Suzuki — DF-300 / 2023

Exploded diagrams and part specifications.

1Cylinder Head 2Cylinder Block 3Crankshaft 4Timing Chain 5Camshaft 6Intake Manifold 7Ring Gear Cover 8Exhaust Cover 9Fuel Injector 10Fuel Pump/Fuel Vapor Separator 11Water Pump 12Thermostat 13Throttle Body 14Oil Pump 15Oil Pan 16Clutch Shaft 17Clutch Rod 18Transmission 19Starting Motor 20Magneto 21Rectifier/Ignition Coil 22Sensorw/Transom (X or XX)23Sensor w/Transom (L)24Harness 25PTT Switch/Engine Control Unit 26Clamp Bracket w/Transom (X or XX)27Clamp Bracket w/Transom (L)28Swivel Bracket w/Transom (X or XX)29Swivel Bracket w/Transom (L)30Trim Cylinder w/Transom (X or XX)31Trim Cylinder w/Transom (L)32PTT Motor w/Transom (X or XX)33PTT Motor w/Transom (L)34Engine Holder 35Drive Shaft Housing w/Transom (X)36Drive Shaft Housing w/Transom (XX)37Drive Shaft Housing w/Transom (L)38Gear Case 39Side Cover w/Transom (X or XX)40Side Cover w/Transom (L)41Engine Cover 42Squeeze Pump 43Opt: Flush Mount Remocon 44Opt: Harness (1)45Opt: Harness (2)46Opt: Switch 47Opt: Top Mount Dual 48Opt: Top Mount Single 49Opt: Gasket Set 50Opt: Multi Function Gauge (1)51Opt: Multi Function Gauge (2)

Fig. 1Cylinder Head

REF	Part No.	Name	Qty
1	11101-98J10	HEAD ASSY,CYL S	1
2	09103-06266	Bolt (6x40)	16
3	09206-08001	Knock Pin (8x11)	14
4	01550-06207	BOLT	4
5	11103-98J10	HEAD ASSY,CYL P	1
6	09103-06266	Bolt (6x40)	16
7	09206-08001	Knock Pin (8x11)	14
8	01550-06207	BOLT	2
9	11116-93J01	Plug	4
10	11141-98J10	Starboard Cylinder Head Gasket	1
11	11142-98J10	Port Cylinder Head Gasket	1
12	11216-98L10	Gasket	4
13	11261-93J00	Protection Anode Cover	4
14	09280-22019	O-Ring	4
15	55321-87J01	Aluminum Anode	4
16	09103-06281	Bolt (6x14)	4
17	01550-0820C	BOLT	4
18	01550-08607	BOLT	5
19	01550-08607	BOLT	4
20	09206-14004	Pin (14x11.4x23)	4
21	11170-93J01	Cylinder Head Cover - Starboard (NLA)	1
22	11180-98J01	Port Cylinder Head Cover	1
23	11173-93J00	Breather Plate - Starboard (NLA)	1
24	11183-93J00	Breather Plate - Port (NLA)	1
25	11179-93J00	Cylinder Head Cover Gasket - Starboard	1
26	11189-93J00	Cylinder Head Cover Gasket - Port	1
27	09206-08001	Knock Pin (8x11)	1
28	02112-0612A	SCREW	14
29	01547-0625C	Bolt	16
30	01547-0650C	01547-0650C	6
31	11382-93J00	Oil Filler Cap	1
32	09280-26006	O-Ring	1
33	09482-00427	NGK BKR6E Spark Plug	6
34	11291-93J00	Engine Hook	2
35	01550-08207	BOLT	4
36	11115-93J10-001	Valve Guide (OS:0.5)	24
37	11291-98J00	Engine Hook	1

Fig. 2Cylinder Block

REF	Part No.	Name	Qty
1	11293-98J00	Front Engine Hook	1
2	01550-0820C	BOLT	2
3	11301-98J40	Cylinder Block Set	1
4	11112-93J00	Oil Venturi Plug	2
5	11117-93J10	Crankcase Bolt	12
6	11117-98J10	Crankcase Stud Bolt	4
7	11119-93J00	Cylinder Head Bolt	16
8	11216-98L00	Gasket	3
9	09248-26001	M26 Oil Gallery Plug	3
10	09160-18031	Exhaust Plug Gasket	2
11	09248-18006	Exhaust Plug	2
12	09159-10116	Crankcase Nut	4
13	09206-13019	Knock Pin	5
14	16700-93J00	Piston Jet Valve	1
15	09280-10009	O-Ring	1
16	09280-10016	O-Ring	1
17	07130-0616B	BOLT	1
18	07130-0510A	BOLT	6
19	11390-98J00	Piston Cooling Jet	6
20	09280-06005	O-Ring	6
21	09246-04009	Plug	1
22	11330-93J01	Crankcase Water Jacket Cover	1
23	11332-93J00	Crankcase Water Jacket Cover Gasket	1
24	01550-0620C	BOLT	12
25	16430-93J00	Oil Gallery Cover (NLA)	1
26	16431-93J00	Oil Gallery Plate	1
27	16433-93J00	Oil Gallery Gasket	2
28	01550-0835A	BOLT	9
29	01550-0845C	Bolt	8
30	16510-96J11	Engine Oil Filter	1

Fig. 3Crankshaft

REF	Part No.	Name	Qty
1	12111-98J00-0B0	Piston	6
2	12140-98J10	Piston Ring Set	6
3	12151-02F00	Piston Pin	6
4	09381-22010	Piston Pin Circlip	12
5	12160-98J00	Connecting Rod Assembly	6
7	12220-98J00	Crankshaft	1
10	12242-98J00	Drive Gear	1
11	09160-10104	Drive Gear Washer (NLA)	1
12	01550-1025A	BOLT	1
13	09283-91001	Crankshaft Oil Seal	1
14	12100-98J00-050	Piston & Ring Set (OS:.050)	6
15	12140-98J10-050	Piston Ring Set (OS:0.50)	6

Fig. 4Timing Chain

REF	Part No.	Name	Qty
1	12730-98J02	Driven Gear	1
2	09262-40021	Bearing (40x80x18)	1
3	09262-40017	Bearing (40x80x18)	1
4	09283-32044	Oil Seal (32x47x6)	1
5	12734-93J00	Driven Gear Holder	1
6	09280-70012	O-Ring	1
7	01550-0855A	BOLT,EGR VALVE	4
8	12761-93J00	1st Timing Chain	1
9	12762-93J00	2nd Timing Chain	2
10	12770-93J00	Timing Chain Guide Base	1
11	12778-93J00	Guide Base Gasket	1
12	04211-13149	PIN	2
13	01550-0830A	BOLT	2
14	12771-93J00	Timing Chain Upper Shoe	1
15	12775-93J00	Timing Chain Lower Shoe	1
16	12772-93J00	Timing Chain Guide	1
17	01550-0830A	BOLT	2
18	12810-93J00	Timing Chain Tensioner Assembly	1
19	12813-73G00	Timing Chain Tensioner Pad	1
20	12812-90J00	Timing Chain Tensioner Spacer	1
21	01550-0830A	BOLT	1
22	12831-93J01	Tensioner Adjuster Assembly	1
23	12832-93J00	Starboard Tensioner Assembly	1
24	12833-93J00	Port Tensioner Assembly	1
25	01550-0620A	BOLT	2
26	01550-0620A	BOLT	4

Fig. 5Camshaft

REF	Part No.	Name	Qty
1	12701-98J20	Starboard Intake Camshaft	1
2	12705-98J10	Port Intake Camshaft	1
3	12721-98J10	Starboard Exhaust Camshaft	1
4	12729-98J20	Port Exhaust Camshaft	1
5	12740-93J00	Cam Timing Sprocket Assy	2
6	12748-93J00	Exhaust Camshaft Sprocket	2
7	12753-93J00	Intake Camshaft Bolt	2
8	12749-93J00	Exhaust Camshaft Bolt	2
9	09202-05032	Pin (5x12)	3
10	09261-05006	Pin (5x18)	1
11	16550-93J00	Oil Control Valve	2
12	16555-93J10	GASKET,OCV	2
13	01550-06257	BOLT	8
14	12891-93J10	TAPPET	24
16	12911-98J00	Intake Valve	12
17	12915-93J60	Exhaust Valve	12
18	12921-93J11	Valve Spring	24
19	12931-78G00	Valve Spring Retainer	24
20	12932-24400	Valve Cotter	48
21	12933-69G10	Valve Spring Seat	24
22	09289-05006	Valve Stem Seal	24

Fig. 6Intake Manifold

REF	Part No.	Name	Qty
1	13110-98J10	Intake Manifold	1
2	13119-98J00	Intake Manifold Gasket	2
3	09108-08282	Stud Bolt	4
4	09103-08437	Bolt (8x65)	4
5	09159-08136	Nut	4
6	09160-08161	Washer (8.2x23x3.2)	8

Fig. 7Ring Gear Cover

REF	Part No.	Name	Qty
1	11510-98J03	COVER COMP,RING	1
2	11174-98J01	HOSE,BREATHER	1
3	11176-98J00	Breather Union	1
4	11514-98J00	Ring Gear Cover Plate	1
5	13710-98J00	Flame Arrester	1
6	13811-98J00	Upper Cover Silencer	1
7	09401-18410	Clip	2
8	01550-06127	BOLT	4
9	01550-06207	BOLT	5
10	11517-98J00	Screw	3
11	11515-93J00	Ring Gear Cover Brace	1
12	13841-98J10	Air Duct Starboard Guard	1
13	13851-98J10	Air Duct Port Guard	1
14	01550-0620C	BOLT	4
15	01550-0620C	BOLT	2
16	01550-0640C	Bolt	1
17	01550-0835C	Bolt	2
18	69711-93E11	Label (S.I.G.P)	1
19	61494-93J01	Oil & Clearance Label	1

Fig. 8Exhaust Cover

REF	Part No.	Name	Qty
1	14141-93J02	COVER,EXHAUST S	1
2	14140-98J01	Port Exhaust Cover	1
3	14151-93J00	Starboard Exhaust Cover Gasket	1
4	14152-93J01	GASKET,EXH CVR(	1
5	11261-93J00	Protection Anode Cover	2
6	55321-87J01	Aluminum Anode	2
7	09103-06281	Bolt (6x14)	2
8	09280-22019	O-Ring	2
9	01550-0820C	BOLT	2
10	01550-06257	BOLT	23

Fig. 9Fuel Injector

REF	Part No.	Name	Qty
1	15681-93J02	HOSE,FUEL(3 WAY	1
2	15710-96J00	Fuel Injector	6
3	15717-16G00	O-Ring	6
4	15735-58B00	Delivery Pipe Insulator	4
5	15751-93J00	Delivery Pipe	2
6	15756-93J02	Fuel Hose (Delvery Pipe to Delivery Pipe)	1
7	15762-93J00	Delivery Pipe Gasket	5
8	15830-77EA0	Delivery Pipe Union	1
9	15831-93J01	UNION,DELIVERY	2
10	18498-93J01	Fuel Hose Protector (L:340)	1
11	09247-14041	Delivery Pipe Plug	1
12	09320-08062	Cushion	6
13	09360-14009	Delivery Pipe Union Bolt	1
14	09401-11425	Clip	4
15	09403-16307	CLAMP	1
16	09408-00105	Clamp	1
17	09408-00155	Clamp (NLA)	1
18	01550-0840C	Bolt	4
19	15680-93J40	Fuel Hose (Inlet to Filter)	1
20	09401-14409	Clip	1
21	09408-00135	Clamp (NLA)	2
22	15684-98J00	Fuel Hose Guide	1
23	01550-0612C	BOLT	2
24	09251-09009	PLUG	1

Fig. 10Fuel Pump/Fuel Vapor Separator

图 147燃油泵/燃油蒸汽分离器 Fuel Pump/Fuel Vapor Separator Fig.

REF	Part No.	Name	Qty
1	15100-98J00	Fuel Pump (L)	1
2	15410-93J11	Fuel Filter Assembly	1
3	15411-93J10	Fuel Filter Cap	1
4	15415-93J10	Fuel Filter O-Ring	1
5	15412-93J10	Fuel Filter Element	1
6	15413-93J10	Fuel Filter Cup	1
7	15644-93J00	Fuel Filter Cover	3
8	15633-93J20	Fuel Hose (H)	1
9	09343-75002-600	Hose (7.5x13.5x600)	1
10	15440-93J10	FILTER,FUEL	1
11	09320-08501	Cushion	2
12	15773-90J10	UNION,FUEL HOSE	1
13	15830-93J00	3 Way Union	1
14	09169-06093	Washer	3
15	15770-93J00	Fuel Cooler	1
16	09168-12013	Gasket	3
17	09360-12008	Union Bolt	1
18	09363-08004	Union	1
19	15600-98J50	SEPARATOR ASSY,	1
20	13370-93J10	Needle Valve Assembly	1
21	15626-93J00	VST Seal	1
22	15650-93J00	Float Assembly	1
23	15200-87820	Fuel Pump Assembly	1
24	15647-93J00	Fuel Pump Bushing	1
25	15641-90J00	Fuel Pump Spacer	1
26	15642-90J00	Fuel Pump Filter	1
27	15654-99E00	Float Pin	1
28	02142-0408B	SCREW	1
29	02112-05107	5 X 10 CROSS SC	1
30	15760-93J01	Fuel Pressure Regulator	1
31	15628-99E00	Screw (L:15)	6
32	15627-93J00	Screw (NLA)	1
33	09320-12094	CUSHION,SLCNR B	3
34	15675-93J00	Cooler Bracket Bolt	3
35	09343-75002-600	Hose (7.5x13.5x600)	1
36	09401-11414	Clip	14
37	15636-93J30	Fuel Hose (L)	1
38	15686-93J00	Fuel Hose Clip	1
39	15672-93J10	Fuel Cooler Bracket	1
40	01500-06167	BOLT	4
41	15635-93J30	Fuel Hose (H)	1
42	15632-93J30	Fuel Hose (H)	1
43	15673-98J00	Fuel Filter Bracket	1
44	01550-06257	BOLT	2
45	15643-93J00	Fuel Filter (L)	1
46	09343-75002-600	Hose (7.5x13.5x600)	1
47	15634-93J20	Fuel Hose (H)	1
48	09116-06525	Bolt	3
49	15674-93J00	Check Valve Bracket	1
50	15645-93J00	Check Valve	1
51	15637-93J30	Fuel Hose (L)	1
52	15629-99E10	Drain Screw	2
53	15683-87J00	Drain Hose (L:120)	1
54	02112-0406B	SCREW	3
55	09343-70503-600	Fuel Hose (7x12x600)	1
56	09401-11423	Clip	2
57	18498-90J61	Protector (15.4x18.4x70)	1
58	09169-06062	Washer (6.3x17x1.6)	2
59	09116-06202	Bolt w/Washer (6x25)	2
60	15671-93J00	Vapor Separator Bracket (NLA)	1
61	01550-06357	BOLT	2
62	09169-08042	Washer	6
63	01550-0840C	Bolt	3
64	18417-93J00	Purge Valve Bracket	1
65	01550-0612C	BOLT	2
66	18117-52G10	Evap Purge Valve Assy	1
67	09352-50003-080	HOSE(5X8.2X080)	1
68	13671-02F00	Clip	1
69	15114-93J00	Fuel Pump Bracket No. 1	1
70	15115-93J00	Fuel Pump Bracket No. 2	1
71	15695-98L00	Evaporation Union	1
72	09352-50003-00A	Hose (5x8.2x1000)	1
73	09401-08412	Clip	1
74	09408-00056	Clip	1
75	18498-87JC1	Protector (L:450)	1
76	18498-87J01	PROTECTOR,EVAP	1
77	15118-93J00	Bolt	1
78	08316-10067	Nut	1
79	09408-00105	Clamp	1
80	15141-93J00	COVER,FUEL PUMP	1

Fig. 11Water Pump

REF	Part No.	Name	Qty
1	17410-93J01	Water Pump Case	1
2	17413-93J02	Water Pump Case Sleeve	1
3	17416-93J01	Water Pump Seal Ring	1
4	17461-93J02	IMPELLER,WATER	1
5	17471-98J02	Water Pump Plate	1
6	17472-98J00	Water Pump Plate Gasket	1
7	17473-98J00	Water Pump Plate No. 2	1
9	17562-93J01	Upper Water Tube Bushing	1
10	17563-93J01	Lower Water Tube Bushing	1
11	17564-93J01	Water Pump Case Bushing	1
12	17612-93J00	Water Tube Spacer	1
13	17631-93L10	Port Side Water Filter	1
14	17632-93L10	Starboard Side Water Filter	1
15	29116-93J00	Bolt (6x20)	2
16	09116-08131	Bolt (8x45)	4
17	09132-04034	Screw (4x18)	1
18	09202-06031	Knock Pin (6x12)	2
19	09420-05009	Water Pump Key	1
20	09168-20002	Gasket (20.5x30x1.5)	1
21	17633-93L00	Water Filter Cover	1
22	17400-98J06	Water Pump Repair Kit DF250SS/250AP/300/300AP	1
23	17416-93J01	Water Pump Seal Ring	1
24	17461-93J02	IMPELLER,WATER	1
25	17471-98J02	Water Pump Plate	1
26	17472-98J00	Water Pump Plate Gasket	1
27	17473-98J00	Water Pump Plate No. 2	1
28	09420-05009	Water Pump Key	1
29	17413-93J02	Water Pump Case Sleeve	1

Fig. 12Thermostat

REF	Part No.	Name	Qty
1	11196-93J00	Water Return Hose	1
2	11197-93J00	Water Return Hose	1
3	11270-93J00	Cylinder Block Water Jacket Plate	1
4	11272-93J00	Cylinder Block Plate Gasket	1
5	17581-93J00	Water Outlet Pipe	2
6	17582-93J00	Water Outlet Pipe Gasket	2
7	17611-90J00	Water Pressure Valve Cover	1
8	17660-99E01	Water Pressure Valve	1
10	17681-93J00	Thermostat Cover	2
11	17711-90J00	Water Hose 3 Way	1
12	17712-93J01	HOSE,WATER(3 WA	1
13	09116-06121	Bolt (6x25)	2
14	09280-26006	O-Ring	1
15	09320-12093	CUSHION	1
16	09352-50006-600	Hose (5x9x600)	1
17	09352-50006-600	Hose (5x9x600)	1
18	09352-50006-600	Hose (5x9x600)	1
19	09352-50006-600	Hose (5x9x600)	1
20	09352-50006-600	Hose (5x9x600)	1
21	09352-50006-600	Hose (5x9x600)	1
22	09352-50006-600	Hose (5x9x600)	1
23	09352-50006-00B	Hose (5x9x2000)	1
24	09352-50006-00B	Hose (5x9x2000)	1
25	01550-0812C	01550-0812C	1
26	09367-06002	3 Way	1
27	09401-08413	Clip	18
28	09401-14409	Clip	2
29	09401-25406	Clip	4
30	09403-25304	Clamp (NLA)	1
31	09408-00008	Clamp	1
32	09408-00056	Clip	1
33	01550-0620C	BOLT	6
34	01550-0620C	BOLT	4
35	01550-0625C	BOLT	10
36	17713-98J01	HOLDER,WATER HO	1
37	09401-15414	Clip	2
38	17915-98J02	HOSE,WATER FLUS	1
39	09408-00024	Clamp	1
40	09408-00021	Clamp (NLA)	1
41	36617-93J10	Harness Bracket	1
42	01550-0612C	BOLT	1

Fig. 13Throttle Body

REF	Part No.	Name	Qty
1	11193-98J01	HOSE,PCV	1
2	11198-98L00	SEAL,PCV VALVE	1
3	13100-98J20	COLLECTOR ASSY	1
4	13137-98J00	Collector Spacer	4
5	13140-98J10	Collector Cover	1
6	13147-98J00	Collector Cover Gasket	1
7	13180-98J01	Collector Funnel	2
8	18590-68H00	MAP Sensor	1
9	09280-10009	O-Ring	8
10	01550-08167	BOLT	4
11	01550-08357	BOLT	11
12	09103-05028	BOLT,PRESSURE S	2
13	04211-11129	11 X 12 DOWEL P	8
14	13134-98J00	Collector Bracket	1
15	13139-98J01	Collector Gasket	1
16	13310-98J01	Throttle Body Assembly	1
17	13343-98J20	GASKET,THROTTLE	1
18	13315-98J11	DAMPER,THROTTLE	1
19	13421-98L00	GASKET,THROTLE	1
20	13813-98J01	GROMMET,THROTTL	1
21	09401-14409	Clip	2
22	18118-93J00	PCV Valve	1
23	09103-08370	Bolt (8x250)	6
24	09320-08517	CUSHION,CABLE H	4
25	09403-13310	Clamp	1
26	09408-00155	Clamp (NLA)	1
27	01421-08357	BOLT,STUD	2
28	01550-0816C	Bolt	5
29	01550-0835C	Bolt	2
30	01550-0860C	Bolt	2
31	04211-11129	11 X 12 DOWEL P	2
32	09159-08136	Nut	4
33	08316-1008C	Nut	2
34	09160-08161	Washer (8.2x23x3.2)	2

Fig. 14Oil Pump

REF	Part No.	Name	Qty
1	12632-93J11	Oil Pump Drive Sprocket	1
2	16113-93J10	Oil Pump Driven Sprocket	1
3	16400-93J20	Oil Pump Assembly	1
4	16520-93J00	Oil Pump Strainer	1
5	16760-93J00	Oil Pump Chain	1
6	16781-93J00	Oil Pump Chain Tensioner	1
7	16782-93J00	Oil Pump Tensioner Spring	1
8	16783-93J01	Oil Pump Tensioner Bolt	1
9	09181-12158	Washer (12x20x0.5)	1
10	09280-22020	O-Ring	2
11	01550-0616A	BOLT	3
12	01550-0845A	BOLT	1
13	01550-0865A	BOLT	3
14	01550-0885A	BOLT	1
15	08110-60020	B1 15X32X9 BEAR	1

Fig. 15Oil Pan

REF	Part No.	Name	Qty
1	11261-93J10	Protection Anode Cover	1
3	29103-93J30	Bolt (8x25)	1
4	09103-06281	Bolt (6x14)	1
5	09280-22019	O-Ring	1
6	11489-93J00	Oil Pan Gasket	1
8	11591-93J11	Oil Pan Union	1
10	14154-93J02	Exhaust Tube Seal	1
11	14211-98J00	Exhaust Tube	1
12	14212-93J00	Exhaust Tube Gasket	1
13	29116-93J00	Bolt (6x20)	4
14	11435-93J01	PIPE,EXHAUST RE	1
15	09168-12012	Oil Drain Plug Gasket	1
16	09248-12009	Oil Drain Plug	1
17	09202-08006	Knock Pin (8x12)	2
18	09202-08006	Knock Pin (8x12)	2
19	01550-1050A	BOLT	4
20	09116-08128	Bolt (8x40)	10
21	09116-10175	Bolt (10x50)	2
22	09116-10146	Bolt (10x195)	2
23	09116-10187	BOLT	2
24	29103-93J00	Bolt (6x12)	1
25	29404-93J11	Clamp (L:65)	1
26	16910-93J00	Oil Level Gauge	1
27	16930-93J00	Oil Level Gauge Guide	1
28	09280-09008	O-Ring	1
29	01550-0612C	BOLT	1

Fig. 16Clutch Shaft

REF	Part No.	Name	Qty
1	21110-98J02	Clutch Lever	1
2	21131-93J00	Clutch Lever Bushing	1
3	21151-93J00	Clutch Lever Holder	1
4	09160-10148	Washer (10x20x3)	1
5	21210-98J01	Clutch Shaft	1
6	21230-98J01	Clutch Shaft Arm	1
8	23115-98J00	Clutch Lever Link	1
9	25223-96J00	Seal, Shift Rod Dust	1
10	09160-06094	Washer (6.5x15x1.0)	2
11	09204-01006	Cotter Pin	2
12	09205-10006	Pin (10.2x10)	1
13	09248-12011	Plug (12x9)	1
14	09260-10005	Ball	1
15	09262-17019	Bearing (17x35x8)	1
16	09289-18001	Clutch Shaft Seal	1
17	09306-06005	Bushing	2
18	09306-10001	Bushing	3
19	09383-08004	E Ring	1
20	09440-07051	Spring	1
21	01550-0620C	BOLT	1
22	02142-05107	SCREW	2
23	08331-41359	Circlip	1
24	21241-98J10	Clutch Lever Link No. 2	1
25	67467-89J01	Cable Connector	1
26	67471-99E00	Remote Control Nut	1
27	09160-06055	Washer (7x12x1.0)	2
28	09385-06012	Clip	2
29	19115-98J10	Clutch Lever Holder	1
30	01550-0855C	Bolt	2
31	67467-89J10	Cable Connector	1
32	67471-99E10	Remote Control Nut	1

Fig. 17Clutch Rod

REF	Part No.	Name	Qty
2	25130-93L00	Shifter Yoke	1
3	25232-90J00	Gear Case Magnet	2
4	09205-03004	Spring Pin (3x20)	1
6	25222-90J01	Shift Guide Cover Seal	1
7	09283-10011	Oil Seal (10x22x8)	1
8	25321-93L00	Horizontal Shift Slider	1
9	29116-93J00	Bolt (6x20)	3
10	09160-10082	Washer (10.5x19x2.0)	1
11	25113-93L20	GEAR,SHIFT ROD	2
12	25215-93L00	Magnet Housing	1
13	09383-07003	E Ring	3
14	55122-93L00	Shift Rod Guide Housing Seal	1
15	56141-93L00	Shift Slider Housing	1
16	17637-93L00	Port Front Side Water Filter	1
17	17638-93L00	Stdb Front Side Water Filter	1
18	55321-87J01	Aluminum Anode	1
19	01550-06357	BOLT	2
20	09103-06281	Bolt (6x14)	1
21	09206-09012	Knock Pin	2
22	09132-04034	Screw (4x18)	1
23	25231-93L00	Magnet Holder	2
24	25232-94300	Gear Case Magnet	2

Fig. 18Transmission

REF	Part No.	Name	Qty
2	57133-93L00	Drive Shaft Collar	1
3	57134-93J00	Drive Shaft Bearing Spacer	1
4	09159-28003	Drive Shaft Bearing Nut	1
5	09269-32002	Bearing (32x66x49)	1
6	57300-93L20	Pinion & Gear Set	1
8	09140-16026	Nut 16mm	1
9	08221-16256	Washer	1
10	09180-32006	Spacer (32.4x40x3)	1
12	09160-60012	Washer (60x72x3)	1
13	09263-80002	Bearing (80x105x4)	1
16	09265-30033	Bearing (30x72x28.75)	1
17	57610-93L10	Propeller Shaft Assembly	1
18	57621-93L00	Clutch Dog Shifter	1
19	09202-08013	Clutch Dog Shifter Pin	1
20	57631-93L01	Connector Pin	1
21	09440-58001	Clutch Dog Spring	1
22	57617-93L00	Detent Spring	1
23	06111-07004	STEEL BALL 7/32	2
24	06111-11004	BALL	2
25	56120-93L30	HOUSING COMP,PR	1
26	09263-30063	Bearing (30x40x25)	1
27	09265-32003	Bearing (32x58x17)	1
28	09280-00047	O-Ring	1
29	09280-80001	O RING	1
30	09282-30006	Oil Seal (30x45x6)	2
31	09381-40003	Circlip	1
32	56147-93L00	Prop Shaft Bearing Housing Spacer	1
33	56130-93J02	Drive Shaft Bearing Housing	1
34	09280-66004	O-Ring	1
35	09282-24004	Oil Seal (24x40x7)	2
36	09381-40003	Circlip	1
37	57622-93L00	Forward Thrust Spacer	1
38	09164-50002	Wave Washer	1
39	09381-72003	Snap Ring	1
40	09140-48001	Nut	1
41	56122-93L00	Prop Shaft Bearing Housing Stopper	1
42	56126-93L10	Prop Shaft Bearing Housing Washer No. 1	1
43	56127-93L00	Prop Shaft Bearing Housing Washer No. 2	1
44	56128-93L00	Prop Shaft Bearing Housing Seal	1
45	56129-93L00	Stopper Bushing	1
46	09280-00050	O-Ring	1
47	57527-93L00	Bearing Inner Spacer	1
48	57541-93L00	Bearing Outer Spacer	1
49	09265-50004	Bearing (50x80x20)	1
50	09265-55001	Bearing (55x100x22.75)	1

Fig. 19Starting Motor

REF	Part No.	Name	Qty
1	31100-98L10	Starter Motor Assembly	1
2	31150-98L00	Gear Case	1
3	31170-92J00	Rear Housing	1
4	31173-98L00	Brush Holder Assembly	1
5	31191-63J00	Lever Assembly	1
6	31220-98L10	Switch Assembly	1
7	31311-63J00	Armature	1
8	31192-92J00	Screw Set	1
9	31261-75F10	Through Bolt	2
10	31340-98L00	Starting Motor Clutch Set	1
11	31313-86030	Stopper Set	1
12	31320-98L00	Pinion Assembly	1
13	31341-98L00	Pinion Shaft	1
14	31343-63J00	Internal Gear	1
15	31344-63J00	Planetary Gear	3
16	31912-93J01	Starting Motor Band	1
17	31918-92J01	Lower Damper	1
18	01550-08207	BOLT	2
19	01550-08307	BOLT	2
20	36645-93J00	Wire Lead	1

Fig. 20Magneto

REF	Part No.	Name	Qty
1	32102-98J40	FLYWHEEL COMP,M	1
2	09103-12125	Flywheel Bolt (12x26)	8
3	09202-06031	Knock Pin (6x12)	1
4	32120-93J10	COIL,BATTERY CH	1
5	32131-93J00	Stator Connector Holder (NLA)	1
6	01550-0616C	BOLT	2
7	32160-88L01	CKP/Ignition Timimg Coil	1
8	09106-05030	Bolt (5x10)	2
9	33220-98J00	Cam Position Sensor	3
10	33221-42F00	O-Ring	3
11	01550-0616C	BOLT	3
12	09103-06231	Bolt (6x35)	4
13	09403-13413	CLAMP	2
14	01550-0612C	BOLT	2

Fig. 21Rectifier/Ignition Coil

图 310整流器/点火线圈 Rectifier/Ignition Coil Fig.

REF	Part No.	Name	Qty
1	32800-98J01	Rectifier & Regulator Assembly	1
2	32805-93J00	Rectifier & Regulator O-Ring	2
3	32890-98J01	Electric Parts Holder	1
4	09160-06134	Washer (6.5x24x1.6)	1
5	09169-06062	Washer (6.3x17x1.6)	3
6	09320-09016	Cushion	3
7	09116-06202	Bolt w/Washer (6x25)	3
8	09320-12095	CUSHION	1
9	01550-0612C	BOLT	1
10	01550-0625C	BOLT	4
11	33410-93J00	Ignition Coil Assembly	6
12	01550-0620C	BOLT	6
13	09408-00021	Clamp (NLA)	1

Fig. 22Sensorw/Transom (X or XX)

图 315A带艉板传感器(X或XX) Sensorw/Transom (X or XX) Fig.

REF	Part No.	Name	Qty
1	13650-52G00	Inlet Air Temp Sensor	1
2	13655-87J01	Air Temp Sensor Grommet	1
3	29103-93J00	Bolt (6x12)	1
4	34830-87J20	Temp Sensor Assy	2
5	34830-87J20	Temp Sensor Assy	1
6	34840-98J03	Trim Sensor Assembly	1
7	37820-98J00	Oil Pressure Sensor	1
8	09125-06063	Screw (6x10)	1
9	09403-13413	CLAMP	1
10	29404-93J11	Clamp (L:65)	1
11	09407-14407	Clamp (L:140)	2
12	34841-88L01	Trim Sensor Lever	1
13	34845-88L02	Trim Sender Bracket	1
14	09140-05005	Nut	1
15	09136-05041	Screw (5x20)	1
16	09160-05029	Washer (5.5x10x0.8)	1
17	01550-06207	BOLT	2
18	18213-98J30	Oxygen Sensor	1
19	09403-07340	Clamp	1
20	11218-98J02	Temp Sensor Holder	1
21	11219-98J00	Oil Sensor Holder	1
22	34830-98J00	Oil Temp Sensor	1

Fig. 23Sensor w/Transom (L)

图 315B带艉板传感器(L) Sensor w/Transom (L) Fig.

REF	Part No.	Name	Qty
1	13650-52G00	Inlet Air Temp Sensor	1
2	13655-87J01	Air Temp Sensor Grommet	1
3	29103-93J00	Bolt (6x12)	1
4	34830-87J20	Temp Sensor Assy	2
5	34830-87J20	Temp Sensor Assy	1
6	34840-98J11	Trim Sensor Assembly	1
7	37820-98J00	Oil Pressure Sensor	1
8	09103-06307	Bolt (6x10)	1
9	09403-13413	CLAMP	1
10	29404-93J21	CLAMP	1
11	09407-14407	Clamp (L:140)	2
12	34841-96J00	Trim Sensor Lever	1
13	34845-96J00	Trim Sensor Bracket	1
14	09136-05041	Screw (5x20)	1
15	09160-05029	Washer (5.5x10x0.8)	1
16	01550-06207	BOLT	2
17	18213-98J30	Oxygen Sensor	1
18	09403-07340	Clamp	1
19	11218-98J02	Temp Sensor Holder	1
20	11219-98J00	Oil Sensor Holder	1
21	34830-98J00	Oil Temp Sensor	1
22	34813-93J00	Lead Wire Protector (NLA)	1
23	36611-96J01	Trim Sensor Wire	1
24	43117-96J00	Trim Sender Cam	1
25	09116-05010	Bolt (5x12)	2
26	43118-96J00	Trim Sender Cam Plate	1

Fig. 24Harness

REF	Part No.	Name	Qty
1	33810-98J01	Starter Motor Cable Assembly	1
2	08316-10087	Nut	1
3	36610-98JA1	HARNESS ASSY,WI	1
4	09481-10501	10 Amp Fuse	2
5	36612-98J10	Regular Rotation Selector	1
6	36721-98L10	Upper Cover O-Ring	1
7	36737-98L00	Fuse Puller	1
8	36738-98L00	Fuse Case Upper Cover	1
9	09320-08510	Cushion (8.5x20x8)	2
10	38860-76F01	Relay	1
11	38860-76F01	Relay	1
12	09481-15504	15 Amp Fuse	4
13	09481-30504	30 Amp Fuse	3
14	09481-40403	40 Amp Fuse	1
15	09481-60403	60 Amp Fuse	2
16	36612-96J01	CAP,TERMINAL	1
17	08310-00067	Nut	1
18	08321-01067	Lock Washer	1
19	36617-93J00	Harness Bracket	3
20	36617-93J10	Harness Bracket	8
21	36617-98J00	Harness Bracket (NLA)	1
22	01550-0612C	BOLT	13
23	09403-20308	Clip	1
24	09407-14407	Clamp (L:140)	4
25	09408-00008	Clamp	2
26	09408-00184	Clamp	3
27	09408-00012	Clamp	1
28	09408-00008	Clamp	1
29	01550-06127	BOLT	1

Fig. 25PTT Switch/Engine Control Unit

图 326动力升降倾斜开关/发动机控制单元 PTT Switch/Engine Control Unit Fig.

REF	Part No.	Name	Qty
2	13575-40F00	O-Ring	1
3	37729-96L00	Shift Sensor Lever	1
4	09160-05029	Washer (5.5x10x0.8)	1
5	07130-05167	BOLT	1
6	08321-0105A	Lock Washer	1
7	37721-93J00	Neutral Switch Assembly	1
8	09137-04004	Screw (4x16)	2
9	09407-10404	Clamp (L:100)	2
10	37725-93J11	Switch Assembly Cover	1
11	37850-92J00	PTT Switch Assembly	1
12	37856-92J00	PTT Switch Tape	1
13	37857-92J01	PTT Switch Bushing	1
15	01550-0612C	BOLT	1
16	37722-93J14	Tilt Limit Switch Assembly	1
17	09403-09330	Clamp, Trim Limit	1
18	29125-93J00	Screw	1
19	38410-93J13	PTT Relay Assembly	1
20	38415-93J00	PTT Relay Holder	1
21	01550-06127	BOLT	1
22	09407-30401	Clamp	1
23	33930-98JL0	Engine Control Unit	1
24	33925-98J00	ECU Cushion	1
25	38890-98J12	Shift Actuator Assembly	1
26	38892-98J01	Shift Actuator Damper	1
27	38895-98J00	Shift Actuator Bracket	1
28	01550-0616C	BOLT	2
29	01550-06357	BOLT	3
30	38860-76F01	Relay	2
31	38915-90J00	Relay Holder	2

Fig. 26Clamp Bracket w/Transom (X or XX)

图 335A带艉板夹紧支架(X/XX型) Clamp Bracket w/Transom (X or XX) Fig.

REF	Part No.	Name	Qty
3	41117-93J02	Clamp Bracket Lower Starboard Plate	1
4	41122-93J02	Clamp Bracket Lower Port Plate	1
5	09125-06063	Screw (6x10)	4
6	41130-93J12	Clamp Bracket Shaft	1
7	41135-93J11	Clamp Bracket Shaft Washer	1
8	09159-22006	Nut	1
10	09159-12062	Transom Nut	6
11	09160-13022	Washer	4
12	09160-13021	Washer	6
13	41155-93J02	Transom Plate	2
14	55320-94910	ANODE SET	1
15	09116-06121	Bolt (6x25)	2
16	45421-87D03	Tilt Lock Pin	1
17	09159-14020	Nut (14mm)	2
18	48140-93J01	Tilt Limit Switch Cam	1
19	48144-93J00	Tilt Limit Switch Holder	1
20	09103-06278	Bolt (6x25)	2
21	55321-94910	Magnesium Anode	1
22	48145-93J00	Tilt Limit Switch Cover	1
23	36894-87D00	Wire Lead (L:195)	1
24	09125-06063	Screw (6x10)	2

Fig. 27Clamp Bracket w/Transom (L)

图 335B带艉板夹紧支架(L型) Clamp Bracket w/Transom (L) Fig.

REF	Part No.	Name	Qty
3	41130-92J03	Clamp Bracket Shaft	1
4	41135-92J00	Clamp Bracket Shaft Washer	1
5	09159-22006	Nut	1
7	09159-12062	Transom Nut	6
8	09160-13021	Washer	6
9	09160-13022	Washer	4
10	41155-93J02	Transom Plate	2
11	55320-94910	ANODE SET	1
12	09116-06121	Bolt (6x25)	2
13	48140-93J01	Tilt Limit Switch Cam	1
14	48144-93J00	Tilt Limit Switch Holder	1
15	09103-06278	Bolt (6x25)	2
16	48145-93J00	Tilt Limit Switch Cover	1
17	55321-94910	Magnesium Anode	1
18	41117-93L00	Clamp Bracket Lower Starboard Plate	1
19	41122-93L00	Clamp Bracket Lower Port Plate	1
20	03542-0516C	Screw	4
21	09160-05053	Washer	4

Fig. 28Swivel Bracket w/Transom (X or XX)

图 336A带船尾板旋转支架(X/XX型) Swivel Bracket w/Transom (X or XX) Fig.

REF	Part No.	Name	Qty
1	22511-99011	Grease Nipple	4
2	36894-87D00	Wire Lead (L:195)	1
4	43114-93J00	Swivel to Clamp Bracket Washer	2
5	43211-93J11	Clamp Shaft Swivel Bushing	2
6	43711-97E11	Steering Bushing	2
8	09125-06063	Screw (6x10)	1
9	09160-39001	Washer (39.5x64x1.0)	2
10	09181-39001	Shim (39.5x64x0.3)	0
11	09282-39001	Oil Seal (38x51x5)	1
12	09380-38003	Circlip	1
13	41220-93J12	LEVER,TILT LOCK	1
14	41234-93J12	LEVER,TILT LOCK	1
15	41224-95E01	Tilt Stopper Rod Bushing	2
16	41230-96J00	Tilt Lock Lever Link	1
17	41233-95E10	Tilt Lock Spring Bracket	1
18	09125-06063	Screw (6x10)	1
19	09140-10032	Nut	1
20	09160-06082	Washer (6.5x13x1.0)	1
21	09204-01006	Cotter Pin	1
22	09440-19028	Spring	1
23	09443-10043	Tilt Lock Spring	1

Fig. 29Swivel Bracket w/Transom (L)

图 336B带船尾板旋转支架(L型) Swivel Bracket w/Transom (L) Fig.

REF	Part No.	Name	Qty
1	22511-99011	Grease Nipple	4
2	36894-87D00	Wire Lead (L:195)	1
4	43211-93J11	Clamp Shaft Swivel Bushing	2
5	43711-97E11	Steering Bushing	2
7	09125-06063	Screw (6x10)	2
8	09160-39001	Washer (39.5x64x1.0)	2
9	09181-39001	Shim (39.5x64x0.3)	4
10	09380-38003	Circlip	1
11	09169-28003	Washer (26.2x52x1)	2
12	09282-39001	Oil Seal (38x51x5)	1
13	36895-87D10	Wire Lead (L:310)	1
14	09125-06063	Screw (6x10)	1
15	41220-96J11	LEVER,TILT LOCK	1
16	41234-96J11	LEVER,TILT LOCK	1
17	41224-95E01	Tilt Stopper Rod Bushing	2
18	41230-96J00	Tilt Lock Lever Link	1
19	41233-95E10	Tilt Lock Spring Bracket	1
20	09125-06063	Screw (6x10)	1
21	09140-10032	Nut	1
22	09160-06082	Washer (6.5x13x1.0)	1
23	09204-01006	Cotter Pin	1
24	09440-19028	Spring	1
25	09443-10043	Tilt Lock Spring	1
26	09125-06063	Screw (6x10)	2

Fig. 30Trim Cylinder w/Transom (X or XX)

图 337A带艉板升降油缸(X/XX型) Trim Cylinder w/Transom (X or XX) Fig.

REF	Part No.	Name	Qty
1	48000-98J14	TRIM ASSY,POWER	1
2	31281-92J10	Through Bolt	4
3	38100-93J05	PTT Motor Assembly	1
4	48500-98J14	MANIFOLD ASSY	1
5	48864-98L01	MANUAL VALVE	1
6	48320-93J00	Valve Set	1
7	48582-95E01	Filter	1
8	48605-93J00	O-Ring Set	2
9	48615-87D00	Backup Ring	4
10	48610-93J01	Trim Piston & Ram	2
11	48630-98L02	ROD GUIDE	2
12	48633-93J00	O-Ring	4
13	48691-93J00	Check Valve	1
14	48400-98J03	Cylinder Assembly	1
15	48405-93J00	Tilt O-Ring Set	1
16	48650-93J00	Free Piston	1
17	48627-93J00	O-Ring Set	1
18	48427-87D00	Tilt Piston O-Ring (NLA)	1
19	48572-87J10	Plug	1
20	48585-95E00	O-Ring	1
21	48585-98L00	O-RING	1
22	48862-87J20	Reservoir Tank Bolt	2
23	48583-95E00	Drive Joint	1
24	48121-93J20	Tilt Cylinder Shaft	1
25	48125-93J10	O-Ring Set	1
26	48451-93J00	Back Up Ring	4
27	48452-93J00	O-Ring	4
28	48452-93J10	O-Ring	2
29	48126-93J00	Nylon Washer	2
30	48573-93J00	Cover	1
31	48128-93J11	Bolt	1
32	48571-93J00	Resevoir Tank	1
33	48311-96J10	Trim Cylinder Ram Pad	2
34	48321-93J00	Tilt Cylinder Upper Shaft	1
35	09140-10031	Nut (10mm)	2
36	09162-10005	Lock Washer	2
37	09306-24001	Tilt Cylinder Upper Bushing	2
38	09380-21002	Tilt Cylinder Circlip	2
39	09116-10175	Bolt (10x50)	8
40	36894-87D00	Wire Lead (L:195)	1
41	36894-87D00	Wire Lead (L:195)	1
42	36895-87D01	Wire Lead (L:210)	1
43	09125-06063	Screw (6x10)	1
44	09125-06063	Screw (6x10)	1
45	09125-06063	Screw (6x10)	1

Fig. 31Trim Cylinder w/Transom (L)

图 337B带艉板升降油缸(L型) Trim Cylinder w/Transom (L) Fig.

REF	Part No.	Name	Qty
1	48000-93L04	TRIM ASSY,POWER	1
3	31281-92J10	Through Bolt	4
4	38100-93L01	PTT Motor Assembly	1
5	48502-96J05	PTT Pump Assembly	1
6	48582-95E01	Filter	1
7	48864-96J10	Manual Valve Set	1
8	48503-93L00	Manifold Sub Assembly	1
9	48401-93L00	Piston Assembly	1
10	48601-93L00	Piston & Ram Assembly	1
11	48627-95E00	O-Ring Set	3
12	48630-96J04	Replaced by 48630-96JV0	2
13	48633-94900	O-Ring Set (Pack of 2)	2
14	48641-93L00	PTT Manifold	1
15	48650-94900	Free Piston	1
16	48405-93J00	Tilt O-Ring Set	1
17	48615-97E00	Piston Ring Set	1
18	48570-95E01	Reservoir Assembly	1
19	48572-95E00	Cap	1
20	48583-95E00	Drive Joint	1
21	48585-95E00	O-Ring	1
22	48588-94900	O-Ring (Pack of 6)	1
23	48861-92J01	Reservoir Bolt	3
24	48862-92J20	Pump Bolt No. 1	1
25	48862-92J30	Pump Bolt No. 2	2
26	48121-93L00	Tilt Cylinder Lower Shaft	1
27	09160-10161	Washer	2
28	48311-96J20	Trim Cylinder Ram Pad	2
29	48321-87D03	Tilt Cylinder Upper Shaft	1
30	48326-95E00	Tilt Cylinder Lower Bushing	2
31	09116-10183	Bolt (10x35)	2
32	09140-10031	Nut (10mm)	2
33	09162-10005	Lock Washer	2
34	09306-17001	Bushing	2
35	09380-17009	Circlip	2
36	36894-87D00	Wire Lead (L:195)	1
37	09125-06063	Screw (6x10)	1
38	09125-05050	Screw (5x8)	1
39	36895-87D10	Wire Lead (L:310)	1

Fig. 32PTT Motor w/Transom (X or XX)

图 340A带艉板(X或XX型)马达 PTT Motor w/Transom (X or XX) Fig.

REF	Part No.	Name	Qty
1	38100-93J05	PTT Motor Assembly	1
2	31111-94900	Yoke Screw	3
3	31173-94920	Brush Holder Assembly	1
4	31123-94910	O-Ring	1
5	31133-90J20	Brush Assembly	1
6	31133-94910	Brush	1
7	31135-94900	Spring	2
8	31136-90J30	Breaker Assembly	1
9	33799-97E00	Oil Seal	1
10	31311-93J00	Armature (NLA)	1

Fig. 33PTT Motor w/Transom (L)

图 340B带艉板(L型)马达 PTT Motor w/Transom (L) Fig.

REF	Part No.	Name	Qty
1	38100-93L01	PTT Motor Assembly	1
2	31111-94900	Yoke Screw	3
3	31173-94920	Brush Holder Assembly	1
4	31123-94910	O-Ring	1
5	31133-90J20	Brush Assembly	1
6	31133-94910	Brush	1
7	31135-94900	Spring	2
8	31136-90J30	Breaker Assembly	1
9	33799-97E00	Oil Seal	1
10	31311-94900	Armature (NLA)	1

Fig. 34Engine Holder

REF	Part No.	Name	Qty
2	16519-93J00	Engine Holder Seal	1
3	17913-93J00	Water Flush Plug	1
4	17914-93J01	Water Flush Plug Gasket	1
5	51116-93J01	Water Return Seal	1
6	51211-93J00	Engine Holder Gasket	1
7	61155-93J20	Water Indicator Union	1
8	09206-08001	Knock Pin (8x11)	2
9	01550-08307	BOLT	6
10	22511-99011	Grease Nipple	1
11	51120-98L00	Mount Oil Seal Cover Assembly	1
12	51124-93J01	Oil Seal (Drive Shaft)	2
13	51125-93J00	Scrapper	1
14	51123-93J01	Mount Oil Seal Cover Gasket	1
15	09103-08109	Bolt (8x120)	2
16	09206-08001	Knock Pin (8x11)	2
17	01550-0830A	BOLT	6
19	51142-93J00	Engine Holder Cover Gasket	1
20	09116-08122	Bolt (8x30)	8
21	51151-93J00	Engine Holder Upper Cover	1
22	51152-93J00	Engine Holder Upper Cover Seal	1
23	01550-08307	BOLT	3
24	01550-08607	BOLT	2
25	54123-93J03	Upper Mount Plate	1
26	54130-93J02	MOUNT,UPPER	2
27	54112-93J00	Upper Mount Bolt	2
28	29159-93J00	Upper Mount Bolt Nut	2
29	09160-15051	Upper Mount Bolt Washer	2
30	54137-93J02	Upper Mount Cover	1
31	09116-10135	Bolt (10x95)	2
32	09116-10175	Bolt (10x50)	1
34	54140-98J01	MOUNT,UPR THRUS	1
35	09116-10137	Bolt (10x70)	6
36	09116-10175	Bolt (10x50)	4
37	09116-10146	Bolt (10x195)	2
38	09116-10134	Bolt (10x115)	1
39	09116-08126	Bolt (8x65)	4
40	09169-08038	Washer (8.3x15x3)	2
41	54144-93J01	SEAL,UPPER MOUN	1

Fig. 35Drive Shaft Housing w/Transom (X)

图 405A驱动轴壳体带艉板(X型) Drive Shaft Housing w/Transom (X) Fig.

REF	Part No.	Name	Qty
2	09116-10176	Bolt (10x44)	8
3	09202-08006	Knock Pin (8x12)	2
4	57130-87D10	Drive Shaft Bushing	1
5	09387-39002	RING,DRIVE SHAF	1
6	09125-06063	Screw (6x10)	1
7	36894-87D00	Wire Lead (L:195)	1
8	09125-06063	Screw (6x10)	1
9	54150-98J01	MOUNT,LWR THRUS	1
10	54160-98J00	Lower Mount	2
11	54112-93J00	Upper Mount Bolt	2
12	09160-16050	Lower Mount Washer	2
13	29159-93J00	Upper Mount Bolt Nut	2
14	09160-16050	Lower Mount Washer	2
17	09116-10175	Bolt (10x50)	4
18	54165-98J01	Lower Thrust Reverse Stopper	4
19	09160-14066	Reverse Stopper Lower Washer	2
21	09116-06236	Bolt (6x16)	1

Fig. 36Drive Shaft Housing w/Transom (XX)

图 405B驱动轴壳体带艉板(XX型) Drive Shaft Housing w/Transom (XX) Fig.

REF	Part No.	Name	Qty
2	09116-10176	Bolt (10x44)	8
3	09202-08006	Knock Pin (8x12)	2
4	57130-87D10	Drive Shaft Bushing	1
5	09387-39002	RING,DRIVE SHAF	1
6	09125-06063	Screw (6x10)	1
8	09108-10115	Stud Bolt	6
9	09108-12013	Extension Bolt	1
10	09202-08006	Knock Pin (8x12)	2
11	36894-87D00	Wire Lead (L:195)	1
12	09125-06063	Screw (6x10)	1
13	54150-98J01	MOUNT,LWR THRUS	1
14	54160-98J00	Lower Mount	2
15	54112-93J00	Upper Mount Bolt	2
16	09160-16050	Lower Mount Washer	2
17	29159-93J00	Upper Mount Bolt Nut	2
18	09160-16050	Lower Mount Washer	2
21	09116-10175	Bolt (10x50)	4
22	54165-98J01	Lower Thrust Reverse Stopper	4
23	09160-14066	Reverse Stopper Lower Washer	2
25	09116-06236	Bolt (6x16)	2

Fig. 37Drive Shaft Housing w/Transom (L)

图 405C驱动轴壳体带艉板(L型) Drive Shaft Housing w/Transom (L) Fig.

REF	Part No.	Name	Qty
2	09116-10176	Bolt (10x44)	6
3	09202-08006	Knock Pin (8x12)	2
4	09140-10031	Nut (10mm)	2
5	09108-10150	Stud Bolt (NLA)	2
6	09160-10141	Washer (10.5x19x2)	2
7	09125-06063	Screw (6x10)	1
8	54150-98J01	MOUNT,LWR THRUS	1
9	54160-98J00	Lower Mount	2
10	54112-93J00	Upper Mount Bolt	2
11	09160-16050	Lower Mount Washer	2
12	29159-93J00	Upper Mount Bolt Nut	2
13	09160-16050	Lower Mount Washer	2
16	09116-10175	Bolt (10x50)	4
17	54165-98J01	Lower Thrust Reverse Stopper	4
18	09160-14066	Reverse Stopper Lower Washer	2
19	36894-87D00	Wire Lead (L:195)	1
20	09125-06063	Screw (6x10)	1

Fig. 38Gear Case

REF	Part No.	Name	Qty
2	09263-35048	Bearing (35x56x37)	1
3	09263-80001	Bearing (80x100x30)	1
6	09160-10141	Washer (10.5x19x2)	6
7	09160-12066	Washer (12.5x22x2.5)	1
8	09140-10031	Nut (10mm)	6
9	09159-12014	Nut (12x17)	1
10	09202-08006	Knock Pin (8x12)	2
12	09116-08137	Bolt (8x22)	1
13	55128-93J10	Drain Plug	1
14	09168-10038	GASKET,DRAIN PL	2
16	09116-06236	Bolt (6x16)	2
17	55332-98J01	Exhaust Seal Rubber	1
18	55333-98J00	Exhaust Seal Plate	1
19	09202-06031	Knock Pin (6x12)	2
21	58120-93L00	Watergrip Propeller Bushing Set	1
24	57632-93L11	Watergrip Propeller Bushing Stopper	1
25	57633-93L00	Watergrip Propeller Nut Spacer	1
26	09141-18005	Nut (18mm)	1
27	09160-18028	Washer (18.5x31x1.0)	1
28	09204-03003	Prop Nut Cotter Pin	1
29	55128-93L00	Drain Plug w/Magnet	1
30	09160-12066	Washer (12.5x22x2.5)	1
31	57630-93L00	Watergrip Propeller Hardware Kit	1
32	25700-93L02	Gear Case Seal Kit - DF 250A/250AP/300A/300AP	1

Fig. 39Side Cover w/Transom (X or XX)

图 410A带船尾板侧盖 (X/XX型) Side Cover w/Transom (X or XX) Fig.

REF	Part No.	Name	Qty
3	61137-93J01	Oil Pan Cover Upper Cushion	2
4	09139-06135	Oil Pan Cover Screw (6x17)	5
5	09139-06136	Oil Pan Cover Screw (6x65)	3
8	61134-93J21	Side Cover Seal	1
10	61817-93J01	Side Cover Plug	2
11	09139-06249	SCREW	10
12	61827-93J02	Side Cover Holder	1
13	09321-10049	CUSHION,SIDE CO	2
14	01550-08167	BOLT	2
15	61832-98J00	Front Panel Starboard Seal	1
16	61812-98J00	Side Cover Seal	1
17	61814-98J00	Side Cover Protector (NLA)	1
19	09116-08174	Bolt (8x38)	2
20	09169-08050	Front Panel Washer	2
21	09320-11023	CUSHION,FRONT P	2
22	09321-10049	CUSHION,SIDE CO	3
23	17913-93J00	Water Flush Plug	1
24	17914-93J01	Water Flush Plug Gasket	1
25	61112-98J00	Side Cover Rubber	1
26	61630-98J00	Cover Hook Shaft (NLA)	1
27	63632-98J20	Cover Hook Shaft	1
28	63632-98J30	Cover Hook Shaft	1
29	09306-17002	Bushing	3
30	09160-17052	Washer	3
31	61636-98J00	Bushing	3
35	29103-93J20	Bolt (8x45)	2
36	29103-93J30	Bolt (8x25)	1
37	09160-08152	Washer (8.5x28x1.5)	2
38	09160-08082	Washer (8.5x16x1.2)	1
39	61635-98J00	Spacer	2
40	61643-98J00	Bushing	2
41	61658-98J00	Hook Shaft Spring	3
42	09329-14003	Side Cover Cushion	1
43	61124-98J30	GROMMET,R/CON C	1
44	09407-25402	Clamp (L:248)	1
45	61458-90J01	Engine Cover Label	1
46	67361-90J10	Rigging Hose Adapter	1
47	09208-06011	PIN,HOSE ADAPTE	2

Fig. 40Side Cover w/Transom (L)

图 410B带船尾板侧盖 (L型) Side Cover w/Transom (L) Fig.

REF	Part No.	Name	Qty
3	61137-93J01	Oil Pan Cover Upper Cushion	2
4	09136-06161	Screw (6x17)	8
5	09139-06249	SCREW	3
8	61134-93J21	Side Cover Seal	1
9	09409-05302-5PK	Pin	2
10	61817-93J01	Side Cover Plug	2
11	09139-06249	SCREW	8
12	61827-93J02	Side Cover Holder	1
13	09321-10049	CUSHION,SIDE CO	2
14	01550-08167	BOLT	2
15	61832-98J00	Front Panel Starboard Seal	1
16	61812-98J00	Side Cover Seal	1
17	61814-98J00	Side Cover Protector (NLA)	1
19	09116-08174	Bolt (8x38)	2
20	09169-08050	Front Panel Washer	2
21	09320-11023	CUSHION,FRONT P	2
22	09321-10049	CUSHION,SIDE CO	3
23	17913-93J00	Water Flush Plug	1
24	17914-93J01	Water Flush Plug Gasket	1
25	61112-98J00	Side Cover Rubber	1
26	61630-98J00	Cover Hook Shaft (NLA)	1
27	63632-98J20	Cover Hook Shaft	1
28	63632-98J30	Cover Hook Shaft	1
29	09306-17002	Bushing	3
30	09160-17052	Washer	3
31	61636-98J00	Bushing	3
35	29103-93J20	Bolt (8x45)	2
36	29103-93J30	Bolt (8x25)	1
37	09160-08152	Washer (8.5x28x1.5)	2
38	09160-08082	Washer (8.5x16x1.2)	1
39	61635-98J00	Spacer	2
40	61643-98J00	Bushing	2
41	61658-98J00	Hook Shaft Spring	3
42	09329-14003	Side Cover Cushion	1
43	61124-98J30	GROMMET,R/CON C	1
44	09407-25402	Clamp (L:248)	1
45	61458-90J01	Engine Cover Label	1
46	67361-90J10	Rigging Hose Adapter	1
47	09208-06011	PIN,HOSE ADAPTE	2

Fig. 41Engine Cover

REF	Part No.	Name	Qty
3	61432-98J01	Air Intake Louver	1
4	61433-98J01	Upper Cover Starboard Grip	1
5	61434-98J02	Upper Cover Port Grip	1
6	61439-98J01	SEAL,GRIP STBD	1
7	61439-98J10	Port Grip Seal	1
8	61439-98J21	Air Vent No 2 Seal (NLA)	1
9	61476-98J00	Air Vent No 1 Seal	1
10	01550-06167	BOLT	2
11	01550-06207	BOLT	3
12	01550-06167	BOLT	3
13	03542-06169	SCREW	5
14	01550-06167	BOLT	4
15	03542-06169	SCREW	4
16	61610-98J00	Front Fastener	1
17	61610-98J30	Port Fastener (NLA)	1
18	61610-98J40	Starboard Fastener	1
19	77811-54GC0-0PG	Chrome S Emblem	1
20	61614-98J00	Fastener Protector (NLA)	1
21	61621-98J03	BRACKET,FASTENE	1
22	61624-98J12	BRACKET,FASTENE	1
23	61625-98J12	BRACKET,FASTENE	1
24	61619-98J00	Engine Cover Fastener Cushion	3
25	01547-06167	BOLT 6X16	6
26	01550-06127	BOLT	1
27	01550-06127	BOLT	2
28	61425-98J00	Engine Cover Cushion	1
31	61441-98L00	Suzuki Mark	2
33	09800-81835	Tool Set	1
34	99011-98JA1-03B	99011-98JA1-03B	1
35	99011-98J90-03B	Owners Manual DF250AP/DF300AP - 2020	1

Fig. 42Squeeze Pump

REF	Part No.	Name	Qty
1	65770-93J04	Squeeze Pump	1

Fig. 43Opt: Flush Mount Remocon

图 520选配:嵌入式遥控器 Opt: Flush Mount Remocon Fig.

REF	Part No.	Name	Qty
1	67200-98J24	Flush Mount Precision Control	1
2	67271-98J20	Bottom Base Cover (NLA)	1
3	67264-98J00	Top Base Cover (NLA)	1
4	67263-98J20	Lever Cover (NLA)	1
5	67261-98J20	Grip A (NLA)	1
6	67261-98J30	Grip B (NLA)	1
7	67265-98J00	Neutral Lock Button (NLA)	1
8	67255-98J00	Neutral Lock Link No 1 (NLA)	1
9	67258-98J00	Joint Plate (NLA)	1
10	67256-98J00	Neutral Lock Block (NLA)	1
11	67259-98J00	Spring (NLA)	3
12	67251-98J20	Handle Lever (NLA)	1
13	67294-98J00	Spacer (NLA)	1
14	67254-98J00	Neutral Lock Link No 2 (NLA)	1
15	67233-98J00	Neutral Button Slider (NLA)	1
16	67296-98JA0	Screw (4x10) (NLA)	3
17	67234-98J00	Lever Plate (NLA)	1
18	67211-98J20	Housing (L) (NLA)	1
19	67269-98J20	Lead Clamp (NLA)	1
20	67296-98JB0	Screw (4x30) (NLA)	1
21	67227-98J20	Screw (4x35) (NLA)	1
22	67227-98J30	Screw (4x20) (NLA)	1
23	67288-98J50	Washer	8
24	67296-98JC0	Screw (6x40) (NLA)	4
25	67287-98J00	Nut (NLA)	4
26	67226-98J10	Bolt (6x50) (NLA)	4
27	67288-98J60	Washer (NLA)	3
28	67296-98JD0	Screw (5x40) (NLA)	1
29	67238-98J00	Pin (NLA)	2
30	67288-98J70	Washer (NLA)	5
31	67246-98J00	Drive Shaft (NLA)	1
32	67222-98J00	Back Panel Assembly (NLA)	1
33	67236-98J00	Detent Roller (NLA)	1
34	67235-98J00	Detent Roller Guide (NLA)	1
35	67237-98J00	Detent Spring (NLA)	1
36	67223-98J00	Brake Pad (NLA)	1
37	67296-98JE0	Screw (5x35) (NLA)	1
38	67252-98J00	Drive Shaft Bushing (NLA)	1
39	67288-98J20	Washer (NLA)	1
40	67292-98J00	C-Ring (NLA)	1
41	15980-98J00	Potentiometer	1
42	67227-98J10	Potentiometer No. 2 Lever	1
43	67296-94300	Screw (4x10)	2
44	67288-98J00	Potentiometer Washer (NLA)	5
45	67296-98J10	Screw (5x35) (NLA)	1
46	67288-98J10	Spring Washer (NLA)	8
47	67228-98J50	Wave Washer (NLA)	2
48	67296-98J60	Screw (8x30)	1
49	09160-06104	Washer (6.5x24x2)	4
50	67296-98J50	Screw (5x18) (NLA)	2
51	67272-98J00	Cover Grommet	2
52	37850-98J03	PTT Switch Assembly	1
53	67269-98J10	Band (NLA)	1
54	68165-98J00	Lever Mark (Suzuki)	1
55	36890-98J00	Condenser Adapter Harness	1

Fig. 44Opt: Harness (1)

REF	Part No.	Name	Qty
2	33830-98J11	Battery Isolator Lead Set	1
3	09407-10404	Clamp (L:100)	2
4	09481-40401	40 Amp Fuse	1
5	33911-88BL0	BCM Connector Cap	1
6	33925-93J00	ECU/BCM Cushion	0
7	33926-98J00	Terminal Resistor	0
8	36623-98J21	BCM Harness No 1	1
9	36615-96300	Resin Terminal	4
11	36775-98J00	BCM Holder (L)	0
12	36776-98J00	BCM Holder (R)	0
13	36622-98J00	Dual Station Main Harness	0
14	09481-10501	10 Amp Fuse	0
15	36624-98J02	BCM Harness No 2	1
16	36615-96300	Resin Terminal	2
17	36621-98J00	Dual Engine/Single Station Harness	0
18	36623-98J30	BCM Harness No 1	1
19	36615-96300	Resin Terminal	5
20	36624-98J11	BCM Harness No 2	1
21	36615-96300	Resin Terminal	2
22	36621-98J10	Triple Engine/Single Station Harness	1
23	09403-13402	Harness Clamp (NLA)	20
24	36612-98J20	Counter Rotation Selector - White	0
25	36990-87D00	Terminal & Sleeve Set	1
26	36667-96L20	Gauge Extension Wire	1

Fig. 45Opt: Harness (2)

REF	Part No.	Name	Qty
1	36625-98J10	Battery Wire Assembly	1
2	09481-30501	30 Amp Fuse	1
3	36623-98J40	BCM Harness No 1	1
4	36615-96300	Resin Terminal	8
5	36627-98J00	Harness Extension	1
6	17917-87L00	Water Flush Connector	1

Fig. 46Opt: Switch

REF	Part No.	Name	Qty
1	37100-98J07	Main Switch Panel Assemby	1
2	37110-98J02	Main Switch Assembly	1
4	37143-99E01	Key Cap	1
5	37139-98J10	Main Switch Panel	1
6	37820-93J11	Emergency Stop Switch Assembly	1
7	37823-92E02	Stop Switch Lanyard	1
8	37826-92J00	Nut	1
9	03122-05165	SCREW	4
10	37114-98J00	Main Swtich Panel Sheet (NLA)	1
11	37100-98J11	Single Engine Control Panel	1
12	37112-98J00	Nut (NLA)	1
13	38500-93J90	Warning Buzzer	1
14	09407-14403	Clamp (L:125)	1
15	37803-93J06	Emergency Stop Switch Panel Assembly	1
16	37825-99E10	Emergency Switch Panel	1
17	37820-93J11	Emergency Stop Switch Assembly	1
18	37823-92E02	Stop Switch Lanyard	1
19	37826-92J10	Nut	1
20	03122-05165	SCREW	4
21	37100-98J21	Dual Engine Control Panel	1
22	37112-98J10	Nut (NLA)	1
23	37100-98J31	Triple Engine Control Panel	1
24	37112-98J10	Nut (NLA)	1
25	37860-87L00	Trolling Mode Control Switch Assembly	1
26	37862-87L00	Trolling Switch Panel	1
27	09131-05004	Screw (5x16)	4

Fig. 47Opt: Top Mount Dual

图 540选配: 顶置双联支架 Opt: Top Mount Dual Fig.

REF	Part No.	Name	Qty
1	67200-98J15	Multi Engine SPC 1.0 Control	1
2	67211-98J20	Housing (L) (NLA)	1
3	67251-98J00	Handle Lever	2
4	67246-98J10	Drive Shaft (NLA)	1
5	67261-98J00	Grip No. 1	1
6	67261-98J10	Grip No. 2 (NLA)	1
7	67263-98J00	Lever Cover (NLA)	2
8	67212-98J30	Upper Cover	1
9	67271-98J40	Bottom Cover	1
10	67222-98J10	Back Panel Assembly (NLA)	1
11	67236-98J10	Detent Roller (NLA)	2
12	67235-98J10	Detent Roller Guide (NLA)	2
13	67237-98J40	Detent Spring (NLA)	2
15	67287-92E00	Nut	2
16	67239-98J00	Detent Adjust Screw (NLA)	2
17	67223-98J00	Brake Pad (NLA)	2
18	67296-98J50	Screw (5x18) (NLA)	8
19	67296-98JA0	Screw (4x10) (NLA)	2
20	67272-98J10	Cover Grommet	2
21	67252-98J10	Drive Shaft Bushing	2
22	67288-98J20	Washer (NLA)	2
23	67292-98J00	C-Ring (NLA)	2
24	15980-98J00	Potentiometer	2
25	67227-98J10	Potentiometer No. 2 Lever	1
26	37850-98J03	PTT Switch Assembly	1
27	67269-98J00	Lead Clamp (NLA)	1
28	67273-98J20	Packing (NLA)	1
29	67296-98J60	Screw (8x30)	2
30	67296-98J30	Screw (5x70) (NLA)	4
31	67296-98J80	Lever Cover Screw	2
32	67296-98J00	Clamp Screw (NLA)	1
33	67296-94300	Screw (4x10)	4
34	67288-98J40	Bottom Cover Washer (NLA)	14
35	67288-98J00	Potentiometer Washer (NLA)	4
36	67288-92E20	Washer	2
37	67226-98J00	Bolt (5x50)	4
38	09160-05024	Washer (5.5x16x1.5)	4
39	67287-92E00	Nut	4
40	67296-98J90	Screw (8x30) (NLA)	2
41	67227-98J00	Potentiometer No. 1 Lever	1
42	67284-98J00	Mark (F-N-R)	1
43	67257-98J00	Lever Mark (S)	2
44	67269-98J30	Band (NLA)	1
45	67288-98J10	Spring Washer (NLA)	16
46	67288-98J30	Lever Cover Washer (NLA)	2
47	67228-98J50	Wave Washer (NLA)	2
48	67211-98J30	Housing (R)	1
49	67222-98J20	Back Panel Assembly	1
50	67246-98J20	Drive Shaft	1
51	67273-98J10	Front Packing (NLA)	1
52	67273-98J30	Rear Packing (NLA)	1
53	67277-98J00	Grommet	1
54	67296-98JF0	Upper Cover Bolt	1
55	67297-98J00	Upper Cover Nut	1
56	67237-98J50	Detent Spring (NLA)	2
57	36890-98J00	Condenser Adapter Harness	1

Fig. 48Opt: Top Mount Single

图 543选配: 顶置单联支架 Opt: Top Mount Single Fig.

REF	Part No.	Name	Qty
2	67211-98J20	Housing (L) (NLA)	1
3	67251-98J00	Handle Lever	1
4	67246-98J10	Drive Shaft (NLA)	1
5	67261-98J00	Grip No. 1	1
6	67263-98J00	Lever Cover (NLA)	1
7	67212-98J20	Upper Cover	1
8	67271-98J30	Bottom Cover	1
9	67222-98J10	Back Panel Assembly (NLA)	1
10	67236-98J00	Detent Roller (NLA)	1
11	67235-98J10	Detent Roller Guide (NLA)	1
12	67237-98J30	Detent Spring (NLA)	1
13	67233-98J10	Detent Spring Holder (NLA)	1
14	67287-92E00	Nut	1
15	67239-98J00	Detent Adjust Screw (NLA)	1
16	67223-98J00	Brake Pad (NLA)	1
17	67296-98J50	Screw (5x18) (NLA)	6
18	67296-98JA0	Screw (4x10) (NLA)	1
19	67272-98J10	Cover Grommet	1
20	67252-98J10	Drive Shaft Bushing	1
21	67288-98J20	Washer (NLA)	1
22	67292-98J00	C-Ring (NLA)	1
23	15980-98J00	Potentiometer	1
24	67227-98J10	Potentiometer No. 2 Lever	1
25	37850-98J03	PTT Switch Assembly	1
26	67269-98J00	Lead Clamp (NLA)	1
27	67273-98J00	Packing (NLA)	1
28	67296-98J60	Screw (8x30)	1
29	67274-98J00	Base Flange (NLA)	1
30	67288-92E20	Washer	1
31	67296-98J90	Screw (8x30) (NLA)	1
32	67296-98J80	Lever Cover Screw	1
33	67296-94300	Screw (4x10)	2
34	67288-98J00	Potentiometer Washer (NLA)	2
35	67296-98J20	Screw (5x50) (NLA)	2
36	67226-98J00	Bolt (5x50)	4
37	09160-05024	Washer (5.5x16x1.5)	4
38	67287-92E00	Nut	4
39	67296-98J00	Clamp Screw (NLA)	1
40	67288-98J40	Bottom Cover Washer (NLA)	12
41	67296-98J10	Screw (5x35) (NLA)	1
42	67284-98J10	Mark (F-N-R)	1
43	67257-98J00	Lever Mark (S)	1
44	67269-98J30	Band (NLA)	1
45	67288-98J10	Spring Washer (NLA)	8
46	67288-98J30	Lever Cover Washer (NLA)	1
47	67228-98J50	Wave Washer (NLA)	1
48	67273-98J10	Front Packing (NLA)	1
49	67273-98J30	Rear Packing (NLA)	1
50	67277-98J00	Grommet	1
51	67296-98JF0	Upper Cover Bolt	1
52	67297-98J00	Upper Cover Nut	1
53	36890-98J00	Condenser Adapter Harness	1

Fig. 49Opt: Gasket Set

REF	Part No.	Name	Qty
1	11410-98832	GASKET SET	1
2	11141-98J10	Starboard Cylinder Head Gasket	1
3	11142-98J10	Port Cylinder Head Gasket	1
4	11179-93J00	Cylinder Head Cover Gasket - Starboard	1
5	11189-93J00	Cylinder Head Cover Gasket - Port	1
6	11332-93J00	Crankcase Water Jacket Cover Gasket	1
7	13119-98J00	Intake Manifold Gasket	2
8	14151-93J00	Starboard Exhaust Cover Gasket	1
9	14152-93J01	GASKET,EXH CVR(	1
10	17472-98J00	Water Pump Plate Gasket	1
11	11272-93J00	Cylinder Block Plate Gasket	1
12	11489-93J00	Oil Pan Gasket	1
13	14212-93J00	Exhaust Tube Gasket	1
14	51123-93J01	Mount Oil Seal Cover Gasket	1
15	51142-93J00	Engine Holder Cover Gasket	1
16	51211-93J00	Engine Holder Gasket	1

Fig. 50Opt: Multi Function Gauge (1)

图 601选配: 多功能仪表(1) Opt: Multi Function Gauge (1) Fig.

REF	Part No.	Name	Qty
2	34011-96L42	SMG4 Multi Function Gauge	1
3	34112-96L00	Gauge Nut	1
4	34193-96L00	Gauge Bezel	1
5	34211-96L00	Multi-Function Gauge Sun Cover	1
6	34825-96L00	Gauge Packing	1
7	36661-96L20	SPC Engine Adapter 1.0	1
8	36615-96300	Resin Terminal	5
10	34011-96L42	SMG4 Multi Function Gauge	2
11	34112-96L00	Gauge Nut	2
12	34193-96L00	Gauge Bezel	2
13	34211-96L00	Multi-Function Gauge Sun Cover	2
14	34825-96L00	Gauge Packing	2
15	36661-96L20	SPC Engine Adapter 1.0	1
16	36615-96300	Resin Terminal	5
17	990C0-88104	2' Extension cable	2
18	990C0-88112	SMIS Power Cable	1
19	990C0-88110	T-Connector	2
20	990C0-88113	Terminating Resistor 120 ohm Female	1
21	990C0-88114	Terminating Resistor 120 ohm Male	1
22	36667-96L00	SPC Multi Engine Adapter 1.0	1
23	36667-96L11	2nd Gauge Adapter	1
24	36667-96L30	Gauge Adapter for Tanks 3-4	1

Fig. 51Opt: Multi Function Gauge (2)

图 602选配: 多功能仪表(2) Opt: Multi Function Gauge (2) Fig.

REF	Part No.	Name	Qty
1	990C0-96L15-KIT	990C0-96L16-KIT	1
2	34011-96L42	SMG4 Multi Function Gauge	1
3	34112-96L00	Gauge Nut	1
4	34193-96L00	Gauge Bezel	1
5	34211-96L00	Multi-Function Gauge Sun Cover	1
6	34825-96L00	Gauge Packing	1
7	990C0-88104	2' Extension cable	1
8	990C0-88110	T-Connector	1
9	36665-96L00	Dual Station Adapter	1
10	36666-96L00	Gauge Power Adapter (Dual Station)	1
11	36682-92E00	Wire Harness	1
12	34011-96L42	SMG4 Multi Function Gauge	1
13	34112-96L00	Gauge Nut	1
14	34193-96L00	Gauge Bezel	1
15	34211-96L00	Multi-Function Gauge Sun Cover	1
16	34825-96L00	Gauge Packing	1
17	36001-88L00	Wire Set	1
18	990C0-88104	2' Extension cable	1
19	990C0-88112	SMIS Power Cable	1
20	990C0-88110	T-Connector	1
21	990C0-88113	Terminating Resistor 120 ohm Female	1
22	990C0-88114	Terminating Resistor 120 ohm Male	1
24	990C0-88105	6' Extension cable	1
25	990C0-88107	15' Extension cable	1
26	990C0-88122	GPS Receiver Module	1
27	990C0-88108	25' Extension cable	1
28	990C0-88112	SMIS Power Cable	1
29	990C0-88113	Terminating Resistor 120 ohm Female	1
30	990C0-88114	Terminating Resistor 120 ohm Male	1
31	990C0-88104	2' Extension cable	1
32	990C0-88110	T-Connector	1