M0204649	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	4
18	85026T	安装板	PLATE	2
19	28636	螺钉(.250-20 x .750)	SCREW (.250-20 x .750)	4
20	29245	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	4
20	8M0204649	不锈钢垫圈(0.281x0.500x0.060)	WASHER (.281 x .500 x .060) Stainless Steel	4
21	54343	螺柱（.312-24 x 1.380）	STUD (.312-24 x 1.380)	4
21	8M0034451	螺柱	STUD	4
22	89949A1	隔板总成	PLATE ASSEMBLY	1
23	843108	垫圈（.330 x .560 x .060）不锈钢	WASHER (.330 x .560 x .060) Stainless Steel	4
24	82670911	螺母(.312-24)不锈钢	NUT (.312-24) Stainless Steel	4
25	89024	液压软管6英尺-泵升/右舷艉板	HOSE Hydraulic 6 Feet-Pump-Up/Port at Transom	1
25	89023	液压软管6英尺-泵降/左舷艉板	HOSE Hydaulic 6 Feet-Pump-Down/Starboard at Transom	1
26	96993	液压缸软管-上升/右舷艉板	HOSE Hydraulic Cylinder-Up/Port at Transom	1
26	96994	液压缸软管-下降/左舷艉板	HOSE Hydraulic Cylinder-Down/Starboard at Transom	1
27	87871T	盖板	COVER	1
28	45507	护孔环	GROMMET	1
29	32866	螺钉 (#10-32 x 2.00) 不锈钢	SCREW (#10-32 x 2.00) Stainless Steel	4
30	87775	衬垫	GASKET	1
31	20878	垫圈	WASHER	4
32	826709106	螺母 (#10-32) 不锈钢	NUT (#10-32) Stainless Steel	4
32	8M0204718	螺母	NUT	4
33	45711	O型圈 (.612 x .103)	O-RING (.612 x .103)	1
34	847724	衬套	BUSHING	2
35	54012	垫圈(0.530×0.870×0.105不锈钢)	WASHER (.530 x .870 x .105) Stainless Steel	2
35	8M0204665	垫圈(0.530×0.880×0.104 630不锈钢)	WASHER (.530 x .880 x .104) 630 Stainless Steel	2
36	75275	卡箍	CLAMP	2
37	85020T	枢轴销	PIN Pivot	2
38	847796	调整销	PIN Trim	1
39	847797	固定座	RETAINER	1
40	82671317	螺母(.500-20)	NUT (.500-20)	1
41	54012	垫圈(0.530×0.870×0.105不锈钢)	WASHER (.530 x .870 x .105) Stainless Steel	4
41	8M0204665	垫圈(0.530×0.880×0.104 630不锈钢)	WASHER (.530 x .880 x .104) 630 Stainless Steel	4
42	85022	垫圈(2.00 x 1.06 x 0.060)	WASHER (2.00 x 1.06 x .060)	2
43	8M0050911	升降油缸总成	TRIM CYLINDER ASSEMBLY	1
44	44123	固定座	RETAINER
45	8185163	配平杆	TRIM ROD	1
-	11163A1	配平油缸修理包	REPAIR KIT Trim Cylinder	1
46	NSS	不单独出售刮水器	NOT SOLD SEPARATE WIPER	1
47	NSS	挡圈(不单独销售)	NOT SOLD SEPARATE BACKUP RING	1
48	NSS		NOT SOLD SEPARATE O-RING	1
49	NSS	挡圈(不单独销售)	NOT SOLD SEPARATE BACKUP RING	1
50	NSS		NOT SOLD SEPARATE O-RING	1
51	NSS		NOT SOLD SEPARATE O-RING	1
52	NSS	挡圈(不单独销售)	NOT SOLD SEPARATE BACKUP RING	2
53	NSS		NOT SOLD SEPARATE O-RING	1
54	NSS	黄油孔盖(不单独销售)	NOT SOLD SEPARATE GREASE HOLE COVER	1
55	44125	动力配平活塞	PISTON Power Trim	1

图 31配平泵及安装支架 Trim Pump and Mounting Brackets

REF	零件编号	中文名称	英文名称	数量
1	843017A03	配平泵总成-完整	PUMP ASSEMBLY Trim - Complete	1
2	843017T01	配平泵总成	PUMP ASSEMBLY Trim	1
3	865448A01	油箱盖	CAP Oil Reservoir	1
3	8M0188327	油箱盖	CAP Oil Reservoir	1
4	808727	接头(.50-20 UNF转.4375-24倒角)	CONNECTOR (.50-20 UNF To .4375-24 Inverted Flare)	2
5	818200	接头	FITTING	1
6	861680	绝缘体	INSULATOR	1
7	48409	螺钉 (#10-16 x .625) 不锈钢	SCREW (#10-16 x .625) Stainless Steel	1
8	79139A12	电缆总成红色-正极	CABLE ASSEMBLY Red-Positive	1
9	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	2
10	79023T10	保险丝总成110安培	FUSE ASSEMBLY 110 Ampere	1
11	94275	连接杆	LINK	1
12	25908	垫圈(.265 x .812 x .0625)	WASHER (.265 x .812 x .0625)	1
13	26992	锁紧垫圈(.250)不锈钢	LOCKWASHER (.250) Stainless Steel	1
14	21825	螺母(.250-28)	NUT (.250-28)	1
15	96158T	电磁阀	SOLENOID	2
15	8M0185622	电磁阀	SOLENOID	2
16	826709104	螺母(#8-32)不锈钢	NUT (#8-32) Stainless Steel	4
17	73286	螺钉(0.250-20×0.500)不锈钢	SCREW (.250-20 x .500) Stainless Steel	4
18	826709108	螺母 (.250-20) 不锈钢	NUT (.250-20) Stainless Steel	4
19	846866	支撑架	BRACE	1
20	826709112	螺母(.375-16)不锈钢	NUT (.375-16) Stainless Steel	2
21	79147A09	线束总成	HARNESS ASSEMBLY	1
22	57807	不锈钢螺钉(#10-16 x 0.750)	SCREW (#10-16 x .750) Stainless Steel	2
23	79138A9	电缆总成(6英尺)黑色-负极	CABLE ASSEMBLY (6.00 Feet) Black-Negative	1
24	846673	不锈钢垫圈(.265 x .500 x .060)	WASHER (.265 x .500 x .060) Stainless Steel	1
25	86322A15	电缆总成(5.5英寸)黑色	CABLE ASSEMBLY (5.50 Inches) Black	1
26	86322A24	电缆总成(4英寸)	CABLE ASSEMBLY (4.00 Inches)	1
27	841226001	支架	BRACKET	1
27	8M0192208	泵支架	BRACKET Pump	1
28	844417	螺钉(.375-16 x .875不锈钢)	SCREW (.375-16 x .875) Stainless Steel	4
29	848017A07	升降线束总成	HARNESS ASSEMBLY Trim	1
30	65017A14	线束总成	HARNESS ASSEMBLY	1
31	79146	固定座	RETAINER	2
32	842031T02	倾斜开关套件	SWITCH KIT Tilt	1
-	842109A01	地板安装套件	MOUNT KIT Floor	1
-	87762A04	平衡泵支架总成	BRACKET ASSEMBLY Trim Pump Mounting	1