水星 Mercury 60 2 CYL E-675-00101 THRU E-675-001170 - 爆炸图零件明细

两冲程化油器 · Cat.# 90-83011 · 共 38 个部位 · 1736 条零件

图 1齿轮箱总成 GEARHOUSING ASS'Y

REF	零件编号	中文名称	英文名称	数量
0-1	7122M	齿轮箱总成(短轴)	GEAR HOUSING ASSEMBLY (SHORT SHAFT)	1
0-1	7123M	齿轮箱总成（长轴）	GEAR HOUSING ASSEMBLY (LONG SHAFT)	1
1	7121M	齿轮箱总成	GEAR HOUSING ASSEMBLY	1
2	81924M	堵头	PLUG	3
3	81987M	衬垫	GASKET	3
4	81449M	导向密封件	GUIDE SEAL	1
5	83396M	水泵盖	COVER WATER PUMP	1
6	83403M	嵌件	INSERT	1
7	81426M	密封件	SEAL	1
8	82469M	螺栓	BOLT	2
9	82217M	垫圈	WASHER	4
10	83397M	叶轮	IMPELLER	1
11	83398M	水泵衬垫	GASKET WATER PUMP	1
12	83400M	面板	FACE PLATE	1
13	83399M	水泵衬垫	GASKET WATER PUMP	1
14	83864M	水泵底座	BASE WATER PUMP	1
15	83865M	水泵衬垫	GASKET WATER PUMP	1
16	82275M	O型圈	O-RING	1
17	83406M	油封	SEAL Oil	4
18	83866M	驱动轴(短轴)	DRIVESHAFT (SHORT SHAFT)	1
18	83867M	驱动轴(长轴)	DRIVESHAFT (LONG SHAFT)	1
18	83895M	驱动轴（超长轴）	DRIVESHAFT (SUPER LONG SHAFT)	1
19	83444M	水泵键	KEY WATER PUMP	1
20	82319M	圆锥滚子轴承	BEARING TAPERED ROLLER	1
21	81467M	小齿轮调整垫片（0.05毫米）	SHIM PINION GEAR ADJUST (0.05 MM)	AR
21	81468M	小齿轮调整垫片（0.08毫米）	SHIM PINION GEAR ADJUST (0.08 MM)	AR
21	81469M	小齿轮调整垫片（0.12毫米）	SHIM PINION GEAR ADJUST (0.12 MM)	AR
21	81470M	小齿轮调整垫片（0.30毫米）	SHIM PINION GEAR ADJUST (0.30MM)	AR
21	81471M	小齿轮调整垫片（0.50毫米）	SHIM PINION GEAR ADJUST (0.50 MM)	AR
22	83868M	驱动轴套	SLEEVE DRIVESHAFT	1
23	82316M	滚针轴承	BEARING NEEDLE	1
24	81455M	推力轴承	BEARING THRUST	1
25	83869M	小齿轮	GEAR Pinion GEAR	1
26	81772M	小齿轮螺母	NUT PINION	1
27	81456M	前进齿轮调整垫片（0.05毫米）	SHIM FORWARD GEAR ADJUST (0.05 MM)	AR
27	81457M	前进齿轮调整垫片（0.08毫米）	SHIM FORWARD GEAR ADJUST (0.08 MM)	AR
27	81458M	前进齿轮调整垫片（0.12毫米）	SHIM FORWARD GEAR ADJUST (0.12 MM)	AR
27	81459M	前进齿轮调整垫片（0.30毫米）	SHIM FORWARD GEAR ADJUST (0.30 MM)	AR
27	81460M	前进齿轮调整垫片（0.50毫米）	SHIM FORWARD GEAR ADJUST (0.50 MM)	AR
28	82320M	圆锥滚子轴承	BEARING TAPERED ROLLER	1
29	83877M	前进齿轮	GEAR FORWARD	1
30	83878M	螺旋桨轴	SHAFT PROPELLER	1
31	83419M	凸轮从动件	FOLLOWER Cam	1
32	81475M	换挡滑套	SLIDE SHIFT	1
33	81473M	滑动离合器	CLUTCH SLIDING	1
34	81903M	十字销	PIN CROSS	1
35	81474M	十字销环	RING CROSS PIN	1
36	83429M	压缩弹簧	SPRING COMPRESSION	1
37	81837M	垫圈	WASHER	1
38	83879M	倒车齿轮	GEAR REVERSE	1
39	81462M	倒车齿轮调整垫片（0.05毫米）	SHIM REVERSE GEAR ADJUST (0.05 MM)	AR
39	81463M	倒车齿轮调整垫片（0.08毫米）	SHIM REVERSE GEAR ADJUST (0.08 MM)	AR
39	81464M	倒车齿轮调整垫片（0.12毫米）	SHIM REVERSE GEAR ADJUST (0.12 MM)	AR
39	81465M	倒车齿轮调整垫片（0.30毫米）	SHIM REVERSE GEAR ADJUST (0.30 MM)	AR
39	81461M	倒车齿轮调整垫圈（0.50毫米）	WASHER REVERSE GEAR ADJUST (0.50 MM)	AR
40	81461M	止推垫圈	WASHER THRUST	1
41	83880M	轴承座	CARRIER Bearing	1
42	82296M	球轴承	BEARING BALL	1
43	82289M	O型圈	O-RING	1
44	81916M	键	KEY	1
45	82317M	滚针轴承	BEARING NEEDLE	1
46	81877M	爪形垫圈	WASHER CLAW	1
47	81450M	螺母	NUT	1
48	83881M	换挡凸轮（短轴）	SHIFT CAM (SHORT SHAFT)	1
48	83882M	换挡凸轮（长轴）	SHIFT CAM (LONG SHAFT)	1
48	83902M	换挡凸轮（超长轴）	SHIFT CAM (SUPER LONG SHAFT)	1
49	83883M	换挡凸轮衬套	BUSHING SHIFT CAM	1
50	82451M	螺栓	BOLT	1
51	82214M	垫圈	WASHER	1
52	82881M	换挡杆护套	BOOT SHIFT ROD	1
53	81767M	螺母	NUT	1
54	80652M	换挡杆连接器	CONNECTOR SHIFT ROD	1
55	83857M	堵头	PLUG	1
56	82468M	螺栓	BOLT	2
57	82354M	定位销	PIN DOWEL	2
58	83860M	螺栓	BOLT	1
59	82218M	锁紧垫圈	LOCKWASHER	1
60	83392M	螺钉	SCREW	1
61	81986M	衬垫	GASKET	1
62	82465M	螺栓	BOLT	6
63	82215M	锁紧垫圈	LOCKWASHER	6
64	81448M	密封件	SEAL	1
65	81443M	进水口盖	COVER WATER INLET	1
66	81444M	进水口盖	COVER WATER INLET	1
67	83858M	螺钉	SCREW	1
68	81781M	螺母	NUT	1
69	83859M	平衡鳍板	TRIM TAB	1
70	83862M	安装板	PLATE	1
71	83861M	衬垫	GASKET	1
72	83870M	螺钉	SCREW	2
73	83451M	水管（短轴）	TUBE WATER (SHORT SHAFT)	1
73	83452M	水管（长轴）	TUBE WATER (LONG SHAFT)	1
73	83903M	水管（超长轴）	TUBE Water WATER (SUPER LONG SHAFT)	1
74	81852M	垫圈	WASHER	1
75	81989M	O型圈	O-RING	1
76	81427M	密封件	SEAL	1
77	73345	止推垫片	THRUST WASHER	1
78	81775M	螺旋桨螺母	NUT PROPELLER	1
79	84428M	开口销	PIN COTTER	1
80	83884M	水泵套件-镀铬	PUMP KIT Water - Chrome	1
81	83448M	面板	FACE PLATE	1
82	83449M	嵌件	INSERT	1
83	83450M	滤芯内板	INNER PLATE CARTRIDGE	1
84	80218M	堵头	PLUG	1
-	84362M	衬垫套件	GASKET SET	1
-	84363M	维修套件	REPAIR KIT	1

图 2点火系统 IGNITION SYSTEM

REF	零件编号	中文名称	英文名称	数量
-	819155A2	定子总成(完整)	STATOR ASSEMBLY (COMPLETE)	1
1	819155T	定子板	PLATE Stator	1
2	850899T1	点火模块套件	MODULE KIT Ignition	3
3	830865	连接器(仅维修用)	CONNECTOR (SERVICE ONLY)	AR
3	8M0204694	连接器	CONNECTOR	AR
4	824353	螺钉(#8-32 X .750)-点火模块安装	SCREW (#8-32 X .750)-IGN MODULE MOUNT	9
5	12479A60	模块到线束电缆总成	CABLE ASSEMBLY Modules To Harness	1
6	63709A1	护套/端子套件	BOOT/TERMINAL KIT	3
7	20117A1	点火电缆标记套件(#1)(#2)(#3)	MARKER SET Ignition Cables (#1) (#2) (#3)	1
8	F681091	专用螺母-飞轮	NUT (SPECIAL)-FLYWHEEL	1
9	824380T3	飞轮	FLYWHEEL	1
9	824380T4	飞轮	FLYWHEEL	1
10	824440A6	停机开关总成	SWITCH ASSEMBLY Stop	1
10	824440A14	停机开关总成	SWITCH ASSEMBLY Stop	1
11	824466A3	停机开关盖总成	COVER ASSEMBLY Stop Switch	1
12	824915	停机开关盖饰圈	BEZEL Stop Switch Cover	1
13	826214A1	紧急停止开关总成	SWITCH ASSEMBLY Emergency Stop	1
14	F681188	专用螺母-停机开关套筒	NUT (SPECIAL)-STOP SWITCH SLEEVE	1
14	855594	螺母	NUT	1
15	819399A1	拉绳总成	LANYARD ASSEMBLY	1
15	879104	带夹子的拉绳	LANYARD W/CLIP	1
16	F458498-1	曲轴/飞轮键	KEY Crankshaft/Flywheel	1
17	8278961	节气门凸轮	CAM Throttle	1
18	821375A44	接地线总成	CABLE ASSEMBLY Ground	1
19	56762	扎带(4.00英寸)	TIE STRAP (4.00 Inches)	AR
19	816311	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	AR
19	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	AR
20	824358	螺钉(#10-24 x .500)(#10-24 X .500)-定子板	SCREW (#10-24 x .500) (#10-24 X .500)-STATOR PLATE	5
21	811	火花塞(CHAMPION # L82C)	SPARK PLUG (CHAMPION # L82C)	3
21	896323	SP #L82C @4	SP #L82C @4	3
21	874	火花塞(RFI)(CHAMPION # RL82C)	SPARK PLUG (RFI) (CHAMPION # RL82C)	OPT
21	896329874	SP #RL82C @4	SP #RL82C @4	OPT
22	79138A93	发动机停机线束总成	HARNESS ASSEMBLY Engine Stop	1
23	13541	公插头	PLUG Male	1
24	831275	卡箍	CLAMP	1

图 3电动启动电机 ELECTRIC STARTER MOTOR

REF	零件编号	中文名称	英文名称	数量
1	97693M	启动电机总成	STARTER MOTOR ASSEMBLY	1
2	96360M	小齿轮止动器套件	STOPPER KIT Pinion	1
3	97694M	小齿轮	PINION	1
3	97694T	小齿轮	PINION	1
4	96362M	盖板	COVER	1
5	96363M	O型圈	O-RING	2
6	96364M	垫圈套件	WASHER KIT	1
7	96365M	电枢	ARMATURE	1
8	96366M	定子	STATOR	1
9	96368M	正极电刷	BRUSH ( + )	1
10	96367M	电刷架	HOLDER Brush	1
11	96369M	负极电刷	BRUSH ( - )	1
12	84927M	电刷弹簧	SPRING BRUSH	2
14	84929M	螺栓	BOLT	2
13	96370M	盖板	COVER	1
15	96371M	螺栓	BOLT	1
16	82202M	垫圈	WASHER	1
16	82217M	垫圈	WASHER	1
17	97695M	支架	BRACKET	1
17	97695T	支架	BRACKET	1
18	42762M	螺栓	BOLT	2
19	82214M	垫圈	WASHER	2
20	95642M	电磁阀	SOLENOID	1
20	825096T01	启动电磁阀	SOLENOID Starter	1
20	96357M	电磁阀	SOLENOID	1
20	96357T	电磁阀	SOLENOID	1
21	95643M	继电器支架	BRACKET RELAY	1
21	8M0010250	支架	BRACKET	1
21	84934M	继电器支架	BRACKET RELAY	1
22	97696M	导线	WIRE LEAD	1
23	97697M	开关安装板	PLATE SWITCH FITTING	1
24	97698M	继电器支架	BRACKET RELAY	1
25	84247M	螺栓	BOLT	2
25	826957M	螺栓	BOLT	2
26	82441M	螺栓	BOLT	3

图 4安装系统 MOUNTING SYSTEM

REF	零件编号	中文名称	英文名称	数量
1	95548M	支架	BRACKET	1
2	84838M	橡胶密封件	SEAL RUBBER	1
3	84840M	橡胶密封件	SEAL RUBBER	1
4	81930M	衬套	BUSHING	2
5	82369M	黄油嘴	FITTING GREASE	1
6	81439M	管帽接头	CAP FITTING	1
7	84839M	螺栓	BOLT	4
8	82214M	垫圈	WASHER	3
9	80657M	支架	BRACKET	1
10	82364M	定位销	PIN Dowel DOWEL	1
11	82451M	螺栓	BOLT	1
11	82423M	螺栓	BOLT	1
12	82217M	垫圈	WASHER	4
13	84841M	上部前支架	MOUNT UPPER FRONT	1
14	84058M	螺栓 (M6 x 20)	BOLT (M6 x 20)	2
15	80662M	安装垫片	GASKET MOUNT	3
16	82219M	垫圈	WASHER	3
17	82395M	螺母	NUT	1
18	82557M	上部侧支架	MOUNT UPPER SIDE	2
18	8M0121332	支架	MOUNT	2
19	81612M	安装垫片	GASKET MOUNT	2
20	82396M	冠形螺母	NUT CROWN	2
21	84842M	下部壳体	HOUSING LOWER	1
22	84843M	下部壳体	HOUSING LOWER	1
23	84844M	螺栓	BOLT	2
24	41893M	螺栓	BOLT	2
25	82392M	螺母	NUT	4
25	82382M	螺母	NUT	4
26	84846M	下部前支架	MOUNT LOWER FRONT	1
27	82464M	螺栓	BOLT	2
27	43106M	螺栓	BOLT	2
28	84848M	下部侧支架	MOUNT LOWER SIDE	2
29	84847M	下安装盖	COVER LOWER MOUNT	1
30	82395M	螺母	NUT	2

图 5燃油泵 FUEL PUMP

REF	零件编号	中文名称	英文名称	数量
1	880890T1	燃油泵	PUMP Fuel	1
2	NSS	不单独销售本体	NOT SOLD SEPARATE Body	1
3	881544	弹簧	SPRING	1
4	881545	柱塞	PLUNGER	1
5	881546	弹簧	SPRING	1
6	881547	隔膜	DIAPHRAGM	1
7	881548	销	PIN	1
8	NSS	不单独销售本体	NOT SOLD SEPARATE Body	1
9	NSS	膜片(不单独销售)	NOT SOLD SEPARATE Diaphragm	1
10	NSS	不单独销售本体	NOT SOLD SEPARATE Body	1
11	881550	螺钉	SCREW	3
12	881333	螺母	NUT	3
13	804255	O型圈	O-RING	1
13	8M0050719	O型圈	O-RING	1
14	879650	卡箍	CLAMP	2
14	56762	扎带(4.00英寸)	TIE STRAP (4.00 Inches)	2
15	804256	螺栓 (M6 x 30)	BOLT (M6 x 30)	2
16	881543	软管	HOSE	1
16	881543002	油管	TUBING	1
17	881542	支架	BRACKET	1
18	8527768	螺栓(M6 x 16)	BOLT (M6 x 16)	1
18	811188T	螺栓	BOLT	1
19	8528161	螺母	NUT	1
19	82382M	螺母	NUT	1
20	881538T1	滤清器总成	FILTER ASSEMBLY	1
20	881538T02	燃油滤清器总成	FILTER ASSY-FUEL	1
21	881540	滤芯1.75英寸	ELEMENT 1.75 Inches	1
21	8M0168897	燃油滤清器	FUEL FILTER	1
21	8M0101436	滤芯1.50英寸	ELEMENT 1.50 Inches	1
21	8M0117705	燃油滤清器	FILTER-FUEL	1
22	826966M	O型圈	O-RING	1
22	826966T	O型圈	O RING	1
23	881541	浮子	FLOAT	1
24	881539	杯套	CUP	1
24	8M0101437	杯套	CUP	1
24	8M0137185	燃油杯	CUP FUEL	1
25	879650	卡箍	CLAMP	2
25	56762	扎带(4.00英寸)	TIE STRAP (4.00 Inches)	2
26	804260	支架	BRACKET	1
27	804112	螺栓(M7 x 48)	BOLT (M7 x 48)	2
28	804113	定位销	PIN Dowel	2
29	84292M	垫圈	WASHER	2
30	804257	燃油转换杆	LEVER Fuel Change	1
31	881334	轴	SHAFT	1
32	804259	销	PIN	2
32	82738M	滚销	PIN-ROLL	2
33	830757130	管材(.312)(70英寸整卷)裁切至55英寸长度	TUBING (.312) (70.00 Inches Bulk) Cut to 55.00 Inch Length.	1
33	8M0108349	软管 (70英寸散装)	HOSE (70 Inches Bulk)	1
34	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	1
35	822769	连接器	CONNECTOR	1
36	NSS	盖帽(不单独销售)	NOT SOLD SEPARATE Cap	1
37	828547T1	导管(.500内径 x 3英尺整卷)	CONDUIT (.500 Inside Diameter x 3.00 Feet Bulk)	1
-	858732T01	衬垫套件	GASKET SET	1
-	858732T02	动力头衬垫套件	GASKET SET Powerhead	1
-	858732T02	动力头衬垫套件	GASKET SET Powerhead	1
-	881310T1	气缸盖总成	CYLINDER HEAD ASSEMBLY	1
-	881310T09	气缸盖	HEAD-CYLINDER	1

图 6换挡联动装置 GEAR SHIFT LINKAGE

REF	零件编号	中文名称	英文名称	数量
1	81066M	换挡手柄	GEAR SHIFT HANDLE	1
2	82155M	销	PIN	1
3	81068M	轴	SHAFT	1
4	82348M	钢球	BALL	1
5	82084M	弹簧	SPRING	1
6	81061M	衬套	BUSHING	1
7	814496M	O型圈	O-RING	2
8	83094M	衬套	BUSHING	1
9	82447M	螺栓	BOLT	1
10	82186M	垫圈	WASHER	1
11	81390M	换挡轴杆	LEVER Shift Shaft	1
12	82213M	垫圈	WASHER	1
13	82125M	开口销	COTTER PIN	1
14	82680M	换挡连杆	SHIFT ROD	1
15	80049M	连接器	CONNECTOR	1
16	80050M	连接器	CONNECTOR	1
17	84058M	螺栓 (M6 x 20)	BOLT (M6 x 20)	1
18	881379	垫圈	WASHER	1
18	82214M	垫圈	WASHER	1

图 7进气歧管 INTAKE MANIFOLD

REF	零件编号	中文名称	英文名称	数量
1	94733M	进气盖(外)	COVER Air Intake (OUTER)	1
2	94734M	进气盖(内)	COVER Air Intake (INNER)	1
3	83108M	螺钉	SCREW	2
4	82211M	垫圈	WASHER	2
5	94765M	轴环	COLLAR	2
6	83287M	阻风门旋钮	KNOB Choke	1
7	80231M	护孔环	GROMMET	1
8	80245M	螺母	NUT	1
9	16333	卡扣拉杆	ROD Snap	1
10	94754M	连杆总成	LINK ASSEMBLY	1
11	82207M	垫圈	WASHER	1
12	91772M	螺栓	BOLT	1
13	82933M	垫圈	WASHER	1
14	82050M	开口销	COTTER PIN	2
15	94755M	连杆	LINK ROD	1
16	94753M	连杆	LINK ROD	1
17	82390M	螺母 (M6)	NUT (M6)	2
18	82214M	垫圈	WASHER	5
19	80734M	衬垫	GASKET	1
20	82423M	螺栓	BOLT	2
21	94766M	螺栓	BOLT	1
22	80232M	螺柱	STUD	1
23	81729M	螺柱	STUD	1
24	83244M	衬垫	GASKET	1
25	94750M	簧片阀总成	REED VALVE ASSEMBLY	1
26	94752M	簧片组	REED SET	1
-	95600M	动力头衬垫套件	GASKET SET Powerhead	1
-	94756M	化油器维修套件	REPAIR KIT Carburetor	1
-	827167M	动力头总成	POWERHEAD ASSEMBLY	1

图 8驱动轴壳体 DRIVESHAFT HOUSING

REF	零件编号	中文名称	英文名称	数量
1	858576T03	驱动轴壳体总成	HOUSING ASSEMBLY Driveshaft	1
2	903501	双头螺柱(M10×100)	STUD (M10 x 100)	1
2	9035015	双头螺柱(M10×227)	STUD (M10 x 227)	1
3	9035012	双头螺柱(M10×63)	STUD (M10 x 63)	4
3	9035016	双头螺柱(M10×190)	STUD (M10 x 190)	4
3	8M0034462	双头螺柱(M10×190)	STUD (M10 x 190)	4
4	856774	垫圈(0.406×0.750×0.105)不锈钢	WASHER (.406 x .750 x .105) Stainless Steel	5
4	8M0214963	垫圈	WASHER	5
5	40140	螺母(M10)	NUT (M10)	5
6	85822A15	速度计传感器总成	PICKUP ASSEMBLY Speedometer	1
7	43335	90度接头(.125-27)尼龙	CONNECTOR 90 Degree (.125-27) Nylon	1
7	433351	90度接头-带防振密封	CONNECTOR 90 Degree - With Vibraseal	1
8	85822	直通接头	CONNECTOR Straight	1
8	85822T	直通接头	CONNECTOR Straight	1
9	44343T1	支架	MOUNT	2
10	42973	螺栓(M12×154)	BOLT (M12 x 154)	2
10	898835001	螺钉(M12 x 154)	SCREW (M12 x 154)	2
11	30119	垫圈(外径0.875英寸)	WASHER (.875 Inch Outside Diameter)	2
12	43528	螺母(M12)	NUT (M12)	2
12	8M0204662	螺母	NUT	2
13	88238A10	接地线总成	CABLE ASSEMBLY Ground	2
14	41508	螺钉(0.250-20×0.500)不锈钢	SCREW (.250-20 x .500) Stainless Steel	1
15	858916T	卡箍	CLAMP	2
16	4010725	螺钉 (M8 x 25)	SCREW (M8 x 25)	4
17	858745	盖帽	CAP	4
17	8M0142713	支撑盖帽	CAP Chap Support	4
18	859550	衬套	BUSHING	1
19	24873	定位销	PIN Alignment	1
20	855622	接头	FITTING	1
21	12092A3	隔套套件	SPACER KIT	1
22	43043	定位销-带孔(0.375×0.625)	PIN Dowel - With Hole (.375 x .625)	1
22	8M0084244	定位销 0.375x0.620	PIN Dowel, .375 x .620	1
22	43044	定位销-无孔(.375 x .625)	PIN Dowel - Without Hole (.375 x .625)	1
23	813745	隔套	SPACER	1
24	816311T	捆扎带 (8.00英寸)	TIE STRAP (8.00 Inches)	2

图 9化油器 CARBURETOR

REF	零件编号	中文名称	英文名称	数量
1	821679A17	化油器	CARBURETOR	1
1	821679A18	化油器	CARBURETOR	1
1	821679T18	化油器	CARBURETOR	1
1	821679A19	化油器	CARBURETOR	1
1	821679T19	化油器	CARBURETOR	1
1	821946A24	化油器	CARBURETOR	1
1	821946A45	化油器维修包	CARBURETOR KIT	1
1	821946A25	化油器	CARBURETOR	1
1	821946A46	化油器维修包	CARBURETOR KIT	1
1	821946A26	化油器	CARBURETOR	1
1	821946A47	化油器维修包	CARBURETOR KIT	1
1	821946A27	化油器	CARBURETOR	1
1	821946T42	化油器	CARBURETOR	1
1	821946A28	化油器	CARBURETOR	1
1	821946T43	化油器	CARBURETOR	1
1	821946A29	化油器	CARBURETOR	1
1	821946T44	化油器	CARBURETOR	1
2	823634	螺丝(上/下部)	SCREW (UPPER/BOTTOM)	2
3	823632	油门轴	SHAFT Throttle	1
4	823633	油门轴	SHAFT Throttle	1
4	823636	油门轴	SHAFT Throttle	1
3	823632	节气门轴(上/下部)	SHAFT Throttle (UPPER/BOTTOM)	2
4	823633	节气门轴(中央)	SHAFT Throttle (CENTER)	1
5	NSS	不单独销售油门回位弹簧	NOT SOLD SEPARATE SPRING-THROTTLE RETURN	3
6	6247	主量孔(0.090)	JET Main (.090)	3
7	NSS	不单独销售怠速针	NOT SOLD SEPARATE IDLE NEEDLE	3
8	NSS	不单独销售怠速针弹簧	NOT SOLD SEPARATE SPRING-IDLE NEEDLE	3
9	NSS	不单独销售盖板衬垫	NOT SOLD SEPARATE GASKET-COVER PLATE	3
10	811221	盖板	COVER PLATE	3
11	811220	盖板螺丝	SCREW Cover Plate	6
12	8144461	法兰衬垫	GASKET Flange	3
13	8113522	油泵杠杆(WME43/45-底部)	LEVER Oil Pump (WME43/45 - BOTTOM)	1
14	8086121	杠杆固定螺钉(WME43/45-底部)	SCREW Lever Retainer (WME43/45 - BOTTOM)	1
15	F10155	节气门螺丝	SCREW Throttle Valve	6
16	879194023	节气门阀	VALVE-THROTTLE	3
17	NSS	不单独销售挡圈	NOT SOLD SEPARATE RETAINING RING	3
18	F10064	轴	SHAFT	3
19	NSS	不单独销售喷油嘴衬垫	NOT SOLD SEPARATE GASKET-NOZZLE WELL	3
20	NSS	不单独销售燃油杯衬垫	NOT SOLD SEPARATE GASKET-FUEL BOWL	3
21	879194011	进油阀	VALVE Inlet	3
22	9594	浮子	FLOAT	3
23	808612	螺钉及垫圈 (#8-32 x .750)	SCREW AND WASHER (#8-32 x .750)	12
24	811695	燃油杯	BOWL Fuel	1
24	811693	燃油杯	BOWL Fuel	2
25	811694	塞套件	PLUG KIT	3
26	NSS	排水碗密封件(不单独销售)	NOT SOLD SEPARATE SEAL-BOWL DRAIN	3
27	6246	量孔(.048)	JET (.048)	3
27	6487	主量孔(0.060)	JET Main (.060)	3
27	4217	主量孔(.062)	JET Main (.062)	3
-	812867A97	衬垫套件	GASKET SET	1
-	8236354	化油器维修套件	REPAIR KIT Carburetor	1
-	8112231	化油器衬垫组	GASKET SET Carburetor	1

图 10外罩 COWLING

REF	零件编号	中文名称	英文名称	数量
1	7938	顶罩总成(无标贴)	TOP COWL ASSEMBLY Without Decal	1
1	7937A8	顶罩总成(无标贴)	TOP COWL ASSEMBLY Without Decal	1
1	7938F4	顶罩总成(无标贴)	TOP COWL ASSEMBLY Without Decal	1
1	7937F4	顶罩总成(无标贴)	TOP COWL ASSEMBLY Without Decal	1
2	55455		HOOK Top Cowl Latch - Rear	1
3	22956		SCREW (.250-28 x .880) Rear Hook to Top Cowl	2
4	26992		LOCKWASHER (.250) Stainless Steel Rear Hook Screw	2
5	37690	顶罩后护板	SHIELD Rear - Top Cowl	1
6	48409		SCREW (#10-16 x .625) Stainless Steel Rear Shield to Top Cowl	3
7	97447A1	顶罩固定架总成	RETAINER ASSEMBLY Top Cowl	1
8	53167	顶罩固定架螺丝(.312-18 x .880)	SCREW (.312-18 x .880) Retainer to Top Cowl	1
8	53167T	螺钉 0.312-18X 0.88	SCREW .312-18X .88	1
9	39107	固定架螺丝锁紧垫圈(.312-24)	LOCKWASHER (.312-24) Retainer Screw	1
10	94918T	罩盖锁扣铰链杆	LEVER Cowl Latch Hinge	1
10	94918F1	杠杆	LEVER	1
11	52739T	顶罩锁扣铰链	HINGE Cowl Latch-Top Cowl	1
11	52739	铰链	HINGE	1
12	58998	罩盖锁扣杆铰链销	PIN Cowl Latch Lever to Hinge	1
13	7927A5	水星前盖板(无标贴)	FRONT COVER MERCURY Without Decal	1
13	7927A19	马琳前盖板(无标贴)	FRONT COVER MARINER Without Decal	1
14	56849	前盖板旋钮	KNOB Cowl Front Cover	1
15	30771	盖板旋钮垫圈	WASHER Cover Knob	1
16	59572	盖板旋钮垫圈	WASHER Cover Knob	2
17	30772	盖板旋钮张力弹簧	SPRING Tension - Cover Knob	1
18	29077	旋钮张力弹簧销	PIN Roll Tension Spring to Knob	1
19	38674	隔音毯	BLANKET Sound	1
20	94923	隔音垫	PAD Sound	2
21	3247A3	水星环绕式顶罩总成(无标贴)	TOP COWL ASSEMBLY Wrap Around - Mercury Without Decal	1
21	8181A4	马琳环绕式顶罩总成(无标贴)	TOP COWL ASSEMBLY Wrap Around - Mariner Without Decal	1
22	46785A1	罩壳锁扣总成	LATCH ASSEMBLY Cowl	2
23	30413	罩盖锁钩	HOOK Cowl Latch	2

图 11曲轴与活塞 CRANKSHAFT AND PISTON

REF	零件编号	中文名称	英文名称	数量
1	91531	曲轴总成	CRANKSHAFT ASSEMBLY	1
1	91531	曲轴总成	CRANKSHAFT ASSEMBLY	1
1	879147T16	曲轴总成	CRANKSHAFT ASSY	1
1	822892	曲轴总成	CRANKSHAFT ASSEMBLY	1
1	822892T02	曲轴总成	CRANKSHAFT ASSY	1
2	NSS	曲轴不单独销售	NOT SOLD SEPARATE Crankshaft	1
3	NSS	曲轴不单独销售	NOT SOLD SEPARATE Crankshaft	1
4	813269	连杆	CONNECTING ROD	1
5	813270	轴承	BEARING	1
6	813271	曲轴销	PIN Crank	1
6	813271001	曲轴销-TH	CRANK PIN-TH	1
7	95227	滚柱轴承	BEARING Roller	1
8	95229	键	KEY	1
9	95228	滚珠轴承	BEARING Ball	1
9	898101936	轴承	BEARING	1
10	95230	安装板	PLATE	1
11	95232	油封	SEAL Oil	1
12	95307	滚珠轴承	BEARING Ball	1
12	95307	滚珠轴承	BEARING Ball	1
12	822894	滚珠轴承	BEARING Ball	1
13	95308	油封	SEAL Oil	1
13	95308	油封	SEAL Oil	1
13	822897	油封	SEAL Oil	1
14	822896	下部推力板	THRUST PLATE Lower	1
15	9154A01	完整活塞总成	PISTON ASSEMBLY Complete	1
15	8M0103754	活塞总成	PISTON ASSY	1
15	9183A01	完整活塞总成	PISTON ASSEMBLY Complete	1
15	8M0103753	活塞总成	PISTON ASSY	1
15	9154	活塞	PISTON	1
15	9154A01	完整活塞总成	PISTON ASSEMBLY Complete	1
15	9183	活塞	PISTON	AR
16	95234	活塞环	RING Piston	1
16	95309	活塞环	RING Piston	AR
17	95235	活塞销	PIN Piston	1
17	898101917	活塞销	PIN-PISTON	1
18	952366	卡扣	CLIP	2
-	95220A5	动力头衬垫套件	GASKET SET Powerhead	1
-	898101928	衬垫套装-PH	GASKET SET-PH	1
-	95220A5	动力头衬垫套件	GASKET SET Powerhead	1
-	898101928	衬垫套装-PH	GASKET SET-PH	1
-	815076A2	动力头衬垫套件	GASKET SET Powerhead	1
-	8M0203727	衬垫套件 P/H	GASKET SET P/H	1

图 12动力微调 POWER TRIM

REF	零件编号	中文名称	英文名称	数量
1	8251123	倾斜挡块	STOP Tilt	1
1	8251124	倾斜挡块	STOP Tilt	1
1	8251123	倾斜挡块	STOP Tilt	1
2	16208	握把	GRIP	1
2	16207A3	倾斜止动套件	TILT STOP KIT	1
3	9528616	轴环	COLLAR	2
4	82304216	螺栓	BOLT	2
4	8M0062251	螺栓	BOLT	2
5	168261	垫圈	WASHER	2
6	953837	弹簧	SPRING	1
7	851873A1	动力升降总成	POWER TRIM ASSEMBLY	1
8	851874	上气缸销	PIN Upper Cylinder	1
8	8M0115482	气缸销	PIN-CYLINDER	1
9	8113682	套筒	SLEEVE	2
10	161765	衬套	BUSHING	2
11	16223	螺栓(M6x14)	BOLT (M6 x 14)	1
12	16238	垫圈	WASHER	1
12	898101937	垫圈	WASHER	1
13	8518741	下气缸销	PIN Lower Cylinder	1
14	9528617	轴环	COLLAR	1
15	8113682	套筒	SLEEVE	2
16	161766	衬套	BUSHING	2
16	16176011	衬套	BUSHING	2
17	85372219	螺母	NUT	2
18	8518681	垫圈	WASHER	4
18	8M0060184	垫圈	WASHER	4
19	17169	卡箍	CLAMP	1
20	8555445	螺钉	SCREW	1

图 13曲轴箱和气缸盖 CRANKCASE AND CYLINDER HEAD

REF	零件编号	中文名称	英文名称	数量
1	827168M	曲轴箱	CRANKCASE	1
2	80727M	止回阀总成	CHECK VALVE ASSEMBLY	1
3	84661M	放油接头	FITTING Drain	1
4	83326M	接头	FITTING	1
5	80122M	接头	FITTING	1
6	811045M	软管	HOSE	1
7	82012M	软管	HOSE	1
8	82046M	卡箍	CLAMP	2
9	98974M	卡扣	CLIP	2
10	82359M	定位销	PIN Dowel	2
11	95592M	螺栓	BOLT	8
12	95593M	螺栓	BOLT	2
13	11919M	节温器	THERMOSTAT	1
13	11919001	节温器	THERMOSTAT	1
14	14214M	定位销	PIN Dowel	1
15	84732M	阳极块	ANODE	1
16	95594M	螺钉	SCREW	1
17	8213M	气缸盖	CYLINDER HEAD	1
18	95595M	衬垫	GASKET	1
18	95595	衬垫	GASKET	1
19	43092M	螺栓(M6x14)	BOLT (M6 x 14)	13
20	804124	螺栓	BOLT	10
21	95598M	排气外盖	COVER Exhaust (OUTER)	1
22	83241M	盖板	COVER	1
23	83242M	衬垫	GASKET	1
23	83242	衬垫	GASKET	1
24	82405M	螺栓	BOLT	1
25	82214M	垫圈	WASHER	14
26	95596M	排气内盖	COVER Exhaust (INNER)	1
27	95597	衬垫	GASKET	2
28	826957M	螺栓	BOLT	1
29	14262M	螺栓	BOLT	2
30	814493M	下壳体	HOUSING (LOWER)	1
31	94762M	密封件	SEAL	1
32	826957M	螺栓	BOLT	2
33	881379	垫圈	WASHER	2
33	82214M	垫圈	WASHER	2
34	82165M	油封	SEAL Oil	1
35	18843M	油封	SEAL Oil	1
36	95602M	O型圈	O-RING	1
37	81841M	垫圈	WASHER	1
38	14195M	油封	SEAL Oil	1
39	82276M	O型圈	O-RING	1
40	83246M	上壳体	HOUSING (UPPER)	1
41	852776	螺栓	BOLT	4
42	881379	垫圈	WASHER	4
42	82214M	垫圈	WASHER	4
-	827167M	动力头总成	POWERHEAD ASSEMBLY	1
-	95600M	动力头衬垫套件	GASKET SET Powerhead	1

图 14倒挡锁 REVERSE LOCK

REF	零件编号	中文名称	英文名称	数量
1	84664M	倾斜杆	LEVER Tilt	1
2	82090M	弹簧	SPRING	1
3	84665M	倾斜锁定杆	TILT LOCK ROD	1
4	84666M	销	PIN	1
5	82327M	卡簧	CIRCLIP	1
6	80519M	倾斜止动杆总成	LEVER ASSEMBLY Tilt Stop	1
7	80100M	倾斜旋钮	TILT KNOB	1
8	80097M	衬套	BUSHING	2
9	82111M	弹簧	SPRING	1
10	82110M	弹簧	SPRING	1
11	80976M	支架	BRACKET	1
12	82405M	螺栓	BOLT	2
13	881379	垫圈	WASHER	2
13	82214M	垫圈	WASHER	2
14	80522M	安装板	PLATE	1
15	82097M	弹簧	SPRING	2
16	80525M	停机开关	STOP	2
17	80521M	倾斜锁臂	TILT LOCK ARM	2
18	80523M	安装板	PLATE	2
19	81883M	销	PIN	1
20	82051M	开口销	COTTER PIN	1
21	82112M	弹簧	SPRING	1
22	80527M	轴	SHAFT	1
23	82049M	开口销	COTTER PIN	2
24	811016M	倾斜销总成	PIN ASSEMBLY Tilt	1
25	82857M	止动板	PLATE Stopper	1
26	82144M	销	PIN	1
27	815007M	弹簧	SPRING	1

图 15夹紧旋转支架 CLAMP AND SWIVEL BRACKET

REF	零件编号	中文名称	英文名称	数量
1	9256M	旋转支架	SWIVEL BRACKET	1
2	80520M	旋转支架（后）	SWIVEL BRACKET (REAR)	1
3	827043M	螺栓	BOLT	4
4	881379	垫圈	WASHER	4
4	82214M	垫圈	WASHER	4
5	81065M	盖板	COVER	1
6	14265M	铆钉	RIVET	4
7	82889M	支架	BRACKET	1
8	82890M	摩擦片	FRICTION PLATE	1
9	82891M	摩擦片	FRICTION PLATE	1
10	82892M	盖板	COVER	1
11	81055M	螺钉	SCREW	1
12	81056M	衬套	BUSHING	4
13	95605M	衬套	BUSHING	2
14	80513T	衬套	BUSHING	2
15	82369M	接头	FITTING	1
16	821596A1	左舷夹紧支架总成	CLAMP BRACKET ASSEMBLY Port	1
17	9834M	右舷夹紧支架	CLAMP BRACKET Starboard	1
18	19247M	螺栓	BOLT	1
19	811270M	安装板	PLATE	1
20	98970M	垫圈	WASHER	2
21	81785M	锁紧螺母	LOCKNUT	1
22	82921M	螺栓	BOLT	1
23	82116M	隔套	SPACER	1
24	82214M	垫圈	WASHER	1
25	8528163	螺母	NUT	1
26	81755M	螺钉	SCREW	2
27	80638M	垫	PAD	2
28	11868M	手柄	HANDLE	2
29	81889M	销	PIN	2

图 16节气门控制器 THROTTLE CONTROL

REF	零件编号	中文名称	英文名称	数量
1	82490M	底座固定螺钉	SCREW BASE ATTACHING	3
2	82211M	垫圈	WASHER	3
3	81581M	磁电机控制凸轮	CAM MAGENTO CONTROL	1
3	81581T	杠杆	LEVER	1
4	83310M	轴环	COLLAR	1
5	81969M	垫圈	WASHER	1
6	82405M	螺栓	BOLT	1
7	81563M	节气门拉线支架	BRACKET THROTTLE CABLE	1
8	84303M	螺栓	BOLT	1
8	91772M	螺栓	BOLT	1
9	81225M	端盖	END	3
9	16715M	接头	JOINT	3
10	81582M	磁电机控制连杆	LINK ROD MAGNETO CONTROL	1
11	80629M	旋转连杆	SWIVEL LINK ROD	1
12	81789M	垫圈	WASHER	1
13	82378M	螺母	NUT	3
13	82388M	螺母 (M5)	NUT (M5)	3
14	41890M	节流阀轴杆	LEVER THROTTLE SHAFT	1
15	81134M	节流阀轴	SHAFT THROTTLE	1
16	81946M	衬套	BUSHING	2
17	82156M	滚销	PIN ROLL	1
18	81722M	连杆	LINK ROD	1
19	83539M	螺栓 (M6 x 20)	BOLT (M6 x 20)	2
19	84058M	螺栓 (M6 x 20)	BOLT (M6 x 20)	2
20	82214M	垫圈	WASHER	4
21	96378M	磁电机底座止动件	STOP MAGNETO BASE	1
22	83539M	螺栓 (M6 x 20)	BOLT (M6 x 20)	4
22	84058M	螺栓 (M6 x 20)	BOLT (M6 x 20)	4
23	82380M	螺母	NUT	2
23	82389M	螺母	NUT	2
24	92572M	摩擦片	PLATE FRICTION	1
25	92573M	磁电机底座护圈(上部)	RETAINER MAGNETO BASE (UPPER)	1
26	96379M	磁电机底座护圈	RETAINER MAGNETO BASE	1

图 17化油器 CARBURETOR

REF	零件编号	中文名称	英文名称	数量
1	821854A7	化油器	CARBURETOR	1
1	821854T22	化油器 (WME 95-1)	CARBURETOR (WME 95-1)	1
1	821854A8	化油器	CARBURETOR	1
1	821854T23	化油器 (WME 95-2)	CARBURETOR (WME 95-2)	1
1	821854A9	化油器	CARBURETOR	1
1	821854T24	化油器 (WME 95-3)	CARBURETOR (WME 95-3)	1
1	821854A4	化油器	CARBURETOR	1
1	821854T19	化油器 (WME 94-1)	CARBURETOR (WME 94-1)	1
1	821854A5	化油器	CARBURETOR	1
1	821854T20	化油器 (WME 94-2)	CARBURETOR (WME 94-2)	1
1	821854A6	化油器	CARBURETOR	1
1	821854T21	化油器 (WME 94-3)	CARBURETOR (WME 94-3)	1
2	823632	油门轴	SHAFT Throttle	1
3	823633	油门轴	SHAFT Throttle	1
4	823636	油门轴	SHAFT Throttle	1
2	823632	油门轴	SHAFT Throttle	2
3	823633	油门轴	SHAFT Throttle	1
5	823634	螺钉	SCREW	2
6	NSS		NOT SOLD SEPARATE Spring-Throttle Return	3
7	NSS		NOT SOLD SEPARATE Idle Needle	3
8	NSS		NOT SOLD SEPARATE Spring-Idle Needle	3
9	NSS		NOT SOLD SEPARATE Gasket-cover Plate	3
10	811221	盖板	COVER PLATE	3
11	811220	盖板螺丝	SCREW Cover Plate	6
12	8144461	法兰衬垫	GASKET Flange	3
13	8113522	油泵杆	LEVER Oil Pump	1
14	8086121	杆固定螺钉	SCREW Lever Retainer	1
15	F10155	节气门螺丝	SCREW Throttle Valve	6
16	879194025	节气门阀	VALVE-THROTTLE	3
17	NSS	非单独销售挡圈	NOT SOLD SEPARATE Retaining Ring	3
18	F10064	轴	SHAFT	3
19	808738	衬垫	GASKET	3
20	NSS		NOT SOLD SEPARATE Gasket-Fuel Bowl	3
21	879194011	进油阀	VALVE Inlet	3
22	9594	浮子	FLOAT	3
23	808612	螺钉及垫圈 (#8-32 x .750)	SCREW AND WASHER (#8-32 x .750)	12
24	811695	燃油杯	BOWL Fuel	1
24	811693	燃油杯	BOWL Fuel	2
24	811693	燃油杯	BOWL Fuel	3
25	811694	塞套件	PLUG KIT	3
26	802731	油封组(含4个油封)	SEAL (CONSISTS OF 4 SEALS)	1
27	7831	主燃油喷嘴 (.058)	JET Main Fuel (.058)	3
27	6487	主量孔(0.060)	JET Main (.060)	3
-	812867A97	衬垫套件	GASKET SET	1
-	8236354	化油器维修套件	REPAIR KIT Carburetor	1
-	8112231	化油器衬垫组	GASKET SET Carburetor	1

图 18夹紧旋转支架 CLAMP AND SWIVEL BRACKET

REF	零件编号	中文名称	英文名称	数量
1	6840M	旋转支架（短轴）	SWIVEL BRACKET (SHORT SHAFT)	1
1	6841M	旋转支架（长轴）	SWIVEL BRACKET (LONG SHAFT)	1
2	82369M	黄油嘴	FITTING GREASE	3
3	81439M	黄油嘴盖	CAP GREASE FITTING	3
4	6839M	夹箍支架	CLAMP BRACKET	2
5	80638M	艉板夹紧螺钉垫块	PAD TRANSOM CLAMP SCREW	2
6	81381M	艉板夹紧螺钉	SCREW TRANSOM CLAMP	2
6	92649M	螺钉	SCREW	2
7	81382M	艉板夹紧螺钉手柄	HANDLE TRANSOM CLAMP SCREW	2
7	11868M	手柄	HANDLE	2
8	81889M	销	PIN	2
9	81383M	夹紧支架螺柱	STUD CLAMP BRACKET	1
10	81981M	夹紧支架螺柱隔套	SPACER CLAMP BRACKET STUD	1
11	82220M	垫圈	WASHER	2
12	82395M	螺母	NUT	2
13	81387M	夹紧支架螺柱	STUD CLAMP BRACKET	1
13	41312M	螺栓	BOLT	1
14	81836M	垫圈	WASHER	2
15	81787M	螺母	NUT	2
15	879172252	螺母	NUT	2
16	81388M	夹紧支架螺柱盖	CAP CLAMP BRACKET STUD	2
16	811914M	盖帽	CAP	2
17	81392M	减震器	SHOCK ABSORBER	2
17	92650M	减震器	SHOCK ABSORBER	2
18	81386M	上部减震器销	PIN UPPER SHOCK MOUNT	1
19	82120M	减震器安装垫片	SPACER SHOCK MOUNT	2
20	81830M	垫圈	WASHER	2
21	81939M	衬套	BUSHING	4
22	81384M	下部减震器安装销	PIN LOWER SHOCK MOUNT	2
23	81859M	垫圈	WASHER	2
24	81938M	衬套	BUSHING	4
25	81812M	垫圈	WASHER	4
26	81718M	螺栓	BOLT	4
27	81385M	减震器安装盖	COVER SHOCK MOUNT	4
27	92651M	盖板	COVER	4
28	82533M	螺钉	SCREW	4
28	95467M	螺钉	SCREW	4

图 19外罩 COWLING

REF	零件编号	中文名称	英文名称	数量
1	813010A8	顶盖总成 (无贴花)	TOP COWL ASSEMBLY Without Decals	1
1	813010A14	顶盖总成 (无贴花)	TOP COWL ASSEMBLY Without Decals	1
1	813010T14	顶罩总成银色-电动型	TOP COWL ASSEMBLY Silver-Electric	1
1	816534A8	顶盖总成 (无贴花)	TOP COWL ASSEMBLY Without Decals	1
1	8M0107142	罩盖-顶部, 黑色	COWL-TOP, BLACK	1
1	816534A14	顶盖总成 (无贴花)	TOP COWL ASSEMBLY Without Decals	1
1	816534T14	顶罩总成银色-手动型	TOP COWL ASSEMBLY Silver-Manual	1
2	824666	进气口护罩	SHIELD Air Inlet	1
3	4006731	螺钉(M6 x 16)	SCREW (M6 x 16)	4
4	47341A11	手动启动绳柄套件	ROPE AND HANDLE KIT Manual Starting	1
5	NSS	不单独出售信封袋	NOT SOLD SEPARATE Envelope	1
6	813548A3	支架罩盖支撑-黑色	BRACKET Cowl Support - Black	1
6	813548A6	支架罩盖支撑-银色	BRACKET Cowl Support - Silver	1
6	813548A3	支架罩盖支撑-黑色	BRACKET Cowl Support - Black	1
7	8231871	螺钉(M4×14.5)	SCREW (M4 x 14.5)	2
8	26995	防松垫圈(#8不锈钢)	LOCKWASHER (#8) Stainless Steel	2
9	8237515	螺母(M4)	NUT (M4)	2
10	813549A2	后盖支撑支架	BRACKET Cowl Support Rear	1
11	8231871	螺钉(M4×14.5)	SCREW (M4 x 14.5)	3
12	26995	防松垫圈(#8不锈钢)	LOCKWASHER (#8) Stainless Steel	3
13	8237515	螺母(M4)	NUT (M4)	3
14	814336A1	隔音毯套装	SOUND BLANKET KIT	1
14	814336A02	隔音毯套装(预涂压敏胶)	SOUND BLANKET KIT (Pre-Applied Pressure Sensitive Adhesive)	1
15	NSS	不单独销售前部隔音毯-手动	NOT SOLD SEPARATE Sound Blanket-Front-Manual	1
16	NSS	不单独销售右舷侧隔音毯	NOT SOLD SEPARATE Sound Blanket-Side-Starboard	1
17	NSS	不单独销售左舷侧隔音毯	NOT SOLD SEPARATE Sound Blanket-Side-Port	1
18	NSS	不单独销售隔音垫-后部	NOT SOLD SEPARATE Sound Blanket-Rear	1
19	444622	密封件	SEAL	1
19	8M0043150	罩盖密封条	SEAL-COWL	1
20	813504A1	油位表套件	GAUGE KIT Oil Level	1
21	813505	护孔环	GROMMET	1
22	113171	固定座	RETAINER	1
23	113161	螺母	NUT	1
23	65110	螺母	NUT	1
24	823593A1	导流板套件空气	DEFLECTOR KIT Air	1
25	8135462	支架	MOUNT	3
25	813546003	支架	MOUNT	3
26	18173	锁扣滚轮支架总成	BRACKET ASSEMBLY Latch Roller	1
26	893763	滚轮锁扣支架	BRACKET Roller Latch	1
27	4006731	螺钉(M6 x 16)	SCREW (M6 x 16)	2
28	812512A8	下机罩	BOTTOM COWL	1
28	812512A9	下罩总成	BOTTOM COWL ASSEMBLY	1
29	813607	密封件	SEAL	1
29	8M0043162	密封件	SEAL	1
30	828465	缓冲垫	BUMPER	2
30	8M0043169	缓冲垫	BUMPER	2
31	850691	开关	SWITCH	1
31	8M0235192	微调开关	SWITCH TRIM	1
32	8128301	堵头	PLUG	1
32	812830T01	堵头	PLUG	1
33	8124431	固定座	RETAINER	1
33	8M0032848	开关固定座	RETAINER Switch	1
34	813613	接头	FITTING	1
35	8136061	密封件	SEAL	1
35	813606003	密封件	SEAL	1
36	40011151	不锈钢螺钉(M8×35)	SCREW (M8 x 35) Stainless Steel	2
37	8136052	密封件	SEAL	1
37	813605003	密封件	SEAL	1
38	7568058	软管 (15.00英寸)	HOSE (15.00 Inches)	1
39	4006731	螺钉(M6 x 16)	SCREW (M6 x 16)	2
40	19812A1	支架电缆固定器	BRACKET Cable Retainer	1
40	19812T03	支架总成	BRACKET ASSEMBLY	1
41	42975	传动螺钉	DRIVE SCREW	2
42	98889	闩锁	LATCH	1
43	39519	杯套	CUP	1
44	88807A28	拉线总成	CABLE ASSEMBLY	1
45	817626	螺钉(#10-16×0.380)	SCREW (#10-16 x .380)	2
45	878607	螺钉（#10-16 x 0.375）	SCREW (#10-16 x .375)	2
46	4000335	螺钉(M6 x 50)	SCREW (M6 x 50)	1
47	35280	垫圈(.255 x .620 x .030) 不锈钢	WASHER (.255 x .620 x .030) Stainless Steel	2
48	37642	波形垫圈	WAVE WASHER	2
49	19428	衬套	BUSHING	1
50	813547T	罩壳锁杆	LEVER Cowl Latch	1
50	813547F1	杠杆	LEVER	1
50	813547T6	罩壳锁杆	LEVER Cowl Latch	1
50	813547F1	杠杆	LEVER	1
51	826354A1	衬套套件罩盖锁扣	BUSHING KIT Cowl Latch	1
52	NSS	不单独销售衬套	NOT SOLD SEPARATE Bushing	1
53	813604	锁扣凸轮	LATCH CAM	1
54	8268336	螺母 (M6)	NUT (M6)	1
54	401386	螺母(M6)不锈钢	NUT (M6) Stainless Steel	1
55	812717T	配平盖	TRIM COVER	1
55	812717T1	配平盖	TRIM COVER	1
55	812717T6	配平盖	TRIM COVER	1
55	812717T	配平盖	TRIM COVER	1
56	40011128	不锈钢螺钉(M6x20)	SCREW (M6 x 20) Stainless Steel	4
56	8M0204741	六角带垫大帽螺钉(M6x1.0x20)	SCREW (M6 x 1.0 x 20) Hex Wash HD	4

图 20曲轴箱和气缸盖 CRANKCASE AND CYLINDER HEAD

REF	零件编号	中文名称	英文名称	数量
0-1	6835M	曲轴箱总成	CRANKCASE ASSEMBLY	1
1	80727M	止回阀总成	CHECK VALVE ASSEMBLY	1
2	82975M	弯头止回阀	ELBOW CHECK VALVE	1
3	80107M	止回阀	VALVE CHECK	1
4	80122M	曲轴箱放油接头	FITTING CRANKCASE DRAIN	1
5	82354M	定位销	PIN DOWEL	1
6	82368M	定位销	PIN DOWEL	1
7	82405M	螺栓	BOLT	8
8	81792M	垫圈	WASHER	8
9	82033M	线夹	CLAMP WIRE	1
10	82410M	螺栓	BOLT	4
11	81807M	垫圈	WASHER	6
12	82387M	螺母	NUT	2
13	81735M	进气歧管安装螺柱	STUD INTAKE MANIFOLD ATTACHING	8
14	81995M	排水软管	HOSE DRAIN	1
14	811045M	软管	HOSE	1
15	82046M	软管卡箍	CLAMP HOSE	2
16	81258M	轴承销	PIN BEARING	2
17	81743M	曲轴箱安装螺柱	STUD CRANKCASE ATTACHING	2
18	81255M	阳极块	ANODE	1
19	82527M	螺钉	SCREW	2
19	82532M	螺钉	SCREW	2
20	6927M	气缸盖	HEAD CYLINDER	1
21	81252M	气缸盖衬垫	GASKET CYLINDER HEAD	1
21	19140	衬垫	GASKET	1
22	82409M	螺栓	BOLT	10
23	80564M	垫圈	WASHER	10
24	81253M	气缸盖罩	COVER CYLINDER HEAD	1
25	81254M	气缸盖罩衬垫	GASKET CYLINDER HEAD COVER	1
26	83539M	螺栓 (M6 x 20)	BOLT (M6 x 20)	21
26	84058M	螺栓 (M6 x 20)	BOLT (M6 x 20)	21
27	82199M	锁紧垫圈	WASHER LOCK	25
27	82214M	垫圈	WASHER	25
28	81267M	压力控制阀	VALVE PRESSURE CONTROL	1
29	82086M	压缩弹簧	SPRING COMPRESSION	1
30	82067M	护孔环	GROMMET	1
31	81098M	节温器	THERMOSTAT	1
31	99080M	节温器	THERMOSTAT	1
32	81265M	节温器盖	COVER THERMOSTAT	1
33	81266M	节温器盖衬垫	GASKET THERMOSTAT COVER	1
34	84237M	螺栓	BOLT	4
34	83285M	螺栓	BOLT	4
35	81926M	堵头	PLUG	1
36	81990M	塞衬垫	GASKET PLUG	1
37	81330M	排气外罩	COVER EXHAUST - OUTER	1
38	81331M	排气盖衬垫	GASKET EXHAUST COVER	1
39	80756M	排气罩接头	FITTING EXHAUST COVER	1
39	94716M	连接器	CONNECTOR	1
40	81324M	排气罩软管	HOSE EXHUAST COVER	1
41	82047M	软管卡箍	CLAMP HOSE	2
42	81251M	升降支架	BRACKET LIFT	1
42	41827M	吊架	HANGER	1
43	84342M	螺栓	BOLT	1
44	82200M	锁紧垫圈	WASHER LOCK	1
44	82215M	锁紧垫圈	LOCKWASHER	1
45	84409M	火花塞 B-8HS10 (NGK)(1.0MM间隙)	PLUG SPARK B-8HS10 (NGK)(1.0MM GAP)	2
45	8M0181926	火花塞	SPARK PLUG	2
45	82372M	火花塞 B-8HS (NGK)(0.7MM间隙)	SPARK PLUG SPARK B-8HS (NGK)(0.7MM GAP) ()	2
45	8M0157387	火花塞BR8HS @4	PLUG BR8HS @4	2
0-2	82985M	停止开关套件	SWITCH KIT Stop	1
46	81526M	停机开关总成	SWITCH ASSEMBLY Stop	1
47	82417M	螺栓	BOLT	1
48	82210M	垫圈	WASHER	1
49	82057M	护孔环	GROMMET	1
50	82042M	卡箍	CLAMP	1
-	83790M	动力头总成	POWERHEAD ASSEMBLY	1
-	92624M	动力头	POWERHEAD	1
-	84168M	衬垫套件	GASKET SET	1

图 21曲轴与活塞 CRANKSHAFT AND PISTON

REF	零件编号	中文名称	英文名称	数量
1	6825M	曲轴总成	CRANKSHAFT ASSEMBLY	1
2	82312M	滚针轴承	BEARING NEEDLE	1
2	82312T	轴承	BEARING	1
3	82249M	曲轴上油封	SEAL Oil CRANKSHAFT - UPPER	1
4	82276M	曲轴上O型圈	O-RING CRANKSHAFT - UPPER	1
5	82313M	中央主轴承	BEARING CENTER MAIN	1
5	97837T	轴承	BEARING	1
6	82304M	曲轴下轴承	BEARING CRANKSHAFT - LOWER	1
6	814560T	滚珠轴承	BALL BEARING	1
7	81259M	曲轴垫片	SHIM CRANKSHAFT	1
8	6954M	活塞 (81.95毫米) 标准	PISTON (81.95 mm) Standard	2
8	6955M	活塞 (标准 81.96毫米)	PISTON (STD 81.96 MM)	2
8	6956M	活塞 (标准 81.97毫米)	PISTON (STD 81.97 MM)	2
8	6957M	活塞 (加大 82.25毫米)	PISTON (O.S. 82.25 MM)	2
8	6958M	活塞 (加大 82.50毫米)	PISTON (O.S. 82.50 MM)	2
9	83195M	活塞环组(标准)	RING SET Piston (STD)	2
9	83196M	活塞环套装 (加大 82.25毫米)	RING SET Piston (O.S. 82.25 MM)	2
9	83197M	活塞环套装 (加大 82.50毫米)	RING SET Piston (O.S. 82.50 MM)	2
9	83197T	活塞环	PISTON RING	2
10	81263M	活塞销	PIN PISTON	2
10	81263T	活塞销	PIN-PISTON	2
11	81264M	活塞销卡簧	CLIP PISTON PIN	4
12	82353M	连杆轴承（活塞端）	BEARING CONNECTING ROD (PISTON END)	56
13	81831M	连杆轴承垫片	WASHER CONNECTING ROD BEARING	4
14	82986M	油封壳体	HOUSING OIL SEAL	1
14	41828M	壳体	HOUSING	1
15	82255M	曲轴下油封	SEAL Oil CRANKSHAFT - LOWER	1
16	82248M	曲轴下油封	SEAL Oil CRANKSHAFT - LOWER	1
17	82286M	油封壳体O型圈	O-RING OIL SEAL HOUSING	1
18	83395M	螺栓	BOLT	3
18	826957M	螺栓	BOLT	3
19	82214M	垫圈	WASHER	3
20	81915M	曲轴至飞轮键	KEY CRANKSHAFT TO FLYWHEEL	1
21	6830M	曲轴箱总成	CRANKCASE ASSEMBLY	2
21	8813M	连杆	CONNECTING ROD	2
22	81715M	螺栓	BOLT	4
23	82311M	连杆轴承（曲轴端）	BEARING CONNECTING ROD (CRANKSHAFT END)	2
23	97710M	轴承	BEARING	2
-	84168M	衬垫套件	GASKET SET

图 22驱动轴壳体 DRIVESHAFT HOUSING

REF	零件编号	中文名称	英文名称	数量
1	822154A1	壳体总成 (短) 黑色	HOUSING ASSEMBLY (SHORT) BLACK	1
1	822155A1	壳体总成 (长) 黑色	HOUSING ASSEMBLY (LONG) BLACK	1
1	822154A2	壳体总成 (短) 灰色	HOUSING ASSEMBLY (SHORT) GRAY	1
1	822155A2	壳体总成 (长) 灰色	HOUSING ASSEMBLY (LONG) GRAY	1
2	195992	驱动轴壳体衬垫	GASKET Driveshaft Housing	1
3	421891	支架	MOUNT	4
4	42374F6	安装盖	COVER Mount	2
4	42374F5	安装盖	COVER Mount	2
5	4009238	螺钉(M6x80)安装盖	SCREW (M6 x 80) MOUNT COVER	2
6	400256	锁紧垫圈 (M6) 盖螺钉	LOCKWASHER (M6) COVER SCREW	2
7	400212	螺母(M6)不锈钢盖螺钉	NUT (M6) Stainless Steel COVER SCREW	2
8	40011131	螺钉 (M6 x 35) 不锈钢驱动轴壳体至板	SCREW (M6 x 35) Stainless Steel DRIVE SHAFT HOUSING TO PLATE	4
9	413448	适配板 (无管)	ADAPTER PLATE (NO TUBE)	1
9	41344A3	适配板总成 (1-1/8"内径管)	ADAPTER PLATE ASSEMBLY (1-1/8"I.D.TUBE)	1
10	11287	适配板密封件	SEAL Adapter Plate	1
11	42123	水管(短型)	TUBE Water (SHORT)	1
11	42122	水管(长型)	TUBE Water (LONG)	1
12	42371	水管固定座	HOLDER WATER TUBE	1
13	192012	衬垫	GASKET	1
14	42380	密封件	SEAL	1
15	42465	水管隔套	SPACER WATER TUBE	1
16	400035	螺钉 (M5 x 16) 壳体至适配板	SCREW (M5 x 16) HOUSING TO ADAPTOR PLATE	2
17	445551	轴承座(长型)	BLOCK Bearing (LONG)	1
-	42364A92	发动机垫片组	GASKET SET Engine	1

图 23电动启动电机 ELECTRIC STARTER MOTOR

REF	零件编号	中文名称	英文名称	数量
1	81490M	启动电机总成	STARTER MOTOR ASSEMBLY	1
2	83654M	前支架	BRACKET Front	1
3	81502M	前支架	BRACKET Front	1
3	83654M	前支架	BRACKET Front	1
4	81513M	开关	SWITCH	1
5	81504M	齿轮	GEAR	1
5	81504T	驱动总成	DRIVE ASSY	1
6	81510M	电枢	ARMATURE	1
6	83651M	电枢	ARMATURE	1
6	83651M	电枢	ARMATURE	1
7	81493M	定子	STATOR	1
8	81507M	电刷架	HOLDER Brush	1
9	81494M	电刷(+)	BRUSH (+)	2
10	81495M	电刷(-)	BRUSH (-)	2
11	81496M	电刷弹簧	SPRING BRUSH	4
12	81499M	后盖	REAR COVER	1
13	82420M	螺栓	BOLT	2
13	84088M	螺丝 (M6 x 10)	SCREW (M6 x 10)	2
14	81500M	螺栓	BOLT	2
15	81505M	止动环	RING STOP	1
15	92671M	止动器套件	STOPPER KIT	1
16	83652M	垫圈套件	WASHER KIT	1
16	81491M	垫圈套件	WASHER KIT	1
17	81497M	导线	WIRE LEAD	1
18	81508M	盖板	COVER	1
19	84236M	螺栓	BOLT	2
20	84342M	螺栓	BOLT	1
21	82200M	垫圈	WASHER	4
21	82215M	锁紧垫圈	LOCKWASHER	4
22	82202M	垫圈	WASHER	2
22	82217M	垫圈	WASHER	2
23	81485M	接线端子	TERMINAL	AR
24	82437M	螺栓	BOLT	1

图 24燃油管路与滤清器 FUEL LINE AND FILTER

REF	零件编号	中文名称	英文名称	数量
1	81041M	燃油管接头	CONNECTOR Fuel Pipe Joint	1
2	83539M	螺栓 (M6 x 20)	BOLT (M6 x 20)	1
2	84058M	螺栓 (M6 x 20)	BOLT (M6 x 20)	1
3	82212M	锁紧垫圈	LOCKWASHER	1
4	80617M	燃油滤清器总成	FILTER ASSEMBLY Fuel	1
4	826964T	燃油滤清器	FILTER Fuel	1
5	82790M	燃油杯衬垫	GASKET FUEL BOWL	1
6	82783M	燃油滤清器滤芯	ELEMENT FUEL FILTER	1
6	826965T	燃油滤清器	FILTER-FUEL	1
7	82792M	O型圈	O-RING	1
7	84957M	O型圈	O-RING	1
8	82784M	燃油杯	BOWL Fuel	1
8	11935M	杯套	CUP	1
9	80620M	燃油滤清器支架	BRACKET FUEL FILTER	1
10	84211M	螺栓	BOLT	1
11	82197M	锁紧垫圈	WASHER LOCK	1
11	82212M	锁紧垫圈	LOCKWASHER	1
12	82382M	螺母	NUT	1
13	82017M	燃油管连接器至泵	LINE Fuel CONNECTOR TO PUMP	1
13	82012M	软管	HOSE	1
14	82037M	卡箍	CLAMP	1
15	82010M	燃油管滤清器至泵	LINE Fuel FILTER TO PUMP	1
15	82012M	软管	HOSE	1
16	82020M	燃油管泵至三通	LINE Fuel PUMP TO TEE	1
16	94727M	软管	HOSE	1
17	81697M	燃油管三通接头	TEE FITTING FUEL LINE	1
18	82004M	燃油管三通至化油器	LINE Fuel TEE TO CARBURETOR	2
18	82012M	软管	HOSE	2
19	82047M	软管卡箍	CLAMP HOSE	9
20	82048M	软管卡箍	CLAMP HOSE	1
-	84168M	衬垫套件	GASKET SET	1

图 25燃油泵 FUEL PUMP

REF	零件编号	中文名称	英文名称	数量
1	81328M	燃油泵总成	PUMP ASSEMBLY Fuel	1
1	43113T	燃油泵	FUEL PUMP	1
2	80606M	隔膜	DIAPHRAGM	2
3	80611M	板簧导板	PLATE SPRING GUIDE	2
4	80610M	弹簧	SPRING	1
5	80613M	机体至底座衬垫	GASKET BODY TO BASE	2
5	80613	衬垫	GASKET	2
6	80608M	止回阀	CHECK VALVE	2
7	80612M	止回阀衬垫	GASKET CHECK VALVE	2
8	80609M	止回阀固定座	RETAINER CHECK VALVE	2
9	82511M	螺钉	SCREW	2
9	82511M	螺钉	SCREW	2
11	82373M	螺母	NUT	1
11	82537M	螺母	NUT	1
11	80615M	弹簧	SPRING	1
12	80614M	机体至盖板衬垫	GASKET BODY TO COVER	1
12	80614	衬垫	GASKET	1
13	80607M	盖板	COVER	1
14	82522M	螺钉	SCREW	3
15	82208M	锁紧垫圈	WASHER LOCK	3
15	82186M	垫圈	WASHER	3
16	84139M	燃油泵总成	PUMP ASSEMBLY Fuel	1
16	43113T	燃油泵	FUEL PUMP	1
17	80606M	隔膜	DIAPHRAGM	1
18	80611M	板簧导板	PLATE SPRING GUIDE	1
19	80610M	弹簧	SPRING	1
20	80613M	机体至底座衬垫	GASKET BODY TO BASE	1
20	80613	衬垫	GASKET	1
21	84140M	止回阀	CHECK VALVE	2
21	84650M	止回阀	CHECK VALVE	2
22	80614M	机体至盖板衬垫	GASKET BODY TO COVER	1
22	80614	衬垫	GASKET	1
23	84141M	隔膜	DIAPHRAGM	1
24	80607M	盖板	COVER	1
25	82522M	螺钉	SCREW	3
26	82208M	锁紧垫圈	WASHER LOCK	3
26	82186M	垫圈	WASHER	3
27	80757M	燃油泵至曲轴箱衬垫	GASKET FUEL PUMP TO CRANKCASE	1
27	80757	衬垫	GASKET	1
28	82428M	螺栓	BOLT	2
28	827043M	螺栓	BOLT	2
29	82198M	垫圈	WASHER	2
29	82213M	垫圈	WASHER	2
-	84168M	衬垫套件	GASKET SET	1

图 26燃油箱（22.7升）(6加仑) FUEL TANK (22.7 LITRE)(6 GALLON)

REF	零件编号	中文名称	英文名称	数量
0-1	1529A16	燃油箱总成-完整	TANK ASSEMBLY Fuel - Complete	1
0-1	812410A1	燃油箱总成	TANK ASSEMBLY Fuel	1
1	1529	燃油箱	TANK Fuel
1	812410A1	燃油箱总成	TANK ASSEMBLY Fuel
2	75881	贴花	DECAL	1
2	13921	贴花	DECAL	1
3	25392A2	加注口盖总成	CAP ASSEMBLY Filler	1
3	18962M	燃油箱盖	CAP Fuel Tank	1
4	25575	螺钉通气-加注口盖	SCREW VENT-FILLER CAP	1
5	49221	垫圈(.187 x .500 x .062)氯丁橡胶通气螺钉	WASHER (.187 x .500 x .062) Neoprene VENT SCREW	1
5	8M0204663	垫片@5	WASHER @5	1
6	22227	张力弹簧-通气螺钉	SPRING TENSION-VENT SCREW	1
7	28587	螺母调速弹簧固定器	NUT SPEED-SPRING RETAINER	1
8	25568	衬垫加注口盖至燃油箱	GASKET FILLER CAP TO FUEL TANK	1
8	41065	衬垫	GASKET	1
0-2	64841A1	连接器/仪表总成	CONNECTOR/GAUGE ASSEMBLY COMPLETE	1
9	64841A3	燃油箱盖	COVER FUEL TANK	1
9	17792A1	浮子组件总成	BODY ASSEMBLY PickUp	1
10	33909A3	管	TUBE	1
10	75239	管	TUBE	1
11	54920A1	燃油表透镜总成	LENS ASSEMBLY FUEL GAUGE	1
11	98542A1	观察窗总成	WINDOW ASSEMBLY	1
12	54921	衬垫燃油表透镜	GASKET FUEL GAUGE LENS	1
12	98542A1	观察窗总成	WINDOW ASSEMBLY	1
13	28897A2	燃油表总成	GAUGE ASSEMBLY Fuel COMPLETE	1
14	20430	燃油表固定架	RETAINER FUEL GAUGE	1
15	28897A1	指针与浮子总成	INDICATOR AND FLOAT ASSEMBLY	1
16	20427	燃油表浮子	FLOAT FUEL GAUGE	1
16	99274	浮子	FLOAT	1
17	20426	铆钉指针至固定架	RIVET INDICATOR TO RETAINER	1
18	62568	螺钉(#10-16 x .375) 固定架至燃油箱盖	SCREW (#10-16 x .375) RETAINER TO FUEL TANK COVER	2
19	28862	盖总成至框架衬垫	GASKET COVER ASEMBLY TO FRAME	1
20	28860	框架固定件-燃油箱盖	FRAME RETAINING-FUEL TANK COVER	1
21	28903	螺母固定框架至燃油箱	NUT RETAINING FRAME TO FUEL TANK	2
22	20411	螺钉(.190-24 x .62) 燃油箱盖至燃油箱	SCREW (.190-24 x .62) FUEL TANK COVER TO FUEL TANK	4
23	74711	燃油箱盖紧固螺钉垫圈	WASHER FUEL TANK COVER FASTENING SCREW	4
23	29070	垫圈	WASHER	4

图 27燃油箱（S-675-00450/L-32875及以下） FUEL TANK (S-675-00450/L-32875 & BELOW)

REF	零件编号	中文名称	英文名称	数量
0-1	6836M	燃油箱总成	TANK ASSEMBLY Fuel	1
1	82984M	贴花	DECAL	1
2	81694M	燃油箱盖	CAP Fuel Tank	1
3	81321M	燃油接头壳体	HOUSING FUEL CONNECTOR	1
4	81320M	壳体至油箱衬垫	GASKET HOUSING TO TANK	1
5	82526M	壳体固定螺钉	SCREW HOUSING ATTACHING	4
5	83356M	螺钉	SCREW	4
6	80271M	壳体螺钉垫圈	WASHER HOUSING SCREW	4
6	95501M	密封件	SEAL	4
7	80270M	壳体至指示器透镜衬垫	GASKET HOUSING TO LENS INDICATOR	1
7	17540M	衬垫	GASKET	1
8	80269M	指示器透镜	LENS INDICATOR	1
9	80268M	指示器支架	BRACKET INDICATOR	1
10	82518M	支撑固定螺钉	SCREW SUPPORT ATTACHING	2
10	83523M	螺钉	SCREW	2
11	81318M	指示器	INDICATOR	1
12	81319M	浮子指示器	FLOAT INDICATOR	1
0-2	83192M	燃油软管总成	HOSE ASSEMBLY Fuel	1
0-2	877681Q8	燃油软管总成(8英尺)	HOSE ASSEMBLY Fuel (8 Feet)	1
13	81042M	壳体总成	HOUSING ASSEMBLY	2
13	14213Q	燃油接头@2	FITTING-FUEL@2	2
14	82789M	O型圈	O-RING	2
15	81327M	软管卡箍	COLLAR HOSE	1
16	81325M	注油球	PRIMER BULB	1
16	89396Q01	注油球@4	PRIMER BULB @4	1
17	82025M	壳体至手泵软管连接器	HOSE CONNECTOR HOUSING TO BULB	1
17	94727M	软管	HOSE	1
18	82023M	球头至连接器软管	HOSE BULB TO CONNECTOR	1
18	94727M	软管	HOSE	1
19	80752M	软管卡箍	CLAMP HOSE	4
19	16725M	卡箍	CLAMP	4

图 28燃油箱（S-675-00451/L-675-32876及以上） FUEL TANK (S-675-00451/L-675-32876 & UP)

REF	零件编号	中文名称	英文名称	数量
1	82984M	侧面贴花	DECAL SIDE	1
2	82962M	顶部贴花	DECAL TOP	1
3	83627M	衬垫	GASKET	1
4	83618M	燃油表总成	METER ASSEMBLY Fuel	1
5	80269M	指示器透镜	LENS INDICATOR	1
6	80268M	指示器支架	BRACKET INDICATOR	1
7	80270M	衬垫	GASKET	1
7	17540M	衬垫	GASKET	1
8	82518M	螺钉	SCREW	2
8	83523M	螺钉	SCREW	2
9	81318M	燃油液位指示器	INDICATOR FUEL LEVEL	1
10	81319M	浮子指示器	FLOAT INDICATOR	1
11	81320M	壳体至油箱衬垫	GASKET HOUSING TO TANK	1
12	83626M	吸油软管	HOSE PICKUP	1
12	94727M	软管	HOSE	1
13	83764M	吸油管卡箍	CLAMP PICKUP HOSE	1
14	82526M	壳体固定螺钉	SCREW HOUSING ATTACHING	4
14	83356M	螺钉	SCREW	4
15	80271M	壳体螺钉垫圈	WASHER HOUSING SCREW	4
15	95501M	密封件	SEAL	4
0-1	83628M	燃油管路总成	LINE ASSEMBLY Fuel	1
0-1	877681Q8	燃油软管总成(8英尺)	HOSE ASSEMBLY Fuel (8 Feet)	1
16	30185A1	卡口式阀体总成	BAYONET BODY ASSEMBLY	1
16	30185Q3	油箱端快速断开总成-卡口式	QUICK DISCONNECT ASSEMBLY Tank End - Bayonet Style	1
17	30187	卡口阀体阀杆	STEM BAYONET BODY	1
17	30185Q3	油箱端快速断开总成-卡口式	QUICK DISCONNECT ASSEMBLY Tank End - Bayonet Style	1
18	20415	卡口阀体阀杆O型圈	O-RING BAYONET BODY STEM	1
18	16524	燃油接头O型圈	O-RING Fuel Connector	1
19	30189	卡口体杆弹簧	SPRING BAYONET BODY STEM	1
20	30188	盖垫圈	WASHER CAP	1
21	63187	倒刺接头(0.250-18)燃油管	FITTING Barb (.250-18) FUEL LINE	1
22	82025M	壳体至手泵软管连接器	HOSE CONNECTOR HOUSING TO BULB	1
22	94727M	软管	HOSE	1
23	81325M	手泵	PRIMER BULB PRIMER	1
23	89396Q01	注油球@4	PRIMER BULB @4	1
24	82023M	球头至连接器软管	HOSE BULB TO CONNECTOR	1
24	94727M	软管	HOSE	1
25	80752M	软管卡箍	CLAMP HOSE	4
25	16725M	卡箍	CLAMP	4
26	81042M	发动机端壳体总成	HOUSING ASSEMBLY ENGINE END	1
26	14213Q	燃油接头@2	FITTING-FUEL@2	1
27	82789M	O型圈	O-RING	1

图 29齿轮箱总成 GEARHOUSING ASS'Y

REF	零件编号	中文名称	英文名称	数量
0-1	6902M	齿轮箱总成(短轴)	GEAR HOUSING ASSEMBLY (SHORT SHAFT)	1
0-1	6903M	齿轮箱总成（长轴）	GEAR HOUSING ASSEMBLY (LONG SHAFT)	1
0-1	8613M	齿轮箱	GEAR HOUSING	1
1	6844M	齿轮箱总成	GEAR HOUSING ASSEMBLY	1
1	7971M	齿轮箱	GEAR HOUSING	1
2	81449M	导向密封件	GUIDE SEAL	1
3	81924M	堵头	PLUG	3
4	81987M	衬垫	GASKET	3
4	81987	衬垫	GASKET	3
5	81445M	齿轮箱盖	COVER GEAR HOUSING	1
6	82281M	齿轮箱盖O型圈	O-RING COVER TO GEAR HOUSING	1
7	82257M	齿轮箱盖油封	SEAL Oil GEAR HOUSING COVER	1
8	83395M	螺栓	BOLT	2
8	826957M	螺栓	BOLT	2
9	82214M	垫圈	WASHER	2
10	81408M	换挡杆-下部	ROD SHIFT - LOWER	1
11	82334M	卡环	RING Snap	1
12	81409M	换档凸轮	CAM SHIFT	1
13	81451M	驱动轴(短轴)	DRIVESHAFT (SHORT SHAFT)	1
13	81452M	驱动轴(长轴)	DRIVESHAFT (LONG SHAFT)	1
14	81912M	驱动轴-叶轮键	KEY DRIVESHAFT TO IMPELLER	1
15	82319M	驱动轴轴承	BEARING DRIVESHAFT	1
15	82319T	轴承	BEARING	1
16	81467M	驱动轴轴承垫片(0.05mm)	SHIM DRIVESHAFT BEARING (.05MM)	AR
16	81468M	驱动轴轴承垫片(0.08mm)	SHIM DRIVESHAFT BEARING (.08MM)	AR
16	81469M	驱动轴轴承垫片(0.12mm)	SHIM DRIVESHAFT BEARING (.12MM)	AR
16	19148002	垫片 @5	SHIM @5	AR
16	81470M	驱动轴轴承垫片(0.30mm)	SHIM DRIVESHAFT BEARING (.30MM)	AR
16	19148004	垫片 @5	SHIM @5	AR
16	81471M	驱动轴轴承垫片(0.50mm)	SHIM DRIVESHAFT BEARING (.50MM)	AR
16	19153M	垫片	SHIM	AR
17	81453M	驱动轴套	SLEEVE DRIVESHAFT	1
18	82316M	驱动轴滚针轴承	BEARING NEEDLE- DRIVESHAFT	1
18	82316T	轴承	BEARING	1
19	81455M	驱动轴轴承	BEARING DRIVESHAFT	1
20	81772M	驱动轴螺母	NUT DRIVESHAFT	1
21	82991M	齿轮组	GEAR SET	1
22	84208M	小齿轮	GEAR PINION	1
23	84206M	前进齿轮	GEAR FORWARD	1
24	84207M	倒车齿轮	GEAR REVERSE	1
25	81456M	前进齿轮调整垫片(0.05mm)	SHIM FORWARD GEAR ADJUST (.05MM)	AR
25	81457M	前进齿轮调整垫片(0.08mm)	SHIM FORWARD GEAR ADJUST (.08MM)	AR
25	81458M	前进齿轮调整垫片(0.12mm)	SHIM FORWARD GEAR ADJUST (.12MM)	AR
25	19148003	垫片 @5	SHIM @5	AR
25	81459M	前进齿轮调整垫片(0.30mm)	SHIM FORWARD GEAR ADJUST (.30MM)	AR
25	19158M	垫片	SHIM	AR
25	81460M	前进齿轮调整垫片(0.50mm)	SHIM FORWARD GEAR ADJUST (.50MM)	AR
26	82320M	前进齿轮轴承	BEARING FORWARD GEAR	1
26	82320T	轴承	BEARING	1
27	81473M	离合器	CLUTCH	1
27	81473T	离合器	CLUTCH	1
28	81903M	离合器销	PIN CLUTCH	1
29	81474M	十字销环	RING CROSS PIN	1
30	81476M	换挡柱塞	PLUNGER SHIFT	1
30	92643M	柱塞	PLUNGER	1
31	81475M	换挡滑套	SLIDE SHIFT	1
32	82091M	换挡弹簧	SPRING SHIFT	1
33	81472M	螺旋桨轴	SHAFT PROPELLER	1
33	92644M	螺旋桨轴	PROP SHAFT	1
34	81837M	倒档齿轮垫圈	WASHER REVERSE GEAR	1
35	81462M	倒车齿轮调整垫片(0.05mm)	SHIM REVERSE GEAR ADJ (.05MM)	AR
35	81463M	倒车齿轮调整垫片(0.08mm)	SHIM REVERSE GEAR ADJ (.08MM)	AR
35	81464M	倒车齿轮调整垫片(0.12mm)	SHIM REVERSE GEAR ADJ (.12MM)	AR
35	19163002	垫片 @5	SHIM @5	AR
35	81465M	倒车齿轮调整垫片(0.30mm)	SHIM REVERSE GEAR ADJ (.30MM)	AR
35	19163001	垫片 @5	SHIM @5	AR
35	81466M	倒车齿轮调整垫片(0.50mm)	SHIM REVERSE GEAR ADJ (.50MM)	AR
35	19165M	垫片	SHIM	AR
36	81461M	倒档齿轮垫圈	WASHER REVERSE GEAR	1
37	82296M	倒车齿轮轴承	BEARING REVERSE GEAR	1
37	82296T	滚珠轴承	BALL BEARING	1
38	82289M	轴承壳体O型圈	O-RING BEARING HOUSING	1
39	81446M	轴承座	CARRIER Bearing	1
40	81916M	键	KEY	1
41	82317M	螺旋桨轴滚针轴承	BEARING NEEDLE - PROPELLER SHAFT	1
42	82233M	螺旋桨轴油封	SEAL Oil PROPELLER SHAFT	2
42	854017	油封	SEAL Oil	2
43	81877M	爪形垫圈	WASHER CLAW	1
44	81450M	螺母	NUT	1
44	8M0059031	螺母	NUT	1
45	81416M	水泵壳体	BODY WATER PUMP	1
46	81419M	滤芯	INSERT CARTRIDGE	1
47	82824M	水泵叶轮	IMPELLER WATER PUMP	1
47	97108M	叶轮	IMPELLER	1
48	81417M	水泵衬垫	GASKET WATER PUMP	1
48	81417	衬垫@2	GASKET @2	1
49	81420M	滤芯外板	OUTER PLATE CARTRIDGE	1
50	81421M	滤芯外板衬垫	GASKET CARTRIDGE OUTER PLATE	1
51	81422M	水泵底座	BASE WATER PUMP	1
52	81418M	衬垫	GASKET	1
53	82275M	O型圈	O-RING	1
54	82234M	水泵油封	SEAL Oil WATER PUMP	2
55	82354M	定位销	PIN DOWEL	2
56	84057M	螺栓	BOLT	2
57	82468M	螺栓	BOLT	2
57	85277614	螺栓	BOLT	2
58	82217M	垫圈	WASHER	4
59	81426M	上水管密封件	SEAL WATER TUBE - UPPER	1
60	81448M	橡胶密封件	SEAL RUBBER	1
61	81443M	左舷进水口盖	COVER WATER INLET - PORT	1
61	19166M	盖板	COVER	1
62	81444M	右舷进水口盖	COVER WATER INLET - STARBOARD	1
62	19167M	盖板	COVER	1
63	82484M	螺钉	SCREW	1
64	81781M	螺母	NUT	1
64	8528165	螺母	NUT	1
65	82364M	定位销	PIN Dowel	2
66	82474M	螺栓	BOLT	4
66	91636M	螺栓	BOLT	4
67	82218M	锁紧垫圈	LOCKWASHER	4
68	82470M	螺栓	BOLT	1
68	43103M	螺栓	BOLT	1
69	82215M	锁紧垫圈	LOCKWASHER	1
70	83859M	平衡鳍板	TRIM TAB	1
70	83859T	平衡鳍板	TRIM TAB	1
71	82801M	螺栓	BOLT	1
72	81401M	倒挡杆导套	GUIDE REVERSE ROD	1
72	98937M	导套	GUIDE	1
73	81410M	倒挡杆凸轮	CAM REVERSE ROD	1
74	73345	止推垫片	THRUST WASHER	1
74	73345A1	止推垫片	THRUST WASHER	1
75	81775M	螺旋桨螺母	NUT PROPELLER	1
75	859935	螺旋桨螺母	PROP NUT	1
76	82135M	开口销	PIN COTTER	1
76	95295	开口销	COTTER PIN	1
77	81852M	水管垫圈	WASHER WATER TUBE	1
78	81424M	水管（短轴）	TUBE WATER (SHORT SHAFT)	1
78	81425M	水管（长轴）	TUBE WATER (LONG SHAFT)	1
79	81989M	水管O型圈	O-RING WATER TUBE	1
80	81428M	水管固定板	SET PLATE WATER TUBE	1
81	82448M	螺栓	BOLT	2
81	91772M	螺栓	BOLT	2
82	82212M	锁紧垫圈	LOCKWASHER	2
83	81427M	下水管密封件	SEAL WATER TUBE - LOWER	1
84	80218M	冲洗塞(选配)	PLUG FLUSH (OPT)	1
84	8M0121335	堵头	PLUG	1
-	84179M	衬垫套件	GASKET SET	1
-	84188M	维修套件	REPAIR KIT	1
-	84188T	维修套件	REPAIR KIT	1

图 30换挡联动装置 GEAR SHIFT LINKAGE

REF	零件编号	中文名称	英文名称	数量
1	81404M	换挡支架	BRACKET SHIFT	1
2	82137M	U型销	PIN CLEVIS	1
3	82199M	锁紧垫圈	WASHER LOCK	3
3	82214M	垫圈	WASHER	3
3	82199M	垫圈	WASHER	2
3	82214M	垫圈	WASHER	2
4	81866M	波形垫圈	WASHER WAVE	1
5	82423M	螺栓	BOLT	1
6	81530M	安装板	PLATE	1
7	81407M	换挡拉杆	LEVER SHIFT ROD	1
8	82330M	卡环	RING Snap	3
8	82330M	卡环	RING Snap	2
9	84209M	换挡拉杆	LEVER SHIFT ROD	1
10	82736M	开口销	PIN COTTER	1
10	43089M	开口销	COTTER PIN	1
11	81412M	U型叉盖	CAP CLEVIS	1
11	92657M	固定座	RETAINER	1
12	81480M	换挡控制线U型叉	CLEVIS SHIFT CONTROL CABLE	1
13	82556M	换挡杆支架	BRACKET SHIFT ROD	1
14	82441M	螺栓	BOLT	2
15	82200M	锁紧垫圈	WASHER LOCK	2
15	82215M	锁紧垫圈	LOCKWASHER	2
16	81529M	空挡开关支架	STAY NEUTRAL SWITCH	1
17	81528M	空挡开关	NUETRAL SWITCH	1
17	95631001	开关	SWITCH	1
18	82346M	定位球	BALL DETENT	1
19	82081M	弹簧	SPRING	1
20	80635M	固定弹簧	RETAINER SPRING	1
21	81405M	上换挡杆-短轴	SHIFT ROD UPPER - SHORT SHAFT	1
21	81406M	上换挡杆-长轴	SHIFT ROD UPPER - LONG SHAFT	1
21	92656M	换挡连杆	SHIFT ROD	1
22	81953M	衬套	BUSHING	1
23	81858M	换挡杆隔套	SPACER SHIFT ROD	2
24	82324M	卡簧	CIRCLIP	1
24	19259M	卡环	RING Snap	1

图 31点火系统 IGNITION SYSTEM

REF	零件编号	中文名称	英文名称	数量
0-1	6845M	CDI磁电机总成(80W)	CDI MAGNETO ASSEMBLY (80W)	1
1	6935M	飞轮	FLYWHEEL	1
1	6845M	CDI磁电机总成	CDI MAGNETO ASSEMBLY	1
2	83035M	磁电机底座总成	MAGNETO BASE ASSEMBLY	1
2	97100M	底座	BASE	1
3	83036M	充电线圈	COIL CHARGE	1
4	83037M	屏蔽线圈	COIL BLANKING (MASKING)	1
5	83038M	照明线圈	COIL LIGHTING	1
6	82508M	螺钉	SCREW	2
6	82522M	螺钉	SCREW	2
7	82509M	螺钉	SCREW	2
7	82568M	螺栓@2	BOLT @2	2
8	84647M	导线	WIRE LEAD	1
9	82059M	护孔环	GROMMET	5
10	84212M	线圈	COIL	2
11	83031M	正时指针	POINTER TIMING	1
12	83349M	螺栓	BOLT	1
12	826957M	螺栓	BOLT	1
13	82199M	锁紧垫圈	WASHER LOCK	10
13	82214M	垫圈	WASHER	10
14	81342M	底座固定座	RETAINER BASE	1
14	82678M	固定座	RETAINER	1
15	82424M	螺栓	BOLT	3
15	84058M	螺栓 (M6 x 20)	BOLT (M6 x 20)	3
16	81971M	轴环	COLLAR	3
17	81343M	垫圈	WASHER	1
18	81773M	飞轮螺母	NUT FLYWHEEL	1
18	893789	螺母	NUT	1
19	81834M	飞轮垫片	WASHER FLYWHEEL	1
19	893762	垫圈(18×36×3)	WASHER (18 X 36 X 3)	1
19	84436M	飞轮垫片	WASHER FLYWHEEL	1
19	893762	垫圈(18×36×3)	WASHER (18 X 36 X 3)	1
20	81543M	支架	BRACKET	1
21	81523M	减震器安装支架	DAMPER MOUNTING BRACKET	3
22	82851M	衬套	BUSHING	3
22	804344003	轴环	COLLAR	3
23	82979M	垫圈	WASHER	3
23	83769M	垫圈	WASHER	3
24	82405M	螺栓	BOLT	3
25	82194M	锁紧垫圈	WASHER LOCK	3
25	82209M	垫圈	WASHER	3
26	81518M	接线端子	TERMINAL	1
27	82798M	螺钉	SCREW	10
28	82799M	垫圈	WASHER	10
28	82847M	垫圈	WASHER	10
29	82980M	螺钉	SCREW	2
30	82057M	护孔环	GROMMET	1
31	81515M	端子排盖	COVER TERMINAL STRIP	1
32	81516M	端子排垫片	GASKET TERMINAL STRIP	1
33	83048M	螺钉	SCREW	4
33	80738M	怠速螺钉	SCREW Idle Speed	4
34	82184M	锁紧垫圈	LOCKWASHER	4
34	82206M	锁紧垫圈	LOCKWASHER	4
35	83030M	开关盒总成	SWITCHBOX ASSEMBLY	1
35	83030T	开关盒	SWITCH BOX	1
36	81544M	开关箱减震器	DAMPER SWITCH BOX	1
37	81520M	开关箱固定座	RETAINER SWITCH BOX	1
38	81549M	点火线圈	COIL Ignition	2
38	97077M	点火线圈	IGNITION COIL	2
39	82831M	高压线	HIGH TENSION LEAD	2
40	82069M	护孔环	GROMMET	2
41	81250M	电线	WIRE	2
41	81250M	电线	WIRE	3
42	84237M	螺栓	BOLT	4
42	83285M	螺栓	BOLT	4
43	82788M	火花塞帽总成	CAP ASSEMBLY Spark Plug	2
43	63709A1	护套/端子套件	BOOT/TERMINAL KIT	2
43	80935M	保护器(消音器)	PROTECTER (NOISE SUPPRESSER)	2
43	815119M	火花塞帽	CAP Spark Plug	2
44	81652M	整流器	RECTIFIER	1
44	8M0091976	整流器	RECTIFIER	1
45	84245M	螺钉	SCREW	1
45	82522M	螺钉	SCREW	1
46	82193M	锁紧垫圈	WASHER LOCK	1
46	82186M	垫圈	WASHER	1
47	82685M	保险丝支架总成	HOLDER ASSEMBLY Fuse	1
48	81522M	保险丝	FUSE	1
49	81541M	箍带	BAND	1
50	84435M	螺钉	SCREW	2
50	11832M	螺钉	SCREW	2
51	82212M	锁紧垫圈	LOCKWASHER	2
52	82214M	垫圈	WASHER	2
53	82997M	导线	WIRE LEAD	1
54	82998M	导线	WIRE LEAD	1
55	81517M	护孔环	GROMMET	1

图 32进气歧管 INTAKE MANIFOLD

REF	零件编号	中文名称	英文名称	数量
1	81274M	进气底座	BASE AIR INTAKE	1
2	81276M	进气至化油器衬垫	GASKET AIR INTAKE TO CARBURETOR	1
3	83539M	螺栓 (M6 x 20)	BOLT (M6 x 20)	4
3	84058M	螺栓 (M6 x 20)	BOLT (M6 x 20)	4
4	82197M	锁紧垫圈	WASHER LOCK	8
4	82212M	锁紧垫圈	LOCKWASHER	8
5	81275M	进气盖	COVER AIR INTAKE	1
6	81273M	进气衬垫	GASKET AIR INTAKE	1
7	82438M	螺栓	BOLT	1
8	82200M	锁紧垫圈	WASHER LOCK	1
8	82215M	锁紧垫圈	LOCKWASHER	1
9	82202M	垫圈	WASHER	1
9	82217M	垫圈	WASHER	1
10	84410M	电磁阀	SOLENOID	1
10	82987M	电磁阀	SOLENOID	1
10	84410M	电磁阀	SOLENOID	1
11	82145M	滚销	PIN ROLL	1
12	84411M	拉线钩	HOOK WIRE PULL	1
12	81553M	拉线钩	HOOK WIRE PULL	1
13	84412M	拉线	WIRE PULL	1
13	81552M	拉线	WIRE PULL	1
14	82258M	拉线O型圈	O-RING PULL WIRE	1
15	81551M	电磁阀盖	COVER SOLENOID	1
16	84245M	螺钉	SCREW	2
16	82522M	螺钉	SCREW	2
17	81272M	化油器至歧管垫片	GASKET CARBURETOR TO MANIFOLD	2
17	81272	衬垫@5	GASKET @5	2
18	84413M	进气歧管	MANIFOLD INTAKE	2
18	92632M	进气歧管	INTAKE MANIFOLD	2
18	81271M	进气歧管	MANIFOLD INTAKE	2
18	92677M	进气歧管	INTAKE MANIFOLD	2
19	80122M	溢流接头	FITTING OVER FLOW	2
20	80454M	溢流管帽	CAP OVER FLOW PIPE	2
21	81269M	歧管至簧片阀垫片(上)	GASKET MANIFOLD TO REED VALVE - UPPER	2
22	81270M	歧管至簧片阀垫片(下)	GASKET MANIFOLD TO REED VALVE - LOWER	2
23	84204M	簧片阀	REED VALVE	2
23	92633M	簧片	REED	2
23	81268M	簧片阀	REED VALVE	2
23	95630M	簧片	REED	2
24	84414M	簧片组(不含止动片)	REED SET (REED STOPS NOT INCLUDED)	2
24	92634M	簧片阀组件	REED KIT	2
25	82380M	螺母	NUT	8
25	82389M	螺母	NUT	8
26	81337M	阻风门拉杆	ROD CHOKE	1
27	81191M	阻风门杆支架	BRACKET CHOKE LEVER	3
27	16333	卡扣拉杆	ROD Snap	3
28	82988M	阻风门连杆	ROD CHOKE LINK	1
28	810938M	杆	ROD	1
29	82911M	节气门调节杆	ROD THROTTLE ADJUSTMENT	1
29	810939M	杆	ROD	1
30	81554M	减震器	DAMPER	1
31	84415M	软管	HOSE	1
32	82047M	软管卡箍	CLAMP HOSE	2
33	84416M	贴花	DECAL	1
-	84168M	衬垫套件	GASKET SET	1
-	84419M	维修套件	REPAIR KIT	1

图 33安装系统 MOUNTING SYSTEM

REF	零件编号	中文名称	英文名称	数量
1	81359M	臂轴总成(短轴)	ARM AND SHAFT ASSEMBLY (SHORT SHAFT)	1
1	81360M	臂轴总成(长轴)	ARM AND SHAFT ASSEMBLY (LONG SHAFT)	1
1	19145T	转向臂	STEERING ARM	1
2	81482M	转向板(导流板)	PLATE STEERING (RIDE GUIDE)	1
3	81742M	转向板螺柱	STUD STEERING PLATE	2
4	81785M	锁紧螺母	LOCKNUT	2
5	81838M	垫圈	WASHER	1
5	19146M	垫片@5	WASHER @5	1
6	81955M	衬套	BUSHING	2
7	82256M	转向轴油封	SEAL Oil STEERING SHAFT	1
7	98950M	密封件	SEAL	1
8	81839M	垫圈	WASHER	1
9	81432M	下部安装壳体	HOUSING LOWER MOUNT	1
10	82325M	卡簧	CIRCLIP	1
11	84430M	下支架	MOUNT LOWER	2
11	81435M	安装壳体	MOUNT Housing	2
12	84431M	垫圈	WASHER	2
12	81860M	垫圈	WASHER	2
13	84432M	垫圈	WASHER	2
13	81819M	垫圈	WASHER	2
13	83915M	垫圈	WASHER	2
14	81717M	螺栓	BOLT	2
15	81436M	缓冲垫	BUMPER	2
16	84429M	垫圈	WASHER	4
16	81811M	垫圈	WASHER	4
17	82397M	螺母	NUT	2
18	84433M	下安装座固定器	RETAINER LOWER MOUNT	2
18	81433M	下安装座固定器	RETAINER LOWER MOUNT	2
19	82087M	压缩弹簧	SPRING COMPRESSION	4
20	82464M	螺栓	BOLT	4
20	43106M	螺栓	BOLT	4
21	82215M	锁紧垫圈	LOCKWASHER	7
22	81434M	下安装盖	COVER LOWER MOUNT	2
23	82172M	螺钉	SCREW	2
23	83870M	螺钉	SCREW	2
24	81779M	螺母	NUT	2
25	81676M	上安装壳体	MOUNT Housing UPPER	2
25	81676T	支架	MOUNT	2
26	81431M	缓冲垫	BUMPER	2
27	81714M	螺栓	BOLT	2
28	81825M	垫圈	WASHER	2
29	81857M	垫圈	WASHER	2
30	81803M	垫圈	WAHSER	2
31	81783M	螺母	NUT	2
32	81429M	上安装座固定器	RETAINER UPPER MOUNT	1
33	82466M	螺栓	BOLT	3
33	82442M	螺栓	BOLT	3

图 34动力微调 POWER TRIM

REF	零件编号	中文名称	英文名称	数量
41	68258	启动电磁阀	SOLENOID Starter	1
42	26996	锁紧垫圈(#10)(不锈钢)	LOCKWASHER (#10) Stainless Steel	2
43	68219	螺母 (#10-32) 不锈钢	NUT (#10-32) Stainless Steel	2
44	26993	锁紧垫圈 (.312)	LOCKWASHER (.312)	2
44	8M0204647	锁紧垫圈 (.312)	LOCKWASHER (.312)	2
45	68292	螺母(.312-18)	NUT (.312-18)	2
45	8M0204668	螺母(.312-18)	NUT (.312-18)	2
46	46265	橡胶护套	BOOT RUBBER	2
47	74407	电磁阀安装支架	BRACKET SOLENOID MOUNTING	1
47	74407T	支架	BRACKET	1
48	21140	支架至泵螺丝(.250-28 x .50)	SCREW (.250-28 x .50) BRACKET TO PUMP	2
49	26992	锁紧垫圈(.250)不锈钢	LOCKWASHER (.250) Stainless Steel	2
50	69052	电磁阀至支架螺丝	SCREW SOLENOID TO BRACKET	2
50	98256	螺钉(.250-28x.500)	SCREW (.250-28 x .500)	2
51	26992	锁紧垫圈(.250)不锈钢	LOCKWASHER (.250) Stainless Steel	2
52	21825	螺母(.250-28)	NUT (.250-28)	2
53	21825	支架贯穿螺栓螺母(.250-28)	NUT (.250-28) BRACKET TO THRU-BOLT	1
54	26901	橡胶缓冲器	BUMPER RUBBER	1
54	269011	橡胶缓冲垫	BUMPER Rubber	1
0-3	55642A7	控制面板总成	CONTROL PANEL ASSEMBLY	1
0-3	55642A13	控制面板总成	CONTROL PANEL ASSEMBLY	1
55	53107	跳线(3.00英寸)(紫色)	WIRE Jumper (3.00 Inches) (PURPLE)	1
55	48078	跳线(红色)	WIRE Jumper (RED)	1
56	55642A1	面板	PANEL	1
56	55642A17	面板套件	PANEL KIT	1
57	55422	面板至船体螺柱(#10-32 x 2.00)	STUD (#10-32 x 2.00) PANEL TO BOAT	4
58	24676	垫圈 (.200 x .440 x .032)	WASHER (.200 x .440 x .032)	4
59	27164	螺母与锁紧垫圈 (#10-32)	NUT AND LOCKWASHER (#10-32)	4
60	55738A1	开关总成	SWITCH ASSEMBLY	3
61	55641	开关固定座	RETAINER SWITCH	1
62	62568	螺钉（#10-16 x 0.375）	SCREW (#10-16 x .375)	4
63	4534120	线束总成(20英尺)	HARNESS ASSEMBLY (20 FEET)	1
63	87394A20	线束总成	HARNESS ASSEMBLY	1
64	33865	尼龙扎带	BINDER NYLON	1
65	46770	卡箍	CLAMP	1
65	95814	绑带	STRAP	1
66	29227	螺丝(#8-32 x 0.50)	SCREW (#8-32 x 0.50)	1
67	34388	螺母	NUT	1
68	76509A3	配平油缸	TRIM CYLINDER	2
68	92194A14	配平油缸	TRIM CYLINDER	2
69	74036	润滑脂接头	FITTING Grease	2
69	8M0169589	润滑脂接头	FITTING Grease	2
70	45265	螺钉(#10-32x0.3125)放气	SCREW (#10-32 x .3125) BLEED	4
71	45016	O型圈-放气螺钉	O-RING BLEED SCREW	4
72	71796	缸体至下销螺丝	SCREW CYLINDER TO LOWER PIN	2
73	45280	下垫片	SPACER LOWER	2
74	45281	橡胶衬套	BUSHING RUBBER	2
74	94907A1	衬套	BUSHING	2
75	66084	缸体安装支架(左舷)	BRACKET CYLINDER MOUNTING (PORT)	1
75	89108A3	支架	BRACKET	1
76	71797	支架至上销螺丝	SCREW BRACKET TO UPPER PIN	2
77	68298	支架至船体螺栓(.375-16 x 3.250)	BOLT (.375-16 x 3.250) BRACKET TO BOAT	4
78	68410	垫圈	WASHER	4
78	46765	垫圈 (.390 x 1.50 x .120)	WASHER (.390 x 1.50 x .120)	4
79	68411	螺母（.375-16）	NUT (.375-16)	4
79	82670912	螺母(.375-16)不锈钢	NUT (.375-16) Stainless Steel	4

图 35动力配平（选装） POWER TRIM (OPTIONAL)

REF	零件编号	中文名称	英文名称	数量
0-1	45194A23	动力调整套件	POWER TRIM KIT	1
0-2	76395A5	液压泵总成	PUMP ASSEMBLY Hydraulic	1
0-2	92975A32	泵套件-微调	PUMP KIT-TRIM	1
1	21720	泵底座O型圈	O-RING PUMP BASE	4
1	48171	O型圈(0.364 x 0.070)	O-RING (.364. x .070)	4
2	2936	阀体与齿轮总成	VALVE BODY AND GEAR ASSEMBLY	1
2	7734	阀体与齿轮总成	VALVE BODY AND GEAR ASSEMBLY	1
3	2618	阀体外壳	CAN VALVE BODY	2
4	20411	阀至储液罐螺丝(.190-24 x .62)	SCREW (.190-24 x .62) VALVE TO RESERVOIR	8
5	2937	阀至储液罐密封件	SEAL VALVE TO RESERVOIR	1
5	7735	密封件	SEAL	1
6	2939	储液罐总成	RESERVOIR ASSEMBLY	1
7	38257	通气螺钉	SCREW VENT	1
7	62269	螺丝(#10-32 x .437)	SCREW (#10-32 x .437)	1
8	28634	注油螺丝(.375-16)	SCREW (.375-16) FILL	1
8	79953Q04	放油螺钉套件	SCREW KIT Drain	1
9	20260	注油螺丝垫圈	WASHER FILL SCREW	1
9	8M0187157	蓝色密封件@15	SEAL-BLUE @15	1
10	2623	电枢垫圈	WASHER ARMATURE	AR
11	2943	电枢	ARMATURE	1
12	2942	磁场框架总成	FIELD AND FRAME ASSEMBLY	1
13	2944	球端板	BALL END PLATE	1
14	2940	隔板总成	PLATE ASSEMBLY	1
15	2941	电刷组	BRUSH SET	1
15	8989	电刷套件	BRUSH KIT	1
16	2529	弹簧组	SPRING SET	1
17	2938	螺栓套件	BOLT SET	1
18	26996	锁紧垫圈(#10)(不锈钢)	LOCKWASHER (#10) Stainless Steel	2
19	55901	指示标贴	DECAL INSTRUCTION	1
20	32979	蓄电池正极导线	LEAD Battery (+)	1
21	32988	蓄电池负极导线	LEAD Battery (-)	1
22	45336	歧管板	PLATE MANIFOLD	1
23	45197A2	控制阀总成	VALVE ASSEMBLY Control	1
-	21720	O型圈	O-RING	4
-	48171	O型圈(0.364 x 0.070)	O-RING (.364. x .070)	4
24	45254	阀至歧管O型圈	O-RING VALVE TO MANIFOLD	1
25	21720	阀至歧管O型圈	O-RING VALVE TO MANIFOLD	1
25	48171	O型圈(0.364 x 0.070)	O-RING (.364. x .070)	1
26	45253	阀至歧管O型圈	O-RING VALVE TO MANIFOLD	2
27	56500	阀安装螺钉(.250-28 x 1.250)	SCREW (.250-28 x 1.250) VALVE ATTACHING	4
28	26992	锁紧垫圈(.250)不锈钢	LOCKWASHER (.250) Stainless Steel	4
29	38609	阀塞(3/8英寸)	PLUG VALVE (3/8 INCH)	2
30	46008	阀塞(1/2英寸)	PLUG VALVE (1/2 INCH)	2
31	74023	线束总成	HARNESS ASSEMBLY	1
31	74023A1	线束总成	HARNESS ASSEMBLY	1
32	45559	泵接线端子排	TERMINAL BLOCK PUMP	1
33	35519	端子排至泵螺钉(#10-16 x .500)	SCREW (#10-16 x .500) BLOCK TO PUMP	2
34	62568	线束至端子排螺钉(#10-16 x .375)	SCREW (#10-16 x .375) HARNESS TO BLOCK	2
35	45377	泵安装支架	BRACKET PUMP MOUNTING	2
35	45377T	支架	BRACKET	2
36	24234	支架至泵螺钉(.312-18 x 1.00)	SCREW (.312-18 x 1.00) BRACKET TO PUMP	4
36	35386	螺丝(.312-18 x 1.00)	SCREW (.312-18 x 1.00)	4
37	39107	锁紧垫圈(0.312-24)	LOCKWASHER (.312-24)	4
38	21908	螺母（.312-18）镀镉	NUT (.312-18) Cad Plated	4
39	68298	泵至船体螺栓(.375-16 x 3.250)	BOLT (.375-16 x 3.250) PUMP TO BOAT	2
40	68411	螺母（.375-16）	NUT (.375-16)	2
40	82670912	螺母(.375-16)不锈钢	NUT (.375-16) Stainless Steel	2

图 36倒挡锁 REVERSE LOCK

REF	零件编号	中文名称	英文名称	数量
1	81393M	倾斜止动支撑杆(左舷)	LEVER TILT STOP SUPPORT (PORT)	1
2	81394M	倾斜止动支撑杆(右舷)	LEVER TILT STOP SUPPORT (STARBOARD)	1
3	81868M	波形垫圈	WAVE WASHER	1
4	81947M	衬套	BUSHING	2
5	82131M	开口销	COTTER PIN	2
5	82132M	开口销	COTTER PIN	2
6	81980M	倾斜止动支撑套环	COLLAR TILT STOP SUPPORT	1
7	81396M	倒车锁	LOCK Reverse	1
7	97088T	倒挡锁	REVERSE LOCK	1
8	81397M	倒挡锁销	PIN REVERSE LOCK	1
8	41314M	轴	SHAFT	1
9	82130M	开口销	PIN COTTER	1
10	82103M	张力弹簧	SPRING TENSION	1
11	81398M	倒挡锁杆(短轴)	ROD REVERSE LOCK (SHORT SHAFT)	1
11	92653M	杆	ROD	1
12	82400M	螺母	NUT	1
12	82382M	螺母	NUT	1
13	81400M	调节U型夹	CLEVIS ADJUSTING	1
14	82138M	U型销	PIN CLEVIS	1
15	82752M	开口销	PIN COTTER	1
15	82128M	销	PIN	1
16	81909M	铆钉	RIVET	1
17	82159M	滚销	PIN ROLL	1
18	83904M	倾斜销总成	PIN ASSEMBLY Tilt	1
18	814972T	倾斜销	PIN-TILT	1
18	81389M	倾斜锁销总成	PIN ASSEMBLY Tilt Lock	1
18	814972T	倾斜销	PIN-TILT	1
19	84044M	止动器	STOPPER	1
19	81391M	止动板	PLATE Stopper	1
20	82145M	滚销	PIN ROLL	1
21	81395M	盖板	COVER	2
22	81399M	倒挡锁杆(长轴)	ROD REVERSE LOCK (LONG SHAFT)	1

图 37开关面板 SWITCH PANEL

REF	零件编号	中文名称	英文名称	数量
0-1	82993M	开关面板总成	SWITCH PANEL ASSEMBLY	1
1	82994M	主开关	MAIN SWITCH	1
2	81534M	阻风门开关	SWITCH CHOKE	1
3	82689M	停机开关总成	SWITCH ASSEMBLY Stop	1
3	97765M	停机开关总成	SWITCH ASSEMBLY Stop	1
4	81531M	止动器	STOPPER	1
4	97756M	止动器	STOPPER	1
5	81537M	线夹支架	BRACKET CORD CLAMP	1
6	82487M	螺钉	SCREW	1
6	82500M	螺钉(M4 x 8)	SCREW (M4 x 8)	1
7	82184M	锁紧垫圈	LOCKWASHER	1
7	82206M	锁紧垫圈	LOCKWASHER	1
8	82995M	开关面板	SWITCH PANEL	1
8	92661M	开关面板	SWITCH PANEL	1
9	80164M	螺钉	SCREW	4
10	82377M	螺母	NUT	4
11	82184M	锁紧垫圈	LOCKWASHER	4
11	82206M	锁紧垫圈	LOCKWASHER	4
12	82799M	垫圈	WASHER	4
12	82847M	垫圈	WASHER	4
13	84434M	外部线束总成	HARNESS ASSEMBLY (EXTERNAL)	1
13	81539M	线束总成	HARNESS ASSEMBLY	1
13	81539M	外部线束总成	HARNESS ASSEMBLY (EXTERNAL)	1
14	81527M	内部线束	WIRE (INTERNAL)	1
15	81538M	线束总成延长件(选配)	HARNESS ASSEMBLY Extension (OPT)	1

图 38节气门控制器 THROTTLE CONTROL

REF	零件编号	中文名称	英文名称	数量
1	81345M	CDI控制杆	LEVER C.D.I. CONTROL	1
2	81341M	U型夹锁止块	STOPPER CLEVIS LOCK	1
3	82976M	销	PIN	1
4	82367M	定位销	PIN DOWEL	1
5	82149M	滚销(18.5毫米)	PIN (18.5 mm) ROLL	4
6	81480M	油门线U型夹	CLEVIS THROTTLE CABLE	1
7	81350M	轴支架	BRACKET SHAFT	1
8	81946M	衬套	BUSHING	4
9	82423M	螺栓	BOLT	3
10	82199M	锁紧垫圈	WASHER LOCK	4
10	82214M	垫圈	WASHER	4
11	81942M	衬套	BUSHING	1
11	41311M	衬套	BUSHING	1
12	81403M	轴支架止动块	STOP SHAFT BRACKET	1
13	82074M	压缩弹簧	SPRING COMPRESSION	1
14	82330M	卡环	RING Snap	2
15	81346M	CDI控制杆	LEVER C.D.I. CONTROL	1
16	81347M	连接连杆轴	SHAFT LINK CONNECTING	1
17	82113M	扭力弹簧	SPRING TORSION	1
18	81344M	CDI控制杆	LEVER C.D.I. CONTROL	1
19	81349M	轴支架-上部	BRACKET SHAFT - UPPER	1
20	82154M	滚销	PIN ROLL	1
21	82977M	螺钉	SCREW	1
22	83050M	螺钉	SCREW	1
23	82381M	螺母	NUT	2
23	82390M	螺母 (M6)	NUT (M6)	2
24	81415M	盖帽	CAP	2
25	81348M	控制杆	ROD CONTROL	1
26	81225M	端盖	END	4
26	16715M	接头	JOINT	4
27	81333M	连杆	ROD LINK	1
28	82378M	螺母	NUT	1
28	82388M	螺母 (M5)	NUT (M5)	1
29	81334M	凸轮	CAM	1
30	81868M	波形垫圈	WAVE WASHER	1
31	81713M	螺栓	BOLT	1
32	81483M	遥控支架	BRACKET REMOTE CONTROL	1
33	81484M	线缆夹	CLAMP CABLE	1
34	82146M	滚销	PIN ROLL	1
35	82437M	螺栓	BOLT	1
36	82200M	垫圈	WASHER	1
36	82215M	锁紧垫圈	LOCKWASHER	1